2019 FORD EXPLORER Complaints

EXTERIOR A-PILLAR TRIM PART DETACHED, NOW CAUSED CRACKED WINDSHIELD WHERE TRIM WOULD HAVE BEEN. THE PART HAS BEEN DETACHED FOR MONTHS AND MY LOCAL FORD DEALERSHIP HAS NO TEMPORARY OR PERMANENT SOLUTION. MY WINDSHIELD NOW HAS A SPIDERING CRACK WHERE IT WOULD HAVE BEEN PROTECTED .

The vehicle vibrates excessively when shifting into Drive or Reverse (rough idle). Additionally, the vehicle lacks acceleration/power when driving in slightly uphill roads, creating a hazard for nearby drivers. There were no check engine lights and the issue first appeared at approx. 84,000 miles. The vehicle was diagnosed at a Ford dealership and the issue was determined to be the torque converter. The Ford Service Dept cited TSB 22-2287 and recommended replacing the full transmission to fix the issue.

I was putting my car in reverse and all of a sudden, it shifts really hard and makes this loud noise. I thought it was very strange, and put it in drive and went not even 2 minutes and my car had no power. I was pressing the gas pedals but it didn't want to go. I stopped it and called a Tow truck to come get my car and take it to the nearest Ford dealer. They called me in a few days advising that the transmission was gone. After researching online, I noticed a lot of Ford Explorers being recalled for this exact issue, including My sisters Ford Explorer. Hers was under the recall, and Ford paid for hers. Ironic, the same thing happened to mine and mine has no recall. My car had been running fine, up until this day. I have maintained this car and no warning lights ever came on, until I put it in drive and the Orange Wrench cam e on. I knew something was wrong then. I am a single mother of a [XXX] and this could have put us in alot of danger INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2019 Ford Explorer. The contact stated that there was an orange wrench warning light was illuminated when the vehicle was shifted into reverse. The vehicle was towed to the dealer where it was diagnosed, and it was determined that the failure was with the torque converter. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The vehicle was towed to an independent mechanic where the same information was provided. The vehicle was not yet repaired. The manufacturer was notified of the failure and advised to contact NHSTA Hotline for assistance. The approximate failure mileage was 65,000.

The contact owns a 2019 Ford Explorer. The contact stated while driving 65 MPH, the A-pillar trim on the passenger’s side windshield started to detach. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The local dealer was contacted, and the dealer stated that parts were not yet available. The contact was charged for the vehicle to be diagnosed. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and referred the contact to the NHSTA Hotline for assistance. The approximate failure mileage was 56,000. VIN tool confirms parts not available.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving approximately 62 MPH, the front driver’s side door keypad detached and caused a short circuit in the battery causing the battery to fail. The battery was replaced, and the keypad was repaired but shortly afterward the keypad detached and flew off the vehicle on the highway and the battery failed again. The contact referenced the failure to TSB: 19-2150 (Factory Keyless Entry Keypad). The dealer was made aware of the failure. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 19,000. VIN tool confirms parts not available.

I took my vehicle last year to the dealership to report the safety concern I had with a loose piece under my hood causing a flapping sound while driving. They determined the exterior a pillar was warped, loose and missing pieces. I received the recall in the mail a few weeks later, although they will not set up an appointment for me to resolve this issue. Not only does it state this is a potential safety concern, it has already been established this piece is defective on my vehicle. I also drive fellow associates around to meetings in my vehicle and it is putting them in danger along with myself and is bringing concerns it has not yet been addressed. The recall was sent to me a few weeks later on 01/26/2024.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was not made aware of the issue. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2019 Ford Explorer. The contact stated that the roof rail had detached. The local dealer where the vehicle was diagnosed determined that the roof rail needed to be replaced. The contact stated that the roof rail was temporarily fixed with tape. The vehicle was not repaired. The contact was made aware NHTSA Campaign Number: 21V316000 (Structure). The manufacturer was made aware of the failure. The failure mileage was approximately 21,000.

Airbag light has come on, states second row passanger side airbag inflatable circuit (inflatable seatbelt). Just purchased vehicle two days ago.