2020 FORD EXPLORER Complaints

The contact owns a 2020 Ford Explorer. The contact received notification of NHTSA Campaign Number: 25V093000 (Seat Belts); however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

Sun Shade: Sunroof shade guide has lost the bolt securing it to the shade, will need bolt to re-secure. When retracted back sunroof Sun Shade sags, blocking rearview window. Causes driver to be unable to see out back window. No warning lamps. Problem has been inspected by ford dealership. According to ford the bolt that secures the Sun Shade to the sunroof has come out.

When accelerating to enter the highway the car loses forward momentum and emits a loud grinding sound from the console area from the transmission

The contact owns a 2020 Ford Explorer. The contact's husband stated while driving 60 MPH, the brake pedal was depressed, and the vehicle failed to respond. The Forward Collision Avoidance Automatic Emergency Braking warning light illuminated. The vehicle was taken to an independent mechanic and was diagnosed with a possible sensor failure or transmission failure. The vehicle was not taken to the dealer. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 37,000.

The contact owns a 2020 Ford Explorer. The contact stated while driving at approximately 65 MPH and driving over a slight deformation in the road surface, the vehicle was swaying to the left and right with the Electronic Stability Control warning light illuminated. The contact slowed down and regained control of the vehicle. The contact had not taken the vehicle to a local dealer or independent mechanic to be diagnosed or repaired. Additionally, the contact received notification of NHTSA Campaign Number: 25V093000 (Seat Belts) which linked a failure with NHTSA Campaign Number: 24V493000 (Steering) in the summary; however, the failures were unrelated. The manufacturer was not informed of the failure. The failure mileage was approximately 118,000.

I have 68,000 miles on car and car suddenly started making a thumping sound and jerking when braking. Slip also when driving at low speeds. The Dealership says it needs a new Transmission. I have searched online and found this is a common problem for this year and model.

The wiring is faulty. We have had electrical issues since buying this vehicle. The car is not old- I turned my car on put it into reverse and all these lights popped up saying there’s electrical issues and it can’t work and the brakes legitimately did not work. We almost went into traffic from a business with no ability to break. For a 4-5 year old car this should not even be a thing I feel like. And it should not be having this serious electrical issues. Everything electrical in the car is not working and the fuses are fine according to the mechanic. Si we are going down the list of issues that could be an issue. But he is saying the wiring could just be faulty. Which is scary because it almost cost me and my oldest child our lives.

The vehicle was driven to the destination and then turned off. Upon turning the vehicle back on and attempting to drive it, the vehicle vibrated and shuttered violently at times. The vehicle was looked over on-site before being driven to a mechanic for any loose parts or debris in the fender wells. The vehicle was able to be driven slowly to mechanic and only wide turns could be made or it would shudder and vibrate. After inspecting the vehicle, the mechanic stated that the front axles needed to be replaced and this would solve the issue. Approval for the front axle replacements to be completed was given to the mechanic and the soul was completed. However, the vehicle continued to vibrate and shudder in forward and reverse gears, especially when turning. The mechanic suggested to go to the dealership to get it checked out and reset/reprogram the PCM. The vehicle was taken to the dealer who looked it over and checked for a rear axle bolt failure and then sent it back to the original mechanic to swap the axles as they are unsure if the correct parts were installed. The original mechanic contacted the Ford dealership and ordered the front axles again and installed them. The problem persisted. The mechanic then attempted the completion of the TSB 23-2174 to see if that would help solve the problem. The vehicle was then driven to the dealership to have the PCM reprogrammed and the work completed by the mechanic reviewed. After leaving the vehicle at the dealership for several weeks and having the work completed, the problem persists. However, since this problem started, the transmission or drive train now slips or hips when coming to a stop right at 0mph. It also pops and jumps when taking off in the lower gears.the drive train behaves erratically and feels like something is loose or slipping or of place. The rough shifting and hop when stopping causes concern about the vehicle not stopping or shifting out of gear or into the strong gear or something is coming loose

Low beam projector bulb prematurely fails. Replaced under warranty and failed again. Due to dynamic bending feature dealer recommended replacing entire assembly at a cost of $1500. High beam and dynamic bending works, just low beam out of service. Seems like a less costly option to replace LED bulb. Online research lead to other owners reporting similar failures and replacement cost. Some owners replaced control module which fixed the issue, so it is possible that this is controller fault. But a non-working headlight is a safety issue as well as traffic violation. Is this an issue for this agency?

We received a recall stating that one or more of our seat restraint fasteners may have been improperly secured which may not effectively restrain an occupant during a crash, increasing the risk of injury. However, there are no parts or fix available.