2023 FORD EXPLORER Complaints

A hissing noise coming from inside the vehicle when braking. The dealership isolated the problem and concluded it comes from the Brake Booster. The car just came out of manufacture warranty at 39,067 miles. However, there is no check engine or dashboard light on yet.

While out shopping yesterday, [XXX], after turning off the car it would not start again. Everything completely shut down. Locks on doors did not work, hatch wouldn't open, fobs did not work (mine or my husband's) and my ford app even went blank. I called AAA and they sent someone out to get the car started. He thought it might be the battery. So my husband took the car this morning to the ford dealer. They said the battery is good and everything checked out. So we still don't know what caused this. The service department said if it happens again to let them know. I'm just afraid this might happen when we are out in traffic. I'm not sure if anyone else has reported the same issue. I would appreciate if someone could look into this issue. The person from AAA told us that he just came from starting an Explorer that shut down at a traffic light in traffic and would not start. This is very scary especially since I take my special needs granddaughter with me most of the time. Thank you in advance for checking into this issue [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My 2023 Ford Explorer ST has rolled while parked, turned off, and in Park, with the electronic parking brake engaged. This has occurred multiple times on my residential driveway, which has an approximate 20-degree slope, during light snow conditions. On one occasion, the vehicle rolled backward down the driveway and into the street after being parked and shut off. On another occasion, it rolled forward while parked in the same location. In both cases, the vehicle stopped on its own without driver input. The dashboard indicated the vehicle was in Park, and the electronic parking brake had automatically engaged. This behavior is inconsistent and occurred in both directions, which raises concern that the parking pawl and/or electronic parking brake is not reliably holding the vehicle. Snow may reduce traction, but a properly functioning parking system should prevent a parked vehicle from rolling, especially into the street. After the December 14, 2025 incident, the dealer was contacted and they replaced the parking pawl. The subsequent incidents occurred on January 14, 2026 while both rear facing and forward facing. This appears to be a vehicle rollaway safety defect and presents a serious risk of collision, injury, or property damage. The vehicle has not been modified, and this occurred under normal parking conditions. I am reporting this issue due to the safety risk and concern that the parking system may not be functioning as designed. I do have a video is of the December 14, 2025 incident when the vehicle was unoccupied, parked, turned off, and in Park, with the electronic parking brake engaged.

Manufacturer Recall Number25S72 NHTSA Recall Number25V442 Vehicle had been taken to and left at the local Ford dealership all day (opening to closing on 11/28 and 12/23/25) twice now with no resolution to this recall ticket. Technician and service manager advised both times that the required update from Ford is not working and they believe the APIM needs to be released, but Ford Service (corporate) must authorize this. Almost two months since the initial appointment and I still have no answers as to when this recall will be addressed. As this is a safety related recall and my vehicle often replicates the problems which are listed in the recall, I would like this matter addressed with a little more urgency by Ford.

While in moderate snow attempted to go from backing up to drive and the vehicle stopped, parking brake auto engaged, powertrain (wrench) trouble light illuminated. The trouble light did not shut off after sitting overnight.

The moon roof cover was being opened backward, small plastic piece popped off. As that piece popped off the rollaway cover disengaged from the track and angled downward. When the moonroof cover was falling the metal piece that holds it straight slid out directly at my babies head! Barely missed him! This has since been repaired at the dealership.

The contact owns a 2023 Ford Explorer. The contact stated that while operating the vehicle, the engine was misfiring, and the vehicle hesitated while accelerating. The vehicle was taken to the local dealer, who replaced the spark plug,s but the failure persisted. Later, while driving, the vehicle went into LIMP Mode and was towed to the dealer, who diagnosed the vehicle and determined that the coolant hose had failed, and the hose was replaced. Shortly after retrieving the vehicle the misfire continued with the check engine warning light illuminated. The vehicle was taken back to the dealer, and the head gaskets were replaced. The vehicle continued to experience failures, and the fuel injector and the crankshaft position sensor were replaced. The contact stated that later, while driving at an undisclosed speed, the vehicle stalled in the middle of the road. The vehicle was towed back to the dealer, who diagnosed that the engine rod bearings had failed, and the engine needed to be replaced. The vehicle was not yet repaired. The contact also experienced electrical failures with the seat heaters and the mirrors. The cause of the failure was not yet determined. The manufacturer was notified of the failure. The failure mileage was 35,682.

There was a recall on my 2023 Ford Explorer. I took it in to have the recall fixed on 09/15/2025 and was told it was repaired on 9/19/2025. The recall was supposedly fixed and i was given an invoice from Al Piemonte Ford in Melrose Park IL 60160. It still shows on the NHTSA website as "not repaired" and it is going on a month since i was told it was repaired. Can someone please look into this and have this recall cleared since it was repaired back on 9/19/2025? I look forward to hearing a response. Thank you,

My vehicle automatically shuts off after 30 minutes of inactivity. This poses a safety hazard as when I 1st received this vehicle from my fleet company I left my 1 year old in there to nap and had no idea that it was going to automatically shut off. Thankfully, it was not a hot day and nothing happened to her. Today I read a story about a 2 year old that died after being left in a vehicle that has an automatic shutoff after 30 minutes. This feature needs to be removed from vehicles as people have been napping their children in cars for many years and many people do not know about this feature and think that their car will stay on and stay cool with the air conditioner. Please do everything you can to get this feature removed from all vehicles.

I have a 2023 Ford Explorer with a sun room/moon roof and the fabric is sagging causing visibility issues due to not being able to properly see out of my rear view mirror. I have not taken it to the dealership to get it checked out but I’m going to as my vehicle already has an open recall on it.