2019 FORD EXPLORER Complaints

I purchased a Ford certified 2019 Ford Explorer recently. It is my 20th Ford. I could barely hear the horn and thought there was a problem with one of the horns. I researched it and found that the 2019 model year only came with one horn. The horn is at the front of the hood and when I checked there was a bracket for 2 horns but there was only one. You almost can not hear it when inside of the car and it makes me think that others may not hear it if there is an emergency. I have owned close to 70 cars and I have never had a car with one horn. A moped has a louder horn. In my opinion Ford should not have tried to save $5 that could cause an accident. I had to order Ford part number GB5Z-13832-A which are the dual horns found on the other model years. My safety and the safety of other 2019 Ford Explorer owners is at risk because of this.

Dec 2022- Windshield trim on passenger side ripped off while driving on the interstate. Sept 2023- noticed noise while driving. Checked driver side trim and noticed seal was gone. Trim was cracked along its entirety. Replaced before it also flew off

OEM Ford Gen 4 SYNC 3 Nav APIM suddenly started sporadically functioning. Contacted Ford after viewing multiple recalls from previous years Ford vehicles with exact issue. After being told there was no recall on my 2019 Explorer, was given a quote of $170.00 to diagnose issue, $900 + for APIM module, plus installation and programming. We purchased a re-programmed APIM module and installed. Problem is now corrected. Recall needs entered on this unit. Attaching photos of front & back of bad unit: WY1W748K GR26A KB5T-14G370-DCA SERIAL NO. 205831 MFG - JANUARY 2019 ASSY NO. MAJ0673GX PANASONIC AUTOMOTIVE SYSTEMS MODEL FA-170-BCAR-HS IFT# RCPPAFA16-2032 FCC ID: ACJ-FA-170-BCARHS IC ID: 216B-FA170BCARHS ANATEL ID: 05008-16-09014 CMIIT ID: 2016AJ4795

The driver's side exterior windshield moulding detached from the vehicle traveling at interstate speed (75 mph) and struck the driver's door above the window. The apparent cause of detachment was failure of the retaining clips and adhesive that holds the external piece to the internal rubber moulding.

Driver side pillar molding next to the windshield flew off unexpectedly while driving on the highway.

The contact owns a 2019 Ford Explorer. The contact stated while driving at an undisclosed speed, the vehicle shuddered while shifting gears. The vehicle was taken to the dealer, who informed the contact that the power transfer unit (PTU) needed to be replaced. The vehicle was repaired. The contact related the failure to the Customer Satisfaction Program: 20B27. The manufacturer was not made aware of the failure. The failure mileage was approximately 90,000.

Rear toe link and bushing issues. I have the same car as my sister. She has a 2016 with the same rear toe link as my 2019 and her car is covered under the recall and mine isn't.

Windshield trim falling off and deteriorating - windshield rattling - took to dealer to replace windshield trim - paid 642.00 to replace deteriorated trim - want a recall on this as it is very dangerous/ I also want reimbursement of 642.00 for repair

When the vehicle is in outside in the direct sunlight, the extreme heat causes the fuel pump driver module to fail. When this module fails, it cause the vehicles fuel pump to stop sending fuel to the motor which causes the vehicle to turn off or run extremely rough, while driving and or stationary. The moduel has been replaced by world ford Pensacola once, and twice by an ASE Certified Master Mechanic, on 3 separate occasions.

The rear camera failed and it was discovered a corroded connector and cable. This is causing rear camera to fail. Ford helped with the repair cost however, the entire cable was replaced. Waited 5 months. This is a common problem and FORD should cover the refund and recall. The cameras are on a recall but not the cables that are causing the camera to fail. The repair costs like $2000. Ford did help. This is a manufacturer defect and the problem is common. Please see pictures and the video link. https://youtu.be/ewz_OeFO_6M