2020 FORD EXPLORER Complaints

The contact owns a 2020 Ford Explorer. The contact stated that while driving at 30 MPH, the power train warning light illuminated. The vehicle was taken to a dealer where it was diagnosed and determined that the AWD module needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 43,000.

Hard shifting up and down through the transmission shifting sequence. Multiple clutch friction codes and powertrain warnings from Ford service advisor on 3/10/25. Check engine light on. Vehicle mileage 58,735 under warranty but no communication from Ford Motor Company until we brought the vehicle to a dealership. 5-6 week projected repair process at this time. TSB’s on the 10R80 and 10R80 MHT transmissions reported back through 2020 MY. Claim started with Ford Motor Company 3/10/25 and claim number assigned due to mileage of vehicle under the 60,000 mile warranty termination point.

The contact owns a 2020 Ford Explorer. The contact stated that while operating the vehicle, the touchscreen monitor and backup camera display were extremely hot to the touch. The cause of the failure was not yet determined. The manufacturer was notified of the failure, but no assistance was offered. The local dealer was not contacted. The failure mileage was 104,009.

Transmission had been slipping on and off for a long long time. Finally started slipping multiple times in a mile. Transmission needed replaced

Hard Downshifting and Jerking. Valve body replaced 10/2024 for the same issue. Complaint filed at that time as well.

Vehicle came into our shop with the charging system fault light on. Upon checking for codes BCM battery code B11D9:09:0A was present. During diagnosis the technician found that the battery cable was rubbing against the floorboard of the vehicle causing arching/welding of the positive battery against the floorboard of the vehicle leaving visible damage to the vehicle.

The contact owns a 2020 Ford Explorer. The contact stated that while driving at an undisclosed speed, the vehicle unexpectedly downshifted and the vehicle jerked with the check engine warning light illuminated. The vehicle was able to be restarted. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for further assistance. The failure mileage was approximately 101,400.

Transmission failed while traveling on highway. Causing loss of ability to maintain speed or accelerate while in traffic.vehiclw has approximately 82,000 miles. Dealer only reported dark colored fluid as reason to need replacement. No actual cause given.

Transmission downshifts very harsh every downshift. Took to dealer said transmission is out after 100,000. Transmission did go out on the way home from dealership service.

Approximately 2-3 weeks ago (around time car hit 100,000 miles), I began noticing hard downshifts when my car was slowing down between 30-20 mph. It felt as if I was being rear ended every time I came to a stop, with a very forceful physical jerking sensation. I had my husband drive it to confirm I wasn't being paranoid, then had my dad drive it (who has been a mechanic for 40+ years) to get his thoughts. He determined likely a transmission issue and recommended I take it to my local Ford Service Center. Ford confirmed I had a P2704 code and recommended a full replacement of my transmission. I took it to an independent transmission center who confirmed the diagnosis (test drove to confirm hard shifts between 8-7 and occasionally 4-5), but did state the transmission could be rebuilt or repaired instead of fully replaced. On 3-4 occasions, I was attempting to accelerate but the car would not go forward, this occurred while trying to merge onto an interstate/parkway. Additionally, once, when I had my foot off both the gas and brake pedals (coasting), the engine aggressively accelerated on its own and I was in stop and go city traffic, which was terrifying. No lights ever came on the dashboard and no warnings were sent to my FordPass app. There has been a TSB issued (23-2250). I have 2 small children (ages [XXX]) in car seats and I am afraid to drive them around in my car. Thankfully, I have found someone to fix the issue, but it seems it's a very common problem with the 10R60 transmissions from 2020-2022 based on forums and speaking to mechanics. We have been a Ford Family since the 1970s, but this experience has made me never want to buy another one. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)