2003 FORD EXPLORER Complaints

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT WHILE TRAVELING 5 MPH, THE SIDE CURTAIN AIR BAGS DEPLOYED INADVERTENTLY. THE VEHICLE WAS TAKEN TO THE DEALER HOWEVER, THE DEALER WAS UNABLE TO DETERMINE WHAT CAUSED THE AIR BAG DEPLOYMENT. THE MANUFACTURER STATED WOULD PROVIDE NO ASSISTANCE. THE FAILURE AND CURRENT MILEAGE WAS 125,000. *TR

WITHOUT ANY PRIOR INDICATION OF AN ISSUE, THE OVERDRIVE LIGHT STARTED FLASHING. AFTER STOPPING AT THE NEXT TRAFFIC LIGHT, IT APPEARED THE TRANSMISSION WAS HAVING A PROBLEM GETTING INTO 2ND GEAR. NEEDLESS TO SAY, THE TRANNY PROBLEM CONTINUED AND NOW NEEDS TO BE REPLACED. THIS ISSUE SEEMS BE CONSISTENT WITH THAT OF MANY, MANY EARLY 2000S EXPLORER OWNERS. I FEEL AN INVESTIGATION INTO THIS ISSUE IS WARRANTED. *TR

REAR LIFT GATE PANEL CRACKED WHILE VEHICLE WAS PARKED. CONCERNS WITH UNSTABLE REAR GLASS, ABILITY OF HATCH TO REMAIN CLOSED AND OPERATION OF REAR WIPER. GLASS INSTABILITY A CONCERN WHILE DRIVING AND WHEN USING LIFTGATE. PRIOR INJURIES HAVE BEEN REPORTED. *TR

OK WE WERE DRIVING PULLED OUT AND IT DID NOT SHIFT TO SECOND GEAR AND CARS WERE COMING UP AND HONKING HORN IT TAKES CAR A LONG TIME TO SWITCH TO 2ND GEAR AT LIGHT AND THIS IS VERY DANGEROUS CAN GET HIT. THE O/D LIGHT FLASHES CAUSING SERVICE ENGINE LIGHT TO COME ON. TRANSMISSION WAS SERVICED AND I WAS TOLD IT WAS A FORD ISSUE WITH THESE TRANSMISSION FORD WAS NOT SUCCESSFUL AT HELPING THEIR NEEDS TO BE A RECALL ON THESE TRANSMISSION THEY ARE VERY DANGEROUS AND THE CUSTOMER IS CONSTANTLY PAYING THE PRICE ON THESE VEHICLES. *TR

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT NOTICED A LARGE FRACTURE UNDER THE REAR LIFTGATE GLASS NEAR THE MANUFACTURING EMBLEM. THE FRACTURE WAS APPROXIMATELY SIX INCHES LONG. THE VEHICLE WAS NOT INSPECTED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 83,000.

CHECK TRANSMISSION INDICATOR ON IN INFORMATION CENTER AND OVERDRIVE LIGHT ON. GRINDING NOISE FROM UNDER VEHICLE. *TR

I WAS DRIVING DOWN TX HWY 190, AND MY O/D LIGHT STARTED FLASHING ON MY 2003 FORD EXPLORER, IT WAS FOUND THAT THE SHIFT SOLENOID PACK WAS GOING OUT, IT WAS AN ELECTRICAL ISSUE WITH THE SOLENOIDS, THE PACK WAS REPLACED AND NOW IT IS DOING IT AGAIN, RAN THE DIAGNOSTICS ON IT AND IT IS THE EXACT SAME PROBLEM, THE SHIFT SOLENOID PACK ELECTRICAL PROBLEM ON A SOLENOID PACK THAT IS BARELY A YEAR OLD AND THE MILEAGE IS NOW AT 201000. *TR

