2003 FORD EXPLORER Complaints

TL* THE CONTACT OWNS A 2003 FORD EXPLORER EDDIE BAUER EDITION. THE CONTACT WAS DRIVING 30 MPH WHEN THE OVERDRIVE WARNING LIGHT ILLUMINATED AND THE VEHICLE BECAME HARD TO SHIFT. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING WHERE IT WAS DIAGNOSED THAT THE OVERDRIVE BAND WAS FRACTURED AND POSSIBLY HAD CAUSED DAMAGE TO THE TORQUE CONVERTER. THE MANUFACTURER WAS CONTACTED BUT THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 34,029 AND THE CURRENT MILEAGE WAS 64,846. UPDATED 11/22/11*LJ THE CONSUMER STATED THE SHIFTING WAS ERRATIC AT STEADY SPEEDS, THERE WAS A HARD BANG WHEN SHIFTING. THE PCM WAS REPROGRAMMED. THERE WAS A CLUNK NOISE WHEN COMING TO A STOP. THE DEALER REPLACED THE TRANSMISSION FLUID. THE OVERDRIVE LIGHT ILLUMINATED AND 95% OF THE TIME, THE VEHICLE WOULD NOT SHIFT OUT OF 1ST GEAR. UPDATED 03/12/12

WHILE ENTERING THE HIGHWAY, MY SUV WOULD NOT SHIFT INTO GEAR. THE FASTEST IT WOULD GO WAS 35MPH, THE TACHOMETER WAS PEGGED OUT, THE O/D LIGHT WAS FLASHING ON AND OFF AND TRANSMISSION WOULD NOT SHIFT INTO THE NEXT GEAR. ALMOST GOT HIT BY VEHICLES TRAVELING THE SPEED LIMIT WHICH IS 65MPH, BECAUSE THE TRANSMISSION WOULD NOT SHIFT PROPERLY FOR ME TO MERGE INTO TRAFFIC. *TR

TRANSMISION FAILURE, REPLACED AT DEALERSHIP. NEW TRANSMISION FAILED WITHIN A WEEK, REPLACED AT DEALERSHIP ALSO REPLACED ALL HUB BEARINGS, EXCESSIVE NOISE. REAR END ALSO HAS EXCESSIVE NOISE. REAR BACK UP SENSOR FREQUENTLY TURNS OFF AND DOES NOT WORK. *TR

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED WHEN SHE STARTED HER VEHICLE IT WAS IDLING IT WAS VERY ROUGH. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO ADVISED HER THAT THE TIMING CHAIN FRACTURED AND NEEDED TO BE REPLACED. THE MANUFACTURER ALSO ADVISED HER TO NO LONGER DRIVE THE VEHICLE UNDER THOSE CONDITIONS. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND OFFERED NO ASSISTANCE. THE FAILURE AND CURRENT MILEAGE WAS APPROXIMATELY 93,000.

TRANSMISSION FAILURE....O/D LIGHT FLASHES AND SERVICE ENGINE LIGHT STAYS ON. *TR

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED WHILE THE REAR LIFT GATE WAS OPEN THE HINGE FAILED CAUSING THE GATE TO FALL ON THE CONTACTS HEAD. THE DEALER WAS STATED THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN RECALL NUMBER: 04V442000: STRUCTURE: BODY: HATCHBACK/LIFTGATE: HINGE AND ATTACHMENTS. THE VEHICLE WAS NOT REPAIRED. THE CONTACT STATED THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 68,000.

TIMING CHAIN TENSIONER FAILURE WITH VALVE COVER DAMAGE PROVOKING OIL LEAK AND HEAVY SMOKE OUT OF THE ENGINE, WICH LEAD TO SPILL OF OIL IN THE HIGHWAY (OIL DROPPING) AND ENGINE OUT OF SEQUENCE DUE TO A PLASTIC "CASSET" TENSION BREAK, I HAVE READ OVER THE INTERNET ALOT OF COMPLAINS ABOUT THE SAME INCIDENT

