2021 FORD EXPLORER Complaints

The contact owns a 2021 Ford Explorer. The contact stated that while driving at an undisclosed speed, the front driver’s door window independently rolled down. In addition, the contact stated that the failure had previously occurred with the front passenger’s and rear driver’s side windows. The contact stated that during the first failure the vehicle was repaired by the dealer and covered under warranty. After the second failure, the vehicle was repaired by an independent mechanic and the contact paid out-of-pocket. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure but provided no assistance. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 68,188.

The contact owns a 2021 Ford Explorer. The contact stated that while the vehicle was parked, the rearview camera became inoperable. The contact stated that the rearview camera image was blank. The contact received notification of NHTSA Campaign Numbers: 25V159000 (Back Over Prevention) and 25V393000 (Seats). The vehicle was taken to the dealer but was not diagnosed or repaired. The dealer confirmed that parts were not yet available to repair the vehicle. The manufacturer was made aware of the failure. The approximate failure mileage was 90,000.

While driving, the panoramic sunroof shade on my vehicle failed to retract properly, sagging down into the rear visibility area. The shade hangs low enough to completely block the view through the rearview mirror, significantly impairing my ability to monitor traffic behind me. This is a serious safety hazard, particularly when changing lanes, merging, or reversing. The issue also impacts rear passengers, as the drooping shade hangs down into the back seat area. This obstruction makes it difficult to check on passengers—especially children—while driving. There were no warnings before this failure occurred, and research shows that this problem is common among other owners, as documented in multiple online forums and complaint records. The shade appears to have a design flaw where the guide sliders or attachment points fail, causing it to sag into the driver’s line of sight. This failure should not happen on a safety-critical component affecting visibility. Given the frequency of reports and the direct impact on driver awareness, a recall or mandatory repair campaign should be issued to address this defect in all affected vehicles.

I was driving down the road and heard a loud pop and it sounded like a golf ball hit my door. I immediately looked in my rear view mirror and was unable to see anything. After merging to the shoulder of the road and stopping safely I turned around and noticed that the headliner from my sun roof had broken and fallen and was blocking all view from my mirror.

Automatic roll up sun shade for the sunroof sags and does not retract anymore, causing visibility issues as it droops down. Car is out of factory bumper to bumper warranty, currently 52k miles, and the aftermarket warranty does not cover the shade. Ford quoted over $2000 for fix, when this is a manufacturer's defect and many cars are affected.

I was driving and pressed the button to open my sunroof (which has a powered sunshade) but the sunshade dropped down on top of the 2nd row seats, blocking my view through my rear view mirror and rear window completely. I made an appointment with my Ford dealer the next day. The dealer had my vehicle for over 30 days waiting for parts to fix the tensioner system that pulls the powered sunshade back in order for the sunroof to open. I've seen in multiple forums online that this has happened to a lot of other people that has this option on their Ford Explorers (2020-2024) models. This was definitely a safety hazard as I was unable to see anything behind me while I was moving and luckily I didn't panic. I pulled over slowly to the soft shoulder in order to try and get the sunshade to at least go back to it's "closed" state which it finally did after trying for a few minutes. I think Ford needs to make this a recall because of the safety issues of this blocking the view of the driver.

The auto/stop start system is malfunctioning. When I stop at a stop sign, or to turn left, the vehicle stops, but then does not turn on again when I press the gas pedal. Instead, I have to place the car in park and manually restart the engine. This has happened four times over a 2-month period. Sometimes it takes me 30 seconds to turn the car back on. This is harrowing when I am suddenly stuck in the middle of the road. I took my vehicle to the Ford Dealership after it happened three times. They had my vehicle for 3 weeks but could not find anything wrong, and the incident did not happen again. I’ve had my vehicle back for 6 days, and it happened again today at a stop sign. Suddenly, there was a message on my screen to place my car in park and restart the engine. There were many other cars waiting for me to turn.

The contact owns a 2021 Ford Explorer. The contact stated that while her husband was driving at an undisclosed speed, the brake pedal was sticking on three occasions. The contact stated that while driving at an undisclosed speed in a parking lot, the contact had to raise the brake pedal with her foot after the brake pedal was depressed. The contact stated that it felt like the parking brake was engaged. There were no warning lights illuminated. The vehicle was taken to the local dealer, where it was diagnosed that the power brake booster was inoperable. The part: L1MZ2005K - Ford Power brake booster was on back order for a month. The vehicle was taken to an independent mechanic who repaired the brakes, and informed the contact that the required parts were on back order for three months. The contact called the manufacturer, who confirmed the status of the parts, and that there was no release date for the parts. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 85,000.

My vehicle is equipped with a panoramic sunroof, furthermore the panoramic sunroof has a sliding screen to block out the sun when the owner prefers to block the sun. The issue is with the panoramic sunroof screen, this particular screen also slides on rails below the glass window from the panoramic sunroof. The sliders from the screen part seem to break and cause the screen to sag downward blocking the view from the rear view mirror. In which case it’s a safety hazard for the passengers and public due to limited visibility. Furthermore, it also blocks the view of monitoring the rear passengers in which in this case they are toddlers.

Center console cup holder base failure causing items to fall through and into the interior of the console. My key fob fell through the bottom and required nearly an hour to be retrieved. The problem is persistent with anything placed into the cup holder. This issue is common and well documented on forums and social media.