ALTHOUGH THIS DEFECT DID NOT CAUSE AN ACCIDENT OR INJURY, THE POTENTIAL WAS THERE FOR SERIOUS DAMAGE TO THIS OR FOLLOWING VEHICLES. SPECIFICALLY, THE DEFECT WAS THE REAR STRUT/SPRING ASSEMBLIES I.E. BROKEN AND SHIFTED COIL SPRING. AS THIS PART SITS CLOSE TO THE FUEL TANK, THE PIECE OF SPRING THAT BROKE OFF COULD HAVE EASILY PUNCTURED THE FUEL TANK RESULTING IN POSSIBLE FIRE. IT COULD ALSO HAVE WEDGED AGAINST A BRAKE LINE, THUS CAUSING A BRAKE FAILURE AND/OR SUSPENSION FAILURE/MISALIGNMENT CAUSING LOSS OF CONTROL AND AN ACCIDENT. IN ADDITION, IF THE PIECE OF SPRING, WEIGHING ABOUT THREE (3) POUNDS HAD FALLEN OUT, IT COULD HAVE CAUSED SEVERE DAMAGE TO A FOLLOWING VEHICLE OR IT'S OPERATOR HAD IT BOUNCED UP AND PENETRATED A WINDSHIELD. THE REASON FOR THE LAPSE IN TIME IN MY REPORTING THIS CONDITION IS BECAUSE I THOUGHT PERHAPS IT WAS JUST A ONE TIME ISOLATED FAILURE TO MY VEHICLE. HOWEVER, IN TALKING TO OTHER FORD EXPLORER OWNERS, AS WELL AS SEVERAL AUTO REPAIR SHOPS, I HAVE LEARNED THAT THIS HAS BEEN A COMMON FAILURE ON SIMILAR VEHICLES. IF THIS WAS A SIMPLE REPAIR TO A COMPONENT THAT HAD LITTLE OR NO AFFECT ON THE VEHICLES PERFORMANCE OR DID NOT PRESENT A SAFETY CONDITION, I WOULD HAVE PROBABLY JUST WRITTEN IT OFF TO NORMAL MAINTENANCE AND REPAIR. HOWEVER, WITH MY KNOWLEDGE OF AUTOMOBILES, AND A CONDITION THAT COULD POTENTIALLY CAUSE DAMAGE AS WELL AS PERSONAL INJURY, AS WELL AS BEING A QUITE EXPENSIVE REPAIR, I FELT COMPELLED TO REPORT IT TO THE PROPER PEOPLE WHO PERHAPS HAVE A LARGER DATA BASE THAN I DO, AND TAKE ACTION AGAINST FORD MOTOR COMPANY TO MANDATE A RECALL OR REIMBURSEMENT TO THOSE FORD EXPLORER OWNERS WHO HAVE EXPERIENCED THE SAME FAILURE AS I HAVE. *TR

TL* THE CONTACT OWNS A 2003 FORD EXPLORER SPORT. THE CONTACT STATED THAT HE NOTICED THAT THE REAR LIFT GATE HINGES WERE LOOSE AND THE CONTACT WAS CONCERNED THAT THE REAR GLASS WINDOW WOULD FALL FROM THE VEHICLE. THE VEHICLE WAS NOT INSPECTED BY A DEALER OR AN INDEPENDENT MECHANIC. THE MANUFACTURER WAS CONTACTED AND ADVISED HIM THAT THE VEHICLE WAS NOT INCLUDED IN A MANUFACTURER'S RECALL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS UNAVAILABLE. THE CURRENT MILEAGE WAS APPROXIMATELY 153,000. *TR

MY 2003 FORD EXPLORER WHILE GOING DOWN THE ROAD, I STARTED TO NOTICE THAT IT WAS A HARD SHIFT FROM 1ST TO SECOND GEAR, THE RPM WOULD GO TO ALMOST 4000RPM, THEN ALMOST SLAM INTO GEAR. MY O/D LIGHT STARTED FLASHING, AND MY CHECK ENGINE LIGHT CAME ON, WHEN I GOT HOME I RESEARCHED IT ON THE INTERNET AND FOUND THERE ARE NUMEROUS PROBLEMS WITH THE FORD TRANSMISSIONS, AFTER CONTACTING FORD THEY BASICALLY TOLD ME I WAS OUT OF LUCK THEY WOULDN'T HELP,,,, I HAVE BEEN A LOYAL FORD CUSTOMER FOR YEARS AND SO HAS THE REST OF MY FAMILY AND MY BUSINESS USES FORD VEHICLES. SOMEONE NEEDS TO RESEARCH THIS, FORD IS GETTING AWAY WITH A BIG INJUSTICE BY MAKING A SUBSTANDARD TRANSMISSION THAT IS COSTING THEIR CUSTOMS THOUSANDS OF DOLLARS. BUT ALL FORD WILL SAY IS IF THE NHTSA DECIDES TO INVESTIGATE AND SEES ITS A PROBLEM THEN THEY WILL ACT ON IT. *TR