2020 FORD EXPLORER Complaints

Carr rolls when put in PARK until the Emergency Brake senses the roll and engages.

Transmissions “A” clutch failure diagnosed by Ford service department. There were no warning lamps indicating there was an issue Car start jolting upon acceleration and deceleration in 2nd to 3rd gear. Because of the jolting effect, especially upon deceleration, it put me at greater risk of an accident. Vehicle is only 4 years old.

Oil change and service check was completed on 20 Nov 2024. Maintenance record shows transmission fluid levels passed inspection. Issue started on 23 Nov 2024. Driving at speeds of 65, 55, 45, and 35mph on a highway. When accelerating to the speed limit, a hard shift was noticed at around 45mph. When decelerating to stop light or to reduce speed due to traffic, a very hard shift was noticed. Around 25mph is the hardest shift. On 25 Nov 2024 while increasing speed from 42mph to 50mph, a very loud metal clanking sound was heard at the same moment a hard shift took place. A check engine light came on briefly and went away within one minute. I took the vehicle to a transmission repair shop to inspect the codes. Two transmission over temp codes were shown without the check engine caution light on. The codes were cleared and the vehicle was taken for a two minute test drive. Upon returning to the shop, when the vehicle was put into park, a rough gear shift was heard and felt throughout the vehicle. The two transmission over temperature codes were populated again after the test drive.

I was on [SSS], right before [SSS], traveling back from visiting family for the weekend. My vehicle suddenly lost all power while I was in the fast lane doing highway speeds. Luckily I was able to get over to the sliver of shoulder while there was no acceleration and only a brake . Although I was able to turn the vehicle off and start it again to drive from Los Angeles to Sacramento, it was the most frightening moment of my life. I have multiple recalls on this vehicle that have delayed my ability to register it in my state. I do have an open court case with Ford but they have delayed the hearing date to over a year away. 2026. There are multiple issues with this vehicle and I have not been able to drive this SUV comfortably again since my power loss experience. There may be a safety concern for others who have this vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The transmission shifts hard when going at speed and slowing down through about 30mph. Sometimes it will not accelerate, like when passing another car. Overall poor transmission shifting. This is an ongoing issue.

When placing the car in park using the gear shift selector nob the vehicle rolls until the automatic stop feature kicks in. IF it does not roll you can easily push it. This is a continuous issue, parking by selecting "P" never works. You must set the parking brake, so it does not roll.

While driving at highway speeds I have had a engine malfunction warning or a power train warning appear on my dashboard. The vehicle losses power and has a rattling sound when there is a loss of power. The vehicle steers fine but starts to slow down with the engine rpm dropping to zero. After a few seconds of gliding the engine resumes and I have full power. It seems to happen when I try to accelerate to pass. On occasion it has happened with other vehicles being in the lane I intend to move into or with another car following too closely behind me. I have looked on line about this problem and other people have noted the same problem. I brought the car in to Ford service they had the car for a day and ran it without finding anything. I am not surprised as it only happens occasionally. Of course the day after I had the car in for service it happened when I was driving.

Front Right Passenger Low Beam has gone out. Ford dealership says this part is meant to last the lifetime of the vehicle and does not know why it has gone out. It occurred right after dealer did an oil change. After low beam went out a warning on the dash states to check headlamps. The dealer now wants to charge $2500 to replace the whole assemble. Being unable to see the road entirely is a safely risk especially since the primary driver is a third shift worker and we live an a rural community with a lot of deer and other wildlife.

Power window switch driver window inoperative. Remaining windows works fine . Only the main driver window inoperative.

Driving down the highway 65mph, cruise on, car makes an abrupt violent jerk forward, tires squeal, and car starts fishtailing across all lanes of traffic. Seems as if car spontaneously slammed on the brakes. Nothing crossed in front of the vehicle, nothing in the road, both hands were on the wheel, feet resting on the floorboard. Nothing displayed on the console. Once control was regained car drove per usual, no issues.