2020 FORD EXPLORER Complaints

What component or system failed or malfunctioned, and is it available for inspection upon request? The transmission failed at approximately 80,000 miles. It requires a complete rebuild/replacement. The failed transmission is available for inspection upon request. It is currently at the transmission shop. How was your safety or the safety of others put at risk? Although the vehicle was technically still drivable, it did not feel safe. The transmission slipped and struggled to shift, and the vehicle felt like it could break down or cause a wreck at any point. The sudden and unpredictable loss of proper control put me and other drivers at risk. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. An independent transmission repair service confirmed the failure and determined that the transmission required a full rebuild/replacement. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? The vehicle has not been inspected by the manufacturer, police, or insurance representatives. It has only been inspected and diagnosed by an independent repair service. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? There were no warning lamps or dashboard messages prior to the failure. The first symptoms were slipping and difficulty shifting gears, which began shortly before I took it to a repair shop.

The head light is intermittent. Sometimes if I drive it works fine, other times the main beam is out and the car displays a notification that says “check owner manual”. It’s not safe if I never know when my head light will work or decide to not work.

While driving, vehicle gave Powertrain malfunction, downhill assist unavailable and Pre-collision warning system unavailable faults. The vehicle then came to a stop and would not move. Turning the ignition off and on allowed the vehicle to be safely parked in a nearby parking lot.

Sunshade - Bought the car 2 years ago. Hit the button to close the sunshade and it stopped closing. Turns out the frame cracked on its own. No accident, no one pushing or pulling on the sunshade, the frame just cracked on its own. This is a 2020 model so I find it very hard to believe it is "wear and tear", this is definitely a defective part or Ford used too cheap of a product on a expensive vehicle. This issue can cause health concerns as my family is being cooked by the sun, not to mention the potential for skin conditions/sunburn that could develop as a result of this.

With regular service and no warning, my transmission has failed at 83k miles. The 10r60 transmission is a known issue for Ford, as they have set out TSB to the dealerships and GM has recalled the same transmission, but Ford has failed to do so. Regardless of the fact that my family, husband, and I have been loyal Ford/Lincoln customers for the last 15 years, they are not willing to do anything to help with this very costly repair.

The contact owns a 2020 Ford Explorer. The contact stated that while attempting to start the vehicle, several unknown warning lights were illuminated. The contact stated that after inspecting the vehicle, the contact became aware that rodents had eaten through the wiring harness. In addition, the contact stated several of the safety features in the vehicle were inoperable. The vehicle was taken to the dealer, where it was confirmed that rodents had eaten through the wiring harness. The contact was informed that the wiring harness needed to be replaced. The vehicle was repaired. The contact stated that it was the second time that the failure had occurred due to the rodents. The manufacturer was not made aware of the failure. The failure mileage was approximately 15,000.

[XXX] . Twice rats have destroyed the electrical wiring under the hood and chasey. While some of these wires do not affect safety, the wires that control and power the crash airbags do. Plus this may create a fire hazard. This also includes hoses. My reach revealed that these components and wire insulation are made from soy-based polyurethane which the rats see as food. This is a safety issue with the air bags and fire hazard. Other affected safety items would include blind spot detection and back up. Also the customer service hotline I was hung up up on twice and could not get through. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

1. What component or system failed or malfunctioned, and is it available for inspection upon request??The issue pertains to a water leak in the rear liftgate area and/or water accumulation in the spare tire area, potentially accompanied by a lack of audio functionality in my 2020 Ford Explore ST as outlined in TSB 24-2044 (NHTSA ID: 102514). The affected component is the rear liftgate structure and associated seals, which allow water ingress, particularly noticeable after car washes or rainfall. The entire sound system to include any collision and impact warnings have failed to chime. 2. ?The water leak in the rear liftgate and spare tire area poses potential safety risks. Accumulated water can damage electrical components, such as wiring or audio systems, which may lead to malfunctions in critical vehicle systems. For example, water ingress could affect rear lighting, sensors, or other electronic modules, potentially compromising visibility or functionality during operation. Additionally, water accumulation may contribute to corrosion or mold growth, posing long-term structural or health risks for occupants. These issues could reduce vehicle reliability and increase the risk of accidents, especially in adverse weather conditions. 3.The issue has been acknowledged by Ford in TSB 24-2044, which provides a service procedure to identify and address the leak path. The Bill Currie Ford dealership in Tampa, FL has inspected my vehicle on several occasions, recently July 15, 2025 and confirmed water leakage in the rear liftgate area consistent with TSB 24-2044.The dealer will not repair unless I pay over $2200 for the repair, which I refuse for a manufacture defect. 4. To date, the vehicle has not been inspected by the police or insurance representatives, but the issue align with the TSB report. 5. Water observed in the spare tire & tailgate area every time since purchase. A loss of audio back in July 2023 and numerous occasions since complete failure as of January 3 2024

The contact owns a 2020 Ford Explorer. The contact stated that while attempting to open the passenger’s side door, her son and husband’s hands were sliced and injured by the door. Neither the dealer nor an independent mechanic was contacted. The vehicle was not diagnosed by a dealer or independent mechanic. The vehicle was not repaired. The manufacturer was notified of the failure but offered no assistance. The contact was referred by the manufacturer to the NHTSA Hotline to report the failure. The approximate failure mileage was 53,000.

Interior driver door handle - coating is metal, it partially peeled off. Several times it has cut my finger when I open the door (paper type cut). Due to fast paced life, I forget to open door is a way to avoid the metal flake and tend to always cut my finger which is scary if I touched it when vehicle was in motion, there is a quick second of shock/pain from cut. Ford has this common problem as we had the window openers replaced when it was warrantied, same issue. I think it's a safety issue and should be replaced by Ford. They want to charge me over $300 for the repair, I'm not going to give them the satisfaction. Driver side is more affected because it is used 3x as much and other doors.