2017 FORD EXPLORER Complaints

The a-pillar trim came off while driving down [XXX] in Florida. The rubber gasket around the windshield also came off with the trim. This occurred in June 2024. Over a year after the recall Ford still does not have a solution to repair. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2017 Ford Explorer. The contact stated that while driving 65 MPH, the vehicle made an abnormal beeping sound, the cabin lights illuminated unintendedly, and the message "Tailgate Ajar" was displayed. The contact decelerated and pulled over to the side of the road. The contact resumed driving; however, the failure persisted. The contact then became aware that the front driver's side door exterior keypad trim had detached and had fractured into two pieces, causing damage to the keypad wiring system. The vehicle was taken to the dealer, where it was determined that the keypad needed to be replaced. The contact purchased the part from the manufacturer's website, and the vehicle was taken to the dealer, where the part was installed; however, the failure recurred while driving. The dealer was contacted and provided an estimate for the repair. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The manufacturer referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 40,000.

In November of 2024 my 2017 Ford Explorer XLT began to vibrate and shake immensely when put into drive or reverse. The vehicle was taken to repair shop to diagnose the problem, and I was informed that the codes came back as a FORD recall for a torque converter. The vehicle was taken to Karl Flammer Ford in Florida for another diagnostic and I was informed that there was NO RECALL for a torque converter failure from the Chicago plant where my vehicle was manufactured. Ford Motor Company issued a Customer Satisfaction Program 20N07 for engine and 6F35 transmission, also CSP 20B27 in October 2020. It states that: "this program extends the warranty coverage of the automatic transmission torque converter for (12) months from the RO date of Powertrain Control Module reflash under Customer Satisfaction Program 20B27 (I bought vehicle 2/2021). It also states that: "the vehicles covered by this program are Ford Explorers 2016-2019 from assembly plants Louisville and Chicago, build dates Sept. 29, 2014 through March 3, 2019. However, FORD is not honoring the Customer Satisfaction Program. Basically, I bought a vehicle from a dealership with an existing Power Train problem that could have been repaired under an out of date recall (failure to disclose). My vehicle is now inoperable at 80,000 miles and I have to spend $6,500 for a new transmission that should be covered through FORD. Shame, Shame. This major issue needs to be RECALLED at this point.

The contact owns a 2017 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that while driving 60 MPH, the passenger's side A-pillar trim detached from the vehicle. The local dealer was contacted. The vehicle was not repaired. The contact stated that on a separate occasion, while driving 20 MPH, the driver's side A-pillar trim detached from the vehicle. The local dealer was contracted. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was unknown. VIN tool confirms parts not available.

The windshield wipers on my 2017 Ford Explorer will not turn off, when the vehicle is. Of course the wiper switch is in the OFF position and it persists. This issue began without warning and continues consistently. This is distracting, obstructing my vision, and giving me a headache every time I get in my car. This potentially dangerous while driving, especially in dry conditions where the wipers can damage the windshield or reduce visibility by smearing debris. Based on online forums and other owner reports, this appears to be a common issue affecting many 2017 Ford Explorer owners. It also seems to be common in early models of the same generation meaning it has been a known issue and hasn’t been resolved. This should be investigated as a potential manufacturing defect. A malfunctioning wiper system can create a hazardous driving condition and may warrant a recall

The contact owns a 2017 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that while driving at an undisclosed speed, the driver’s side A-pillar trim detached. The local dealer was contacted, and the vehicle was repaired at the owner’s expense. The contact stated that shortly after the repair, the passenger’s side A-pillar trim detached. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 50,000. VIN tool confirms parts not available.

Ford has failed to fix recall for over a year in which side Pilar’s can detach from side of vehicle causing unsafe driving conditions or damage to other vehicles. I have called ford several times over the past year and they don’t have parts to fix the issue and keep advising its months out.

The Roof trim piece flew off while driving and almost hit the car behind me. The other side looks loose as while. I know the A pillars have an open recall on them as while but they said those parts arent available. I already talked with the dealer but they said no recall is available for this Roof trim and I think there should be.

The contact owns a 2017 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

Manufacturer Recall Number24S02 NHTSA Recall Number24V031 Recall StatusRecall Incomplete, remedy not yet available