DEAR MAYZEL, I APPRECIATE YOUR TIMELY RESPONSE, BUT I MUST ADMIT THAT I AM MORE THAN A LITTLE DISAPPOINTED (AND CONFUSED). I AM READING FORD EXPLORER RECALL #04V442000, "FORD RECALLS 2002-2003 FORD EXPLORER VEHICLES FOR LIFTGATE GLASS" (SEE BELOW), AND IT SEEMS TO COVER MY MODEL YEAR AND MY SITUATION EXACTLY. THE LIFT HINGE HAS STRIPPED OUT THE BOLT THREE TIME, LEAVING THE GLASS TO HANG FROM THE OTHER HINGE (AND STRUTS). CAN YOU EXPLAIN WHY THIS RECALL WOULD NOT APPLY? SINCERELY, BILL DASCOMB DEAR WILLIAM, THIS IS MAYZEL FROM FORD'S CUSTOMER SERVICE DEPARTMENT. I HAVE READ YOUR EMAIL REGARDING THE BACK HATCH GLASS CONCERN OF YOUR 2003 FORD EXPLORER. I AM TRULY SORRY TO HEAR THAT YOU ARE HAVING THIS ISSUE WITH YOUR VEHICLE. I HAVE PERSONALLY CHECKED OUR RESOURCES AND VERIFIED THAT YOUR VEHICLE IS NOT INVOLVED IN ANY RECALLS OR CSP'S AT THIS TIME. MANY FACTORS ARE USED TO DETERMINE THESE SUCH AS WARRANTY STATUS, VEHICLE HISTORY, CUSTOMER CONTACTS, DEALERSHIP COMMENTS AND SO FORTH. I HAVE REVIEWED IF ANY AVAILABLE COVERAGES MAY ASSIST IN YOUR REPAIR REQUEST. THERE IS NOT ACTIVE ESP TO COVER THE PART OR THE REPAIR AND THE VEHICLE IS OUTSIDE OF ANY APPLICABLE WARRANTY. WE RECOMMEND THAT YOUR VEHICLE BE INSPECTED BY A FORD/LINCOLN/MERCURY DEALERSHIP TO DETERMINE THE CAUSE OF ANY SYMPTOMS YOUR VEHICLE MAY BE EXPERIENCING. ONCE YOU HAVE THE REPAIRS COMPLETED, I STRONGLY SUGGEST THAT YOU KEEP THE ORIGINAL RECEIPT FOR THE REPAIRS, SO THAT IN CASE A RECALL WILL BE ISSUED IN THE FUTURE, THESE RECEIPTS MAY BE REVIEWED BY YOUR DEALERSHIP'S SERVICE MANAGER FOR A POSSIBLE REFUND. THANK YOU FOR CONTACTING FORD. SINCERELY, MAYZEL CUSTOMER RELATIONSHIP CENTER FORD MOTOR COMPANY

AT ABOUT 85K MILES, THE STUDS ON THE REAR TIRES OF MY 2003 FORD EXPLORER BEGAN BREAKING-OFF. THIS HAS HAPPENED THREE TIMES WHILE I WAS DRIVING AND TWICE WHILE GETTING MY TIRES ROTATED. I HAVE PROBABLY REPLACED ALMOST 20 STUDS IN THE LAST 18 MONTHS. I HAVE HAD NUMEROUS DIAGNOSES FROM MECHANICS AND ALL HAVE BEEN WRONG. FINALLY, A SERVICE MANAGER AT QUIRK FORD IN QUINCY, MA ADMITTED THAT HE DID NOT KNOW THE PROBLEM. OF COURSE, I HAVE ALREADY PAID THOUSANDS OF DOLLARS TO HAVE THE PROBLEM FIXED - TO NO AVAIL. THE SERVICE MANAGER CONTACTED TECNICIALS AT THE CORPORATE LEVEL AND THEY RECOMMENDED SEVERAL THINGS. THE SERVICE DEPT AT QUIRK FORD HAD ALREADY DONE ALL OF THESE RECOMMENDATIONS IN THE PAST. THE CORPORATE LEVEL TECHNICIANS CLAIM THAT THEIR IS NOT HISTORY OF THIS IN OTHER VEHICLES, BUT A QUICK INTERNET SEARCH REVEALS THAT THIS IS NOT TRUE. THERE ARE COUNTLESS COMPLAINTS ONLINE FROM 2002-2004 EXPLORER OWNERS IDENTIFYING THE SAME DANGEROUS PROBLEM. *TR

O/D LIGHT SPONTANEOUSLY CAME ON. CAN NOT BE TURNED OFF. TRANSMISSION TAKES OFF SLOW. FIRST GEAR SLAMS INTO SECOND, WITH SLOW TAKEOFF CAUSES CARS BEHIND ME TO STOP SHORT BECAUSE MY TAKEOFF IS VERY SLOW. *TR