2020 FORD EXPLORER Complaints

-2020 Ford Explorer -Panoramic Sunroof Shade. -Sunroof shade sagging, blocking view from rear view mirror while driving. -Problem is reproduced every time I attempt to open/retract the shade. This is a recurrent problem with many 2020 Explorer owners. -Awaiting appointment with dealer for inspection. -No warnings prior to failure of shade retraction mechanism. Problem began 2-3 months ago.

In May 2023 the passenger side headlight stopped working. For a few months it would intermittently work then go out. Then we had both headlights stop working. Took it to Ford dealership and they said it was just the passenger side headlight. Since it was LED they had to replace the entire assembly for at total with labor of $2,182.54. Now today Feb. 2025 the driver side LED headlight stopped working. Same issues as before with the same symptoms leading up to the light stop working. Took it to my local repair shop and they will need to replace the entire headlight for around $2,400. I am upset because of the safety issues with these headlights and the cost! Also, reading online there seems to be a lot of people with the same problems on these 2020 Ford Explorers.

Panoramic sunroof shade began sagging over night and now can fall and block view of rear view mirror out of the back of vehicle.

Front headlight low beam. Light randomly turn off. Yes No Alert on dashboard to check manual which provides no information. Internet search reveals this is a very pervasive issue with this vehicles and there should be a recall by ford.

The contact owns a 2020 Ford Explorer. The contact stated while the vehicle was stationary, another vehicle collided with the passenger side of the vehicle and hit the rim. The wrench, the four-wheel drive, the brake, and the hillside warning lights illuminated after the crash. The vehicle was driven to the dealer. The vehicle was repaired for an axel that needed to be replaced, the module PMI was replaced, a revised part for the four-wheel drive shaft was replaced, and a module switch was replaced. The manufacturer was made aware of the failure and referred to the NHTSA Hotline. The failure mileage was approximately 61,800.

The contact owns a 2020 Ford Explorer. The contact stated that the vehicle was taken to an independent mechanic for a routine oil change. While driving at 35 MPH, the vehicle began to make an abnormal knocking and squealing sound. The vehicle began to jerk. The driver turned off the vehicle. There were no warning lights illuminated. The contact stated that the failure was like the failure listed in NHTSA Campaign Number: 23V597000 (Engine and Engine Cooling). The vehicle was towed to the residence. The mechanic determined that the engine needed to be replaced. The vehicle was towed to the local dealer, where it was diagnosed that the engine, turbo, and battery needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 94,000.

The contact owns a 2020 Ford Explorer. The contact stated that during cold weather conditions, the front driver’s and passenger’s side door latches failed to unlock to allow the doors to be opened. In addition, the contact was using the rear passenger’s side door to exit the vehicle safely. The vehicle was taken to a local dealer and both door latching cable assemblies were replaced; however, the failure reoccurred. The vehicle was taken back to the same local dealer where it was diagnosed that front door latching cable assemblies needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 67,000.

Electrical shorting caused the transmission to improperly shift stalling the vehicle on a highway

Sun/Panoramic roof cloth sags if the clips that hold it in place break as they are very brittle. Happened multiple times already. Rear visibility is blocked due to it and cannot use the rear view mirror.

The contact owns a 2020 Ford Explorer. The contact stated while driving at 65 MPH with the cruise control engaged, the vehicle occasionally exceeded 85 MPH and accelerated independently. No warning light was illuminated. The vehicle was not taken to be diagnosed. The local dealer was contacted; however, the vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline. The failure mileage was approximately 72,000.