2019 FORD EXPLORER Complaints

Roof rack rails coming off car. Recall number 21S22. I took my 2019 Ford explorer to the local Ford dealer on 03/25/2022 and roof rails were repaired. Roof rails coming off again. I called Ford motor company again (CS-40164791). A lady named Fallon told me there is nothing Ford Motor Company can do. All recall attempts have been made. Roof rails did not look like this when car was new, plus the roof rails looked like new when local Ford dealer made first recall repair. Now coming off again. Roof rails may not have been repaired correctly or to recall recommendation. I have checked many Ford Explorer’s, in parking lot, between 2016 and 2019 none have roof rails sticking up 3/4 of an inch in rear of car like mine.

I have had the key pad replaced 2 times because it melts at top. It has melted again Should it be recalled

2nd row seat belt malfunctioned during when rear ended recently. Seat belt came unlatched on my niece throwing her towards the front passenger seat. Car has been totaled. Injury was to driver.

The torque converter on my 2019 Explorer is messing up. Causing a stutter while driving and an extremely rough idle when trying to stop at a stop light/sign. This stutter happens intermittently and unexpectedly weather driving at a high rate of speed or low. A light never came on and no codes were able to be read. The last day I was able to dive my car the idle suddenly dropped so low mid driving. Thankfully I was going at a low rate of speed and able to get my vehicle off the road. I took my vehicle back to the Ford dealership and asked that they re-evaluate as the problem had gotten worse. That’s when I was informed my torque converter had malfunctioned. Not only did the dealership provide me with that information, but they also informed me that this is a known issue and has affected so many Explorers in this way, Ford had issued multiple TSBs to their service departments notifying them of this issue. I have attached screenshots of TSB 20-2271 and 22-2287, showing Ford is aware of these issues being reported on the 2016-2019 model Explorers. In my research, I’ve also found that the NHTSA has had a previous case, 17S16, showing Fords directive to replace faulty Torque Converters back in June of 2018. It is clear that Ford has not taken this issue seriously and continues to produce and sell vehicles with this bad part. This stutter and sudden decrease in idle could cause a wreck. Thankfully it did not with me, but it is an ongoing issue that could in the future. Ford has acknowledged there’s a problem but has not yet issued a recall on this part, for my VIN or cars like mine. I urge the NHTSA to investigate and encourage Ford to make this right and improve the quality of the torque converters they’re producing and selling to consumers.

When I took a left hand turn coming from a stop-sign the control arm on my front right passenger side busted. I did not hit anything or cause the damange instead this was in part of failure of the product. I was traveling approximately 3 mph on a flat surface with no traffic exiting an industrial park. Because the control arm broke, it caused significant other damage to my vehicle due to the inability to steer my vehicle and the wheel to no longer be controlled by the steering wheel. There were no warning signs and nothing to signal to me that my car was in fact having issues. If I would have been traveling on the hwy during this incident chances are I would have been severally hurt or even killed. I had just dropped off my husband and child at an event where we were traveling on a hwy. Luckily I was traveling at a slow speed during this incident and nobody was injured. The vehicle has been inspected and based on the significant damage (fender, door, mechanical) there has been nothing but challenges getting the issues fixed. My car is still covered under warranty because it's new however between my car insurance and the warranty nobody wants to help cover the cost of the damage that was cause at no fault of my own. Finally, this is a known issue with Ford vehicles. Research shows many, many other complaints just like mine where faulty control arms are breaking at no fault of the driver. As a matter of fact, 3 days ago there was the same incident at a round-about where another Ford Explorer was sitting in the middle with it's control arm broken. Same issue, same scenario.

Transmission torque converter and transmission clutches malfunctioning. Yes it's available for inspection if needed. Safety is an issue because car shudders when driving. Yes, problem has been observed by a dealer. And has been inspected with an estimated cost of $5,100+ No warning lights come on to know to assess the issue.

The front pillar columns on either side of the windshield have flown off while driving on the interstate. This is a ongoing Ford issue that should be fixed and is so dangerous could crack someone’s windshield

The contact owns a 2019 Ford Explorer. The contact stated there was a loud rattle coming from the rear passenger side wheel of the vehicle. The noise progressed when on rough roads. The contact inspected the rear passenger side toe link which seemed as though it was loose and malfunctioning. The contact did not take the vehicle to the dealer. The vehicle had not been diagnosed or repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 46,172

2019 Ford Explorer shutdown at full speed on Florida Turnpike for the second time within 30 days. The first time it was thought that the battery was at end of life. A new battery was installed and thought to be fine however, later the vehicle was unable to start after highway use, requiring waiting to restart. Engine cranks but will not start. Vehicle started then shut down at full highway speed on the Florida Turnpike on July 5th. Car was in unsafe location on highway edge as no other area was reachable. Car cranked but would not start. Turnpike Road Ranger responded, I called for tow and Uber, car eventually started and I drove it to Lorenzo Ford of Homestead FL. Ford has no TSBs on this subject however the internet has multiple videos showing Ford customer’s experiencing the same issue of no start or shutdowns. Please review for similar complaints. I have a very nice unreliable and unsafe car at this point.

At 53,000 miles I was driving down the highway and my vehicle sputtered and died leaving me stranded on the side of the road. The vehicle would not start. I took the vehicle to a local repair shop and had to replace the Fuel Pump for the vehicle. That was very low mileage to have an issue with a major part like a fuel pump.