2013 FORD EXPLORER Complaints

Transmission has failed at 136,000 miles. All maintenance is up to date and has been performed by the dealership. When i pulled out on a main road the car would not accelerate almost causing an accident. I took it to our local mechanic and they had two mechanic's check it and stated the transmission failed. Check engine light show catalytic converter failure, Terraine maintenance failure and solenoid shift failure that came out of the middle of now where .

The contact owns a 2013 Ford Explorer. The contact stated that he depressed the accelerator pedal while shifted into reverse to exit his driveway and the steering wheel seized. The contact depressed the brake pedal and shifted into park. The contact stated that the “electric power steering assist failure” message was displayed. The contact then stated that he inspected underneath the hood of the vehicle, but no failures were detected. The contact then turned off and restarted the vehicle. The warning indicator had turned off and the vehicle operated as designed. The dealer was notified of the failure and confirmed that the VIN was not included in a recall. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 74,000.

For the 4th time since I have owned this vehicle, the trim on the driver's side of the windshield came loose, (the other times it snapped off), the gasket seal around the windshield came loose as a result, loosening the edge of the windshield. The first and second times we thought it was a coincidence or installation problem. By the 3rd time, after Ford denied there was an issue, my mechanic's shop took the time to investigate and found that this is a recurring problem and a design defect. This just happened again and once again I found myself hoping to make it to a store where I could buy tape to hold it all in place until I got home. I used a fair amount of 10x tape, but in addition to severe anxiety and stress over wondering if my windshield was going to peel off (that's what it sounds like), I also had the worry of being in an accident or causing one when the trim snapped loose completely and flew onto the highway. Because I travel for work as well as fun, I am now facing another repair bill that I cannot afford, but cannot do without. All four times this has been at highway speeds. I have reached out to Ford Motor Company and they have denied that there are any reports of problems. I looked online to see that you have opened an investigation and that there have, in fact, been numerous complaints about this same issue. Any support or suggestions would be greatly appreciated, and I am happy to speak in further detail with you. Thanks.

The contact owns a 2013 Ford Explorer. The contact stated while driving approximately 40 MPH, the steering wheel became firm, requiring extra effort while steering the vehicle. The contact stated that the stability control warning light was illuminated. The contact stated that the warning light turned off an hour before the vehicle lost power steering functionality. The contact pulled over and turned off and restarted the vehicle however, the power steering functionality had not returned. The contact had taken the vehicle to an independent mechanic where it was diagnosed and determined that the electronic power steering assist had failed and needed to be replaced. The vehicle had not been repaired. The manufacturer had not been informed of the failure. The contact researched online and related the failure to NHTSA Campaign Number: 14V286000 (Steering). The failure mileage was approximately 156,000.

The contact owns a 2013 Ford Explorer. The contact stated that while driving in a parking lot, the steering wheel seized. The contact was able to restart the vehicle, and the vehicle worked as designed. There were no warning lights illuminated. The contact called the local dealer, who referred her to the manufacturer. The vehicle was not diagnosed or repaired. The manufacturer was contacted, and the contact was informed that the repair was not covered under recall. The contact was referred to the NHTSA Hotline. The contact stated that the failure was related to NHTSA Campaign Number: 14V286000 (Steering). The failure mileage was approximately 98,000.

While turning, the power steering assist stopped functioning, leaving me veering into oncoming traffic as I could not complete my turn without the power steering assist.

The back up camera is now inverted. What is coming from the left appears to be coming from the right, and what is coming from the right appears to be coming from the left. Once the problem started, it has not gone away. The problem was confirmed at an independent service center.

Vehicle began exhibiting intermittent, momentary ABS activation (right front) which would cause vehicle to randomly and severely pull to the right and momentarily flash the traction control warning lamp. This problem began early in 2022 and was first taken to Ford dealership in May 2022. Multiple visits to dealer resulted in inability to diagnose due to lack of recorded codes although they were able to reproduce. Dealer hypothesized a bad electronic steering rack. Subsequent visits to non-Ford repair shops yielded no solution despite replacing ABS Control Module, Electronic Steering rack, yaw sensor, and front struts. Repair shop was able to reproduce. Recently took vehicle to Ford dealer who reproduced and performed pinpoint tests identifying the yaw sensor in the Restraint Control Module (RCM) as most likely cause, but replacement failed to solve. Dealer then removed the front bumper assembly and cleaned and calibrated the cruise control module. Dealer finally identified the problem as a failed Steering Wheel Rotation Sensor and replaced/repaired on May 25, 2023 (over a year after first exhibiting). This part (Ford BB5Z-3F818-A) covers 25 fitments ranging from 2011-2016 and is on national back-order. Speaking with dealers across the US while searching for the part, we found many dealers have been awaiting this part to fix similar problems for a year or more and there were only 7 dealers nationwide with this part in inventory. Based on these facts, it would appear this is likely a "known" issue for Ford, however there has never been a TSB or recall issued to resolve or prevent this from occurring. On multiple occasions, the intermittent ABS activation nearly pulled the vehicle into another lane of traffic and/or into other vehicles' path. I believe this part failure poses a significant safety risk and should, at a minimum, be disclosed to Ford/Lincoln/Mercury dealers via a TSB or through a recall.

Vehicle A pillar flew off while driving on the highway and almost hit a vehicle behind me.

a Ford Dealership informed me my water pump was severely leaking and needed to be replaced. The water pump is located inside the engine, which is EXTREMELY costly to repair. After digging into it I realized that this is common in this type of engine but Ford has not issued a recall in the US, but Canada has a recall. Now we have to come out of pocket to fix this issue when it is well know to Ford that this water pump inside the engine is a massive design and mechanical flaw.