2017 FORD EXPLORER Complaints

The contact owns a 2017 Ford Explorer. The contact received notification of NTHSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available.  The contact stated that the vehicle had experienced the failure. The local dealer was contacted.  The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair.  The manufacturer was not made aware of the issue. The failure mileage was approximately 72,000.

Car was running fine then went to start and received warning about car being too hot. Checked coolant and it was low. Refilled and drove home. Upon arriving engine light came on. PO301 code. There was coolant intrusion into the cylinders, leading to engine failure. Rough idle when starting. Did not drive after this. Went to start and car will not start at all. Symptoms include: Coolant loss with no visible leaks White exhaust smoke Rough idle or misfires P0300 / P0301 / P0302 codes Hydro-locked or destroyed engines

The silver roof rack cover on both sides of vehicle completely came off of vehicle while driving. The clips broke off just like the problems listed in another recall for the same year Explorer. There is a recall for all models of the same year and make, however the Limited is excluded from the recall. If someone was behind me it could've resulted in a crash. This recall for this part needs to be for all models.

The driver side headlight low beam LED stopped functioning. I noticed moisture inside the headlight housing. I bought a replacement headlight unit and a control module. The replacement headlight housing has also had the low beam go out, again. Now I have to purchase a module to see if the headlight itself is fine and it's possibly just the module that's going out. A lot of other people are having the same exact issue. This is ridiculous. How is this not a recall item?

I had the rear toe links replaced under recall 21s32 on April 1, 2026. Within a month I started hearing a clunking noise from the back drivers side wheel whenever I hit a bump. My local mechanic looked at the Explorer and said the problem is the knuckle bushing. I contacted the Ford service department and asked them to fix it under customer satisfaction program 22N01. They told me I wasn’t eligible but for $185 they could do a diagnostic test and I’d be responsible for the full cost of any needed repairs.

No warning. It was cold out. I ran into a store. Came back to my car and started it. The rear window defrost automatically turned on. I sat for a few minutes to let my car warm up and the back window exploded. I heard the loud explosion like a gun shot. Look back and the window exploded all into the vehicle. If I had a child in the 3rd row seat they would have had glass all over them. Possibly causing harm to any rear passenger. I since have had the window replaced. But after doing research about complaints. this has happened to several people. Even several times. This is a safety concern and should be thoroughly investigated!

The A-pillar appliqué trim bordering my windshield on both sides has become loose and has been detaching and flying into the road unexpectedly while I’m driving. I have been waiting over 18 months now for parts to become available for this repair as the hazard continues to become worse. The recall details indicate “ FORD MOTOR COMPANY IS WORKING CLOSELY WITH ITS SUPPLIERS TO PRODUCE PARTS FOR THIS REPAIR. WHEN PARTS BECOME AVAILABLE, FORD MOTOR COMPANY WILL NOTIFY YOU VIA MAIL TO SCHEDULE A SERVICE APPOINTMENT WITH YOUR DEALER FOR REPAIRS TO BE COMPLETED FREE OF CHARGE PARTS AND LABOR. PARTS ARE ANTICIPATED TO BE AVAILABLE TOWARD THE LATTER HALF OF 2024.” but I have yet to be contacted to have this repair completed. I am filing this complaint because Ford has failed to address this repair in a timely manner.

While driving approximately 65-70mph on a straight stretch of road back end began to fish tail, unable to control the steering of the vehicle, vehicle slide to right, hitting a ditch, causing the vehicle to roll multiple times . Causing severe damage to car, and bodily injury to driver.

I’ve had three transmissions replaced from 2023 to 2026. Ford no longer makes 2017 Ford Explorer transmissions so I keep getting bad parts. In 2026 engine light came on , coolant leaking into cylinders, $11K to fix. This car has left me stranded on the side of the road , not to mention months at the dealership trying to find transmission parts. Ford Corporation refuses to buy back vehicle based on lemon law. Rear seatbelts defective.

Car started to overheat randomly, no signs of issues before, replaced the water pump for the second time in a year (2025 and again 2026). Continued having issues & white smoke puffing, turned out to have an oil leak due to piston rings being melted to the pistons, causing all spark plugs (prior repalced) and engine to be bad. Car is continuing to worse, sputters just sitting after you start it. Smells like burnt oil. Too dangerous to drive so it’s been sitting for weeks after pouring $3,000 into it to not have it fixed and now needing a new motor.