2003 FORD EXPLORER Complaints

CRACK IN REAR LIFTGATE BODY PANEL. MAY FAIL DURING OPENING/CLOSING AND CAUSE INJURY. THIS IS A KNOWN PROBLEM WITH 2002-2005 EXPLORERS. FORD KNEW ABOUT THE PROBLEM AND COVERED IT UP. THERE IS A CLASS ACTION LAWSUIT IN PROGRESS. *JS

I HAVE HAD THREE INCIDENTS WITH MY 2003 FORD EXPLORER. THE FIRST INCIDENT INVOLVED THE SUSPENSION ( SWAY BARS SNAPPED, TIRES HAD TO BE REPAIRED). SECOND INCIDENT WAS THE TRANSFER CASE AND A WIGGLING DRIVE SHAFT ALONG WITH REAR WHEEL BEARINGS ( PARTS DEEMED DEFECTIVE BY MECHANICS) , AND EMERGENCY BRAKES THAT SNAPPED OFF IN MY MECHANICS HANDS BECAUSE THEY WERE RUSTY. NOW IT IS TRANSMISSION WORK FOR A POSSIBLE FAULTY SENSOR. FORD NEEDS TO RECALLS BEFORE SOMEONE IS KILLED DUE TO CATASROPHIC EQUIPMENT FAILURE! IVE CALLED THEM EVERY TIME AND THEY ARE AWARE OF THE ISSUES BUT REFUSE TO DO ANYTHING OTHER THEN DOCUMENT THEM AND SAY HAVE A NICE DAY! *JS

THE CAR WAS IDLING ROUGH AND THE "SERVICE ENGINE" LIGHT KEPT COMING ON, EVEN AFTER I HAD THE AUTO REPAIR SHOP (PEP BOYS) CHECK AND FIX THINGS. THEY ADVISED ME TO GO TO THE FORD DEALER, AND SAID IT MAY BE THE TIMING CHAIN. FUTURE FORD RAN DIAGNOSTIC, SAID IT MAY BE TIMING CHAIN BUT HAVE TO OPEN ENGINE TO VERIFY. ESTIMATE FOR REPAIRS $1500 TO OPEN ENGINE AND $2500 TO FIX). DID NOT HAVE WORK DONE YET. THE ENGINE HAS A LOUD RATTLING SOUND THAT STARTED SUDDENLY AND HAS GOTTEN WORSE, AND INCREASES UPON ACCELERATION. THERE IS AN OILY SMELL. AT STOP LIGHT WHEN IDLING, THE IDLE IS SLOW AND A LOUD KNOCKING SOUND - IDLE SOUNDS LIKE CAR IS ABOUT TO SHUT OFF. THE NORMAL IDLE SOUND FOR THE CAR IS SMOOTH AND LIKE A SOFT HUM. CALLED FORD TO SEE IF THERE IS A RECALL FOR THIS PROBLEM, AS THERE ARE MANY COMPLAINTS SIMILAR TO MINE THAT ARE LISTED ON THE FORD WEBSITE ABOUT SEVERAL YEARS OF THE FORD EXPLORER. MILEAGE NOW IS 150,000 MILES. FORD SAID THERE IS NO RECALL, BUT KEEP RECEIPTS FOR WORK DONE IN CASE OF ONE IN THE FUTURE.

I WAS DRIVING ON A CURVE AND THE ENGINE SHUT OFF , I WAS ABLE TO STOP ,AND TURN THE CAR ON AGAIN, THAT WAS THE THIRD TIME THAT HAPPENED , THE OTHER TWO TIMES THE CAR WAS AT LOW SPEED , AROUND 30 MPH . *TR

DRIVING HOME FROM VACATION WITHOUT PROBLEMS, O/D OFF LIGHT STARTED FLASHING, TRIED TO TURN IT BACK ON BUT WOULDN'T DO ANYTHING. STOPPED, TURN KEY OFF, STARTED NO LIGHT. AFTER ABOUT 150 MILES AFTER STOPPING ON TRAFFIC LIGHT O/D OFF LIGHT STARTED FLASHING AGAIN. 10 MILES LATER ENGINE SERVICE LIGHT CAME ON AND STAYED ON . *TR

THE TRANSMISSION LIGHT, 4'4 AND THE OD LIGHT CAME ON. IT DOES SHIFT GEAR FROM 1 TO 2 UNTIL 3000 RPM. *TR

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 70 MPH, THE VEHICLE SUDDENLY DECELERATED DOWN TO APPROXIMATELY 45 MPH AND THE OVER DRIVE WARNING SENSOR LIGHT ILLUMINATED. ALSO, THE CONTACT INDICATED THAT DURING THE INCIDENT THE VEHICLE FAILED TO SHIFT INTO GEAR. THE FAILURE RECURRED ON MULTIPLE OCCASIONS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 156,000.

WHEN CLOSING THE GLASS TAILGATE THE RIGHT HINGE THAT ATTACHES THE GLASS TO THE TAILGATE BROKE CAUSING THE GLASS TO DETACH FROM THE CAR AND FALL HITTING ME IN THE LEFT ARM UPDATED 09/16/14*LJ UPDATED 3/18/2015 *JS

TRANSMISSION OD LIGHT FLASHING, SLAMMING INTO GEAR WHILE SHIFTING. WE HAD THE PAN DROPPED AND FOUND PIECES OF THE GEARS INSIDE... NEED A TOTAL REBUILD OR NEW TRANSMISSION. AFTER READING ALL OF THE PROBLEMS WITH THIS YEAR AND MODEL I BELIEVE FORD NEEDS TO MAKE SOME KIND OF RECALL.... *JS

2 COMPLAINTS - BACK REAR HATCH PANEL UNDER REAR WINDOW HAS MULTIPLE CRACKS LIVE IN AUGUSTA GA AND VISIT FLORIDA AND THIS SEEMS TO BE A COMMON PROBLEM EVERY MAKE BODY LIKE MINE HAVE THIS CRACK AND SOME PANEL HAS EVEN FALLEN OFF. THIS HAS TO BE A MANUFACTURING PROBLEM FOR THIS LARGE AMOUNT OF SUV'S TO HAVE THE SAME PROBLEM SEE MORE WITH PROBLEMS THAN WITHOUT. ALSO RECENTLY HAD PROBLEMS WITH WINDOW INTERMITTENTLY NOT GOING DOWN AND BACK UP AFTER ICE STORM IN AUGUSTA THIS YEAR ALL FOUR WINDOWS STOPPED GOING UP AND DOWN. THIS ALSO SEEMS TO BE A COMMON PROBLEM WITH THIS MODEL AND BODY STYLE OF FORD EXPLORERS. OWNED A 1993 FORD EXPLORER EDDIE BAUER HAD APPROX. 300,000 MILES ON IT BEFORE I GOT RID OF IT AND THE MOST HAPPENED TO THIS CAR WAS THE TRANSMISSION AND REAR BRAKE LEAK WHICH WAS THE MOST EXPENSIVE PROBLEM I HAD. WISH I STILL HAD THE 1993 EXPLORER BECAUSE MY 2003 MAKES ME HESITANT ABOUT PURCHASING ANOTHER FORD EXPLORER NO MATTER HOW MUCH I LIKE THEM THIS ONE WILL MAKE TURN TO ANOTHER MAKE OF CAR. ONCE A LOYAL FORD OWNER NOT SO SURE NOW. YOU WOULD THINK THAT FORD WILL BE AS LOYAL TO US AS WE ARE OF THEM, IT IS THE LITTLE THINGS THAT MAKE YOU FRUSTRATED AND NOT WANTING TO PURCHASE ANOTHER. IF YOU CAN'T DEPEND ON THE SMALLER THINGS HOW CAN WE DEPEND ON THEM WITH THE LARGER THINGS. ONCE A LOYAL FORD OWNER. *JS