2019 FORD EXPLORER Complaints

Fuel pump and module failure. Driving on the highway at 70 miles an hour and the fuel pump failed. Causing me to have zero acceleration. Thus losing speed rapidly in the center lane. No warning lights were present before or after. One previous symptom of a crank no start. Dealership was able to replicate the crank no start situation. Resulting in the problem being a fuel pump failure and module needing replaced, at 83,000 miles on the vehicle. Though I know normal wear and tear can and does happen, there was no warning. And losing engine power at high speeds on a highway is unsafe.

This recall has been unresolved for approximately two years. Recently, while traveling at highway speeds, the A-pillar trim detached from my vehicle and flew off, striking a vehicle behind me. Fortunately, no accident occurred, but the situation was extremely dangerous and could have resulted in serious injuries or property damage. This is precisely the type of incident the recall was intended to prevent. I have reached out to my local dealership numerous times and am told that Ford has no parts available. This is not acceptable and Ford is not handling this recall in a timely fashion.

The contact owns a 2019 Ford Explorer. The contact stated that while driving, Panel on the driver side door, keyless pad became completely detached. The vehicle was taken to a dealer where it was diagnosed as not being fully secured and was replaced. The panel blew the fuses and affected the liftgate on the vehicle and additional repairs, latch replacement on the liftgate had to be completed. The manufacturer was notified of the issue. The approximate failure mileage 47,000.

While my granddaughter was driving our 2019 Ford Explorer, the steering effort suddenly increased without warning, as if the electric power steering assist stopped functioning. She was traveling at approximately 45 mph on a public road and was unable to steer normally. The sudden loss of assist caused her to nearly leave her lane and almost resulted in a collision. This vehicle uses an electric-assist rack-and-pinion steering system. There were no warning lights or messages before or during the event. Road conditions were dry. After the incident, steering remained abnormally heavy/intermittent. It isn't as though it mimics an old school vehicle without power steering, where it simply requires a good deal of strength. With this situation, if you work hard to make a correction, the car suddenly pulls further quickly in that direction, or in the opposite direction in a very jerky manner. The failure occurred without any prior symptoms and created an immediate loss-of-control hazard, especially for younger or smaller drivers who cannot overcome the sudden increase in steering force. It basically feels like it is locked up. I am reporting this because the failure was sudden, unannounced, and nearly caused an accident. This appears to be a malfunction of the electric power steering assist system, and it presents an unreasonable safety risk. On a related note, I am the Director of Quality for a manufacturing facility and have conducted hundreds of formal risk assessments during product design. A sudden, unannounced loss of steering assist represents a high-severity, low-tolerance safety hazard. In my professional opinion, this failure mode warrants an accelerated investigation.

I had my transmission replaced in California on Feb 2025. Had failure issues and took it to ford, they found an issue with the torque converter and replaced 7 months after the new transmission, it was cleaned out for debris and contamination. Early this May took it in again for the vehicle violently shaking, the ford Mechanic before inspecting immediately knew what transmission I had and knew what issue was, said all the 6F35 transmissions are failing. Took it to my local ford dealership who confirmed that the whole transmissions needs to be replaced again. Less than 20k miles on it. Of course this transmission had a law suit filed which was dismissed. Frustrating because it is clearly a known issue. I am currently #10 on the national waitlist for a new transmission. I am expected to be without a vehicle for months.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the windshield exterior A-pillar trims had become loose. The local dealer was contacted. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 75,000.

While driving at highway speeds on the interstate, the B-pillar exterior trim suddenly detached from the vehicle. The trim remained tethered only by the keypad wiring, causing it to flail in the wind and create an immediate road hazard. Simultaneously, the vehicle’s instrument cluster triggered a "Liftgate Open" warning, despite the liftgate being secure. I was forced to make an emergency pull-over onto the shoulder of the interstate—a dangerous situation—to prevent the trim from completely detaching and striking other vehicles. Upon reaching my destination, the vehicle suffered a significant electrical short. The interior lights remained on indefinitely due to the false "liftgate open" sensor reading, and the door keypad became completely inoperable. To prevent a total battery drain and potential fire risk from the short, I had to manually disconnect the battery. The dealership confirmed the failure but stated that current B-pillar recalls (such as Recall 25S53) currently only apply to 2016–2017 models, despite my 2019 model using the same defective clips and adhesive. This failure is identical in nature to Recall 24S02 (A-pillar detachment). The detachment of this trim is a documented projectile hazard. Furthermore, the resulting electrical short in the door harness has compromised the integrity of the vehicle’s sensor system. I am requesting that NHTSA investigate the expansion of the B-pillar recall to include the 2019 model year to prevent further highway incidents.

Brakes, rotors, tires and now steering column and starting gear is needing replaced after recall of rear toe link in 2019 ford explorer

The massage seat on the driver and passenger front seats malfunctioned. The drivers seat massage pillows stayed inflated on the seat and backrest. Driving to work this morning the massage pillow on the drivers seat popped. This was a very loud almost gunshot type of sound which caused me to swerve my vehicle and almost create an accident. This is due to the massage seat malfunctioning. Ford Motor corp is aware of the issue with the seats and have issued a Technical Service Bulletin but no recall. This is a serious safety issue as this could have caused a major accident while operating the vehicle. Ford Motor Corp refuses to fix the issue with my vehicle as it is no longer covered by my warranty.

I brought my vehicle to Ford Motor Place in Webster Massachusetts to do two recalls, my car was driving normally before the recall service. Immediately after recall work, it does not run properly. The dealer claims transmission failure without prior symptoms. The vehicle only has 70,000 miles.