2020 FORD EXPLORER Complaints

I experienced catastrophic brake failure on July 14 2026. Total loss of brakes that led me to narrowly miss several vehicles. The Ford Dealership in Manor TX stated it needed the brake booster replaced and program reset. After researching this is a problem with my VIN that was offered free replacement until 2022 this should be a total unexpired recall. I could have lost my life or someone eles! It’s part of the Customer Satisfaction Program 20B51:

I keep feeling a clunk or thump towards the back of the car at random times, towards the back axle. Sometimes it's when i stop and drive forward, other times it happens while I am just driving normally, usually at slow speeds around 5-45mph. I have an extended warranty and the ford dealer has said they can;t replicate it and want to give my car back until it gets worse, and then try fix it. I am highly concerned about this process....

The contact owns a 2020 Ford Explorer. The contact stated that while driving at an undisclosed speed, the brake pedal was depressed; however, the vehicle failed to stop as intended. The contact stated that while decelerating to approximately 25–30 MPH, the vehicle jerked abnormally. No warning lights were illuminated. The dealer was made aware of the failure. The contact was informed that parts were unavailable to repair the vehicle. The vehicle was later taken to an independent mechanic, where it was diagnosed with an incorrect response from the immobilizer control module. The contact was advised not to continue driving the vehicle. The contact relayed the diagnostic information to the dealer. The contact received notification of NHTSA Campaign Number: 26V402000 (Power Train); however, the part to do the recall repair was unavailable. The manufacturer was made aware of the failure. The contact was informed that the repair could be paid out of pocket with a possible reimbursement whenever the parts became available. The failure mileage was approximately 94,600.

The contact owns a 2020 Ford Explorer. The contact received notification of NHTSA Campaign Number: 26V402000 (Power Train); however, the part to do the recall repair was not yet available. The contact stated that while driving approximately 35-55 MPH and coming to a stop, the vehicle shuddered and jerked. The contact stated that the failure also occurred while driving from a complete stop. The dealer was not contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not contacted. The failure mileage was approximately 100,000.

The contact owns a 2020 Ford Explorer. The contact received notification of NHTSA Campaign Number: 26V402000 (Power Train); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at an undisclosed speed, the vehicle jerked back and forth and then stalled. No warning light was illuminated. The contact turned off and restarted the vehicle, but the failure persisted. The vehicle was taken to a transmission specialist; however, the cause of the failure could not be determined. The dealer was not made aware of the failure. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 90,000.

The dash board has a little split where the air bag is located. The split is in a line of or a crease of the outline of the air bag. I took it to the dealership and they were clueless. They recommended someone to fix it, but since it was closely related to the airbag I can't find anybody to work on it. This happened about a year ago it just appeared and each year I think it's getting larger.

My wife was driving and the horn started blowing and the rear wiper started ejecting all the wiper fluid. When I showed up to assist, it smelled super hot and I had to pull the fuse and negative lead to make the wiper pump and horn stop. It was towed to a Ford dealer, who found the main engine harness had MELTED going into the engine compartment fuse box. The horn and wiper fluid pump also had to be replaced. It's fortunate this did not result in a fire. Ford dealer had the vehicle for TWO MONTHS to repair (and we had to take it back for the horn and washer pump). The Ford dealer said they could not give any reason for why this happened. The entire main harness and fuse panel had to be replaced. No check engine or warning lights appeared when this happened. My wife had to pull over on the side of the road.

Back in 2026 I bought a vehicle from Wild West Ford in Guymon ok about three weeks after I bought the vehicle there was a safety recall on it for the rear axle bolt. Ever since the recall was done, I noticed a significant change in my vehicle rear and it shook real bad. basically I was eating my tires and so I took about to wild West and they told me to go get alignment done so I went and got an alignment done, and it still was doing it and I had taken it to at least four different Ford dealerships across two different states and they all told me that there is nothing wrong with my vehicle, so I looked it up on the forum in the procedure on how the recall was done and i find out that the bushing was improperly installed. One of The ford dealership is the one who send me a picture of the bushing even starting to rip. Please help my kids ride in this vehicle everyday and Wild West claimed the recall but did it completely wrong and refuses to fix it so I took it to different dealerships and with each dealership, I specifically asked them to re-look into the recall because I feel like it was done wrong and they all said that it was all up to four specs in the end. there was nothing wrong with it, but here’s the proof that it is so how do I get my vehicle fixed?

The edges of the fabric sunroof cover have come off the tracks, causing the sunroof cover to not roll up properly and block the rear window when open.

I drove to work with no issues, lights or warnings. I parked and worked for 7 hours. Upon leaving and cranking the engine, it immediately showed overheated and went into limp mode. I drove it less than 100Ft, parked and called for a tow. There was no puddles or other indications of an issue. Upon towing to the closest dealership, I was informed the oil cooler failed putting coolant into the oil and "scorching" the engine and I need an entire new engine. The dealership confirmed there wouldn't be any warning lights of this happening.