1993 FORD EXPLORER Complaints

RIGHT REAR TIRE SIDEWALL BLEW OUT AT 45 MPH IN 4 DIFFERENT SECTIONS. AS A RESULT, VEHICLE ALMOST FLIPPED OVER. *AK

1ST CASE WAS SUMMER TIME, ENGINE WOULDN'T EVEN TURN OVER WHEN TRYING TO START IT. AIR CONDITIONER HAD BEEN ON EARLIER. TURNED THE AIR CONDITIONER SWITCH TO OFF AND ENGINE STARTED AND RAN JUST FINE. ATTRIBUTED THE PROBLEM TO BAD COMPRESSOR LOADING DOWN THE ENGINE. $900 LATER WITH NEW COMPRESSOR AND CONVERSION TO NEW REFRIGERANT I ASSUMED EVERYTHING WAS FIXED. TRUCK IS 2ND VEHICLE NOT USED MUCH UNTIL WINTER. DECEMBER WHILE DRIVING AT NIGHT, I ACCIDENTALLY PUSHED THE HEATER SWITCH IN, (AIR-CONDITIONER ON MODE) AND THE ENGINE INSTANTLY SHUT OFF, AS WELL AS ALL THE LIGHTS AND THE HORN. RESET THE SWITCH AND ONCE AGAIN EVERYTHING WAS FINE. NEVER BLEW A FUSE! EXPECTED A WIRE HARNESS FIRE AFTER THAT! I'D EXPECT THE LOAD LINE TO THE COMPRESSOR TO BE ON A SEPARATE CIRCUIT AND ISOLATED BY A FUSE LINK OR REPLACEABLE FUSE! REPLACED THE $95 SWITCH AND INSPECTED IT. IT WAS ALL MELTED INSIDE. I WONDER IF THE SWITCH WAS THE ORIGINAL PROBLEM AND THE COMPRESSOR WAS ACTUALLY GOOD SINCE THE AIR WAS COLD WHEN IT WAS RUNNING. COULD IT GO FROM GOOD TO INSTANTLY SEIZED? COULD THE CIRCUITRY IN THE EXPLORER SPORT ALLOW A LARGE CURRENT DRAW TO MELT THE SWITCH? IF SO FORD OWES ME FOR THE COMPRESSOR AND LABOR. CAN'T UNDERSTAND WHY A FUSELINK OR FUSE DIDN'T BLOW. ONLY A DEAD SHORT WOULD KNOCK OUT THE LIGHTS, AND HORN. LUCKILY THE SWITCH COULD BE SWITCHED OFF, AS I ROLLED TO A STOP. SECOND ITEM TO REPORT WAS THAT WHILE REPLACING THE BAD RESISTOR COILS FOR FAN'S SPEED CONTROL, THE HEATER ENCLOSURE WAS PACKED WITH LEAVES- VERY DANGEROUS. VACUUMED EVERYTHING OUT. NEED TO FIND OUT WHY THERE IS NO SCREEN SOMEWHERE. *AK

FAILURE OF 1993 FORD EXPLORER FRONT SEAT LOWER HALF AT MOUNTING POINTS. FORD PART 61704, LEFT AND RIGHT. MATERIAL FAILURE DUE TO METAL FATIGUE. MOVEMENT AND FLEXING OF LOWER SEAT FRAME CAUSES MATERIAL FAILURE APPROX. INCH ABOVE ATTACHMENT BOLT POSITION. REPEATED LOSS OF SEAT ATTACHMENT BOLT TORQUE ALLOWED FRAME MOVEMENT, WHICH RESULTS IN MATERIAL FAILURE. SEAT MOVES BACK AND LATERALLY AWAY FROM NORMAL DRIVING POSITION. CAN CAUSE ACCIDENT OR SERIOUS INJURY.

MANUFACTURER CLOSED THE RECALL CASE AND WILL NOT PERFORM REPAIR ACCORDING TO THE DEALER. *LA THE SERVICE DEALER HAD INSPECTED THE REAR LIFT GATE AND SAID THAT THE REPAIR WAS SUBJECT OF A RECALL THAT FORD ISSUED. RECALL#95V164001 *SC THE CONSUMER STATED THE PAPER WORK STATED THE REPAIR HAD BEEN PERFORMED WHEN IT HAD NOT BEEN, BECAUSE THE FIRST TIME THE CONSUMER WAS AT THE DEALERSHIP, DUE TO TIME CONSTRAINTS THE CONSUMER WAS UNABLE TO LEAVE THE VEHICLE. *JB

FIRE IN HEATER BLOWER, 1993 FORD EXPLORER, HEAVY SMOKE IN PASSENGER COMPARTMENT.*AK

WHILE DRIVING 45 MPH, VEHICLE LOST STEERING CONTROL. CONSUMER WAS ABLE TO PULL VEHICLE OFF THE ROAD WITHOUT AN INCIDENT OR ANY FURTHER DAMAGE. VEHICLE WAS TOWED TO THE DEALER, AND DEALER INFORMED CONSUMER THAT STEERING GEAR BOX BROKE AND NEEDED TO BE REPLACED. *AK REPAIR COMPLETED 9/18/03. CONSUMER NOTED HE PURCHASED THE VEHICLE NEW AND WITH 27K MILES ON IT, IT HAS ALREADY BEEN IN THE SHOP TWICE IN ONE YEAR. *PH

CONSUMER NOTICED WHILE TRAVELING, THE BRAKES WERE SMOKING DUE TO OVER HEATING. DEALER HAD BEEN CONTACTED AND THE BRAKING SYSTEM WAS REPLACED. THE BRAKES CONTINUED TO WEAR OUT ONCE A MONTH, THE BRAKES HAD BEEN RESURFACED, ADJUSTED AND REPLACED 5 TIMES. *AK *TT *JB

THE VEHICLES COOLING FAN CRACKED. THE CONSUMER WAS CONCERNED THAT THE FAN WOULD FAIL WHILE DRIVING. PLEASE PROVIDE ANY ADDITIONAL INFORMATION. *NLM

CRUISE CONTROL:1993 FORD EXPLORER- WHILE TRAVELING ON THE HIGHWAY, I HAD MY CRUISE CONTROL ON. AS I APPROACHED ANOTHER VEHICLE FROM BEHIND, I PUT MY FOOT ON THE BRAKE PEDAL TO DEACTIVATE THE CRUISE CONTROL. THE CONTROL DID NOT DEACTIVATE, AND I HAD TO PUSH THE "OFF" BUTTON ON THE STEERING WHEEL TO GAIN CONTROL. THIS ISN'T AN ISOLATED INCIDENT, THIS HAS HAPPENED TO ME ON 3 OTHER OCCASIONS. ALSO WHEN THIS SWITCH GOES BAD, IT IS APPARENTLY TIED INTO THE REAR BRAKE LIGHTS, AS THEY DON'T WORK WHEN IT GOES OUT. ON ALL OCCASIONS WHEN THIS SWITCH GOES OUT, I HAVE TAKEN IT TO A FORD DEALER(ROSS FORD- PIEDMONT, MO.) TO HAVE IT REPAIRED, SO IT SHOULD BE DOCUMENTED. I FEEL THIS IS A SAFETY HAZARD THAT SHOULD BE INVESTIGATED. *LA

WHILE DRIVING DRIVER'S SEAT RECLINED WITHOUT WARNING.*AK SHOULDER BOLT AT THE BASE OF THE SEAT SNAPPED. VEHICLE LEFT ROADWAY BUT CONSUMER WAS ABLE TO REGAIN CONTROL BEFORE AN ACCIDENT OCCURRED. *PH *NLM