2020 FORD EXPLORER Complaints

I own a 2020 Ford Explorer Platinum equipped with Adaptive LED Headlamps. The passenger-side low-beam headlamp intermittently failed and would turn off while driving. The vehicle displayed the warning message, **"Check Headlamp System – See Manual."** Initially, the headlamp would occasionally begin working again after restarting the vehicle, but for approximately the past three months, the passenger-side low beam has remained inoperative. The failed component is the passenger-side adaptive headlamp assembly and related headlamp system. The vehicle is available for inspection upon request. This creates a significant safety concern because nighttime visibility is reduced with only one functioning low-beam headlamp. It also makes it more difficult for other drivers to see my vehicle, increasing the risk of a crash, especially on dark roads or during poor weather conditions. The warning message first appeared before the headlamp permanently failed. The problem was intermittent at first but has progressively worsened until the passenger-side low beam no longer functions. I have learned that numerous owners of higher-trim Ford Explorers equipped with Adaptive LED Headlamps have reported experiencing the same issue. I understand that similar complaints have already been submitted to NHTSA. The replacement cost is extremely expensive and often requires replacement of the entire adaptive headlamp assembly, leaving owners to pay out of pocket for what appears to be a widespread defect. I respectfully request that NHTSA investigate this issue to determine whether a manufacturing or design defect exists and whether Ford should issue a recall or other corrective action. Also, I do have the vehicle available to show.

The contact owns a 2020 Ford Explorer. The contact received notifications of NHTSA Campaign Numbers: 25V685000 (Equipment), 26V117000 (Visibility), and 26V402000 (Power Train); however, the parts to do the recall repairs were not yet available. The contact was concerned that the incomplete recalls presented significant safety risks, specifically because the contact resided in Alaska, where it rained constantly with low temperatures. The dealer was contacted and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

States “apply parking break before exiting” recall listed but not available. unable to drive vehicle

The contact owns a 2020 Ford Explorer. The contact received notification of NHTSA Campaign Number: 26V402000 (Power Train); however, the part to do the recall repair was not yet available. The local dealer and Sam Wampler's Freedom Ford of McAlester (720 S George Nigh Expy, McAlester, OK 74501); were contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

My Ford explorer has a 3rd row headrest stuck in a down position. So, the passengers head will not be supported in a whiplash situation. I have found many complaints on this issue but cant find what should be a very important safety recall.

The contact owns a 2020 Ford Explorer. The contact received notifications of NHTSA Campaign Numbers: 23V675000 (Power Train), 26V117000 (Visibility), and 26V402000 (Power Train); however, parts for the recall repairs were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that after parking the vehicle with the foot on the brake pedal, the gear shifter was shifted to park(P), and the vehicle unexpectedly reversed and crashed into a nearby brick mailbox and came to a stop. There were no injuries or medical attention needed. A Police report was not filed. The contact stated that the vehicle rolled while parking the vehicle. The dealer was contacted, and it was confirmed that the part was not available for the recall repair. The manufacturer was not made aware of the issue. The approximate failure mileage was 87,159.

The front windshield wiper motor on my 2020 Ford Explorer is experiencing severe intermittent failure and physical binding/clunking while in operation, resulting in a total loss of front visibility while driving in rain. This failure matches the exact root cause and symptoms described in Ford Safety Recall 26S14 / NHTSA Campaign 26V117 (intermittent wiper function progressing to complete electrical continuity failure due to internal terminal misalignment). However, Ford claims my specific VIN falls just outside their designated production date window, leaving my vehicle uncovered under the safety recall despite suffering from the identical defect. Although Ford confirmed there is an active Customer Satisfaction Program (CSP) listed for my vehicle's wiper motor, severe supply chain restrictions and dealership backlogs have prevented repairs. Ford has placed a restricted distribution hold on replacement motors, preventing independent shops and local dealers from securing parts, while requiring a multi-day diagnostic wait during which I am expected to drive a vehicle with non-functioning wipers. Driving a vehicle with active, unpredictable wiper failure poses an immediate safety hazard and severe crash risk. Ford's refusal to expand recall coverage or immediately supply unrestricted safety components leaves vehicle owners exposed to hazardous driving conditions. Furthermore, customers face a mandatory four-day intake period solely for vehicle diagnostics. To qualify for a wiper motor replacement under warranty guidelines, Ford requires the motor to experience total failure while under dealership care. If technicians are unable to duplicate the fault condition during testing, the vehicle is returned to the owner without repair, leaving an ongoing safety hazard completely unresolved. I have also contacted Ford Corporate and filed a formal complaint and that was of no assistance.

The contact owns a 2020 Ford Explorer. The contact received notification of NHTSA Campaign Number: 26V402000 (Power Train); however, the part to do the recall repair was unavailable. The contact stated that while driving and decelerating to merge onto the highway, the brake pedal was depressed and the vehicle felt as if the vehicle had been struck in the rear. The contact stated that the failure had occurred on several occasions while decelerating between 25-30 MPH. No warning light was illuminated. The vehicle was taken to the dealer but was not yet diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not contacted. The failure mileage was approximately 76,000.

While traveling uphill in a turn on a county highway the 4WD fault notification arrived on the dash cutting power to the front 2 wheels. The vehicle slipped however was able to regain control. If road condition had been poor I could of slipped into on coming traffic causing a wreck. I took the vehicle to the dealership and they identified that the front axle disconnect actuator was failing and needed to be replaced. Two weeks prior to the code appearing, I had two episodes of unusual binding while in reverse. Ford has issued a TSB long ago to fix this failed design however will not fix it until it fails.

The contact owns a 2020 Ford Explorer. The contact stated that while driving 70 MPH, the transmission unexpectedly shifted to park(P). The transmission was inoperable after the failure. The vehicle was towed to the dealer and was diagnosed with transmission failure. The vehicle was not yet repaired. The contact associated the failure with NHTSA Campaign number: 26V402000 (Power Train). The dealer informed the contact that the vehicle could be repaired out of pocket because the part was not yet available, and then to submit documents for reimbursement after the part became available. The manufacturer was made aware of the failure. The failure mileage was approximately 114,000.