1996 FORD EXPLORER Complaints

DRIVERS SEAT BELT OVER THE COURSE OF 3 WEEKS, GRADUALLY WENT FROM POPPING OUT IN TO NOT WORKING AT ALL. WENT BACK TO FORD, OVER $200.00 TO REPAIR IT.*AK

THE DRIVER'S SEAT BELT DID NOT LATCH PROPERLY. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED THE BUCKLE NEEDED TO BE REPLACED. *JB *SCC *JB

SEAT BELT FAILURE. THE DRIVERS SEATBELT FAILS TO HOLD/LATCH. SEATBELT IS COMPLETELY UNUSEABLE.

REPAIR SHOP STATED THAT THE EXPLORER BY FORD HAS A WEAK SPOT THAT HE HAS HAD TO REPAIR ON NUMEROUS OCCASIONS. IT IS THE L CYLINDER #4 THAT CRACKED.

DEFECT WITH FAULTY INTERIOR DOOR LATCH/RELEASE MECHANISM PREVENTS DOORS FROM BEING OPENED BY PASSENGERS.*MR *CB

SEAT BELT BUCKLE FAILURE, DRIVER'S SIDE, 1996 FORD EXPLORER XLT, @72000 MILES. CAR IS IN GOOD CONDITION OTHERWISE, NEVER WRECKED. OVER THE COURSE OF TWO WEEKS, THE BUCKLE WENT FROM TO "POPPING-OUT THE LATCH" OCCASIONALLY TO BEING NEAR IMPOSSIBLE TO SECURE THE LATCH IN TO THE BUCKLE AND RANDOM "POP-OUTS".THE BUCKLE WAS REPLACED AND I KEPT THE OLD BUCKLE.*AK

WHILE DRIVING VEHICLE SUDDENLY HESITATED TO ACCELERATE, TRANSMISSION HAD GONE BAD, PER DEALERSHIP.*AK

SEATBACK IN MY 1996 FORD EXPLORER ([XXX]) BROKE WITHOUT WARNING WHILE DRIVING ON THE INTERSTATE. CAUSE IS A FRACTURED BOLT IN THE RECLINING SEATBACK LATCH.*AK INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

WE PURCHASED OUR VEHICLE USED IN 1999 WITH 33000 MILES. 6 MONTHS AFTER THE PURCHASE WE NEEDED A NEW TRANSMISSION, ANOTHER NEW TRANSMISSION LAST YEAR (2002), NEW BALL JOINTS, AND NOW WE ARE BEING TOLD THE RACK AND PINION NEEDS TO BE REPLACED. FORD HAS NOT OFFERED ANY RECALLS ON THIS PART BUT I HAVE SEEN OTHER COMPLAINTS REGARDING THIS. MY VEHICLE IS CONSTANTLY SHAKING (FEELS LIKE I AM GOING OVER RUMBLE STRIPS) WHEN I AM OVER 30-40 MPH. WE ALSO JUST HAD OUR VEHICLE ALIGNED AND IT IS OUT OF ALIGNMENT AGAIN BECAUSE OF THIS PROBLEM. *JB

96 FORD EXPLORER: CHECK ENGINE LIGHT CAME ON TWO WEEKS AGO, ONE WEEK LATER, BATTERY STALLED AND REQUIRED A JUMP, THE POWER LEVELS READ NORMAL. I CHECKED THE POWER DISTRIBUTION BOX AND THE FUSES DID NOT MATCH OWNER'S MANUAL. TWO PARTS SHOPS ADVISED THIS COULD TRIGGER FIRE, OR A DEVICE TO MALFUNCTION. PER FORD OWNER'S MANUAL, AIRBAG & ATBS IMPACTED. I REPLACED THE FUSES TO MATCH THE OWNER'S MANUAL. TODAY, I TOOK THE CAR TO A PRIVATE SHOP, THAT WORKED ON THE ELECTRICAL SYSTEM EARLIER. THE OWNER PULLED AN ALL DATA SCHEMA, WHICH IS QUITE DIFFERENT. HOW DO I KNOW WHICH ELECTRICAL SCHEMA IS CORRECT - THE OWNER'S MANUAL, THE OTHER SHOPS REFERRED TO, OR ALL DATA? IT MAKES A DIFFERENCE, 60A VS 30A FUSES, DIFFERENT BLANK RELAYS, ETC. IF THE FORD MANUAL IS CORRECT, AND I FOLLOW THE ALL DATA SCHEMA, IT COULD TRIGGER FIRE OR MALFUNCTION. VICE VERSA, WOULD BE BAD ALSO. EITHER WAY, CONSUMERS SHOULD BE ALERTED? EITHER TO INCORRECT ELECTRICS IN THE FORD MANUAL, OR TO AN INCORRECT ALL DATA SCHEMA USED BY MECHANICS? (I HAVE ASKED FORD, ALSO, FOR A REPLY.) ALSO - THIS IS THE SECOND TIME IN 6 MONTHS I HAVE HAD ISSUES WITH THE CHECK ENGINE LIGHT, BUT NO OTHER SYMPTOMS. THE FIRST TIME, THE MECHANIC REPLACED THE CAM SENSOR, AND IT EVENTUALLY WENT OFF. HE STATED THIS WARNING LIGHT WAS INSIGNIFICANT, AND REFERRED ONLY TO EMISSIONS STANDARDS. (NO VISIBLE EMISSIONS). I NOTE THAT - PER THE OWNERS MANUAL AGAIN - THIS WARNING LIGHT CAN ALSO BE TRIGGERED BY A MONITORING, GPS, OR ALARM DEVICE BEING INSTALLED IN THE VEHICLE. IF I CAN FIND NO OTHER CAUSE, HOW WOULD I CHECK FOR THIS, AND DO YOU HAVE OTHER RECORDS OF THIS BEING THE CAUSE? THE CHECK ENGINE LIGHT WAS ALSO AN ISSUE, LAST SPRING. IN APRIL 02, THE FORD DEALER IN ORLANDO REPLACED THE IDLE AIR CONTROL, AND THE VALVE ASSEMBLY-THRO. CHECK ENGINE LIGHT WAS ALSO AN ISSUE SHORTLY AFTER PURCHASE; DEALER REPLACED SENSOR ASSEMBLY-EGR, THERMOSTAT ASSEMBLY. IS THERE AN ASSOCIATED RECALL, OR DOES THIS FIT OTHER PATTERN? THANKS! *JB