2019 FORD EXPLORER Complaints

Airbag light has come on, states second row passanger side airbag inflatable circuit (inflatable seatbelt). Just purchased vehicle two days ago.

The contact owns a 2019 Ford Explorer. The contact stated while driving approximately 65 MPH, the passenger's side A-pillar trim detached and made a loud popping sound. The contact stated that the driver's side A-pillar trim was extremely loose. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The vehicle was taken to the dealer. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made of the failure. The failure mileage was approximately 63,250. VIN tool confirms parts not available.

The contact owns a 2019 Ford Explorer. The contact stated that the exterior pillars on both sides of the window had detached. Additionally, the contact stated that while driving on several occasions over 30 MPH, she observed a loud buzzing noise and wind coming through the sides of the windshield. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 76,000.

The windshield cawl ( bottom piece that goes across windshield) has deteriorated. Making a whistling sound going down the road. I have already in December 2023 had to replace the A pillar trim and clips on driver side. Have talked to other explorer owners having the same issue. Thank you for your time

The contact owns a 2019 Ford Explorer. The contact stated while driving approximately 60 MPH, the vehicle began making abnormal noises from under the floorboards. The contact stated that the vehicle was losing forward momentum. The contact depressed the accelerator pedal and the vehicle only revved and was not gaining forward momentum. The contact stated numerous warning lights were illuminated. The contact stated that he was able to reach his destination, but was not able to exceed 30 MPH. The contact was able to drive the vehicle to a dealer; however, the vehicle was not diagnosed or repaired. The contact stated that the transmission had been replaced a year prior and felt that the failure was related to the transmission. The manufacturer was not informed of the failure. The failure mileage was approximately 52,000.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

I was traveling on the interstate (~75 mph) when the rear of my vehicle suddenly jerked to one side with enough force to cause a loss of control. There were no lights or warning sounds to indicate that there was anything wrong with the vehicle in that moment or leading up to it. I was fortunate enough that no contact was made with any other vehicles as my car crossed all three lanes; from the center lane to the far right and then back across all three lanes to the far left. The car skidded off the highway and slid onto a sloped embankment before it stopped. Obviously, I or someone else could have been seriously injured or even killed. I was able to drive the car back up on the shoulder of the highway. Everything was functioning properly EXCEPT the steering. I was able to drive at ~15 mph to the nearest exit. I was then towed to my mechanic's shop. The tow truck driver said it looked like my right rear tire was about to "fall off" and that I was very lucky. My mechanic took pictures of the damaged part (Right Rear Toe Arm) both on the vehicle and again once removed. He checked with Ford for a recall and found out that this part had been part of a recall on Explorers from 2012-2017, but not on the 2019. Assuming the part had been redesigned after 2017, he ordered a replacement for the right. (The Left Toe Arm was not damaged.) However, once the replacement part arrived, it was a completely new design from the 2019 Toe Arm. He recommended I replace the Left Toe Arm as well since the parts were so different. My right shock absorber was also damaged in the accident and had to be replaced.

The B-pillar trim piece has become detached from the vehicle due to broken clips and when driving it appears as if it will fall off. Ford will not address the issue, other then using two sided adhesive tape which needs to be replaced continuously. The clips that hold the trim in place are broken and this is common on many explorers. There are other body trim pieces which have been recalled for and this needs to be added as well. The A-pillar trim was recently a recall item and this is just as much a hazard.

The contact owns a 2019 Ford Explorer. The contact stated that there was rust on the aluminum hood, which had bubbles and rust. The vehicle was taken to the local dealer, who stated that the hood needed to be replaced. The vehicle was not repaired. The manufacturer was contacted, but no additional assistance was provided. The failure mileage was approximately 18,600.

The contact owns a 2019 Ford Explorer. The contact stated that there was an abnormal sound coming from the vehicle. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The approximate failure mileage was 38,000. VIN tool confirms parts not available.