2017 FORD EXPLORER Complaints

I was driving in the Columbia Gorge on highway and the Drivers Keyless entry trim Blew off, and broke in half, the top half hit the car behind me dented his hood and put a nick in his window. I'm very thankful the piece that broke did not cause an accident or kill anyone. The lower half (with the keypad) was flapping in the wind being held on by electrical wires. The keypad blew a fuse, sending me signals that the lift gate was open and I had 4 dogs in the back. Luckily the lift gate did not open, tossing my dogs or belongings on the highway, causing more road hazards.

The contact owns a 2017 Ford Explorer. The contact stated that the passenger's side and driver's side door's exterior B-pillar trims had detached. The vehicle was taken to an unknown dealer, where it was determined that the passenger's side and driver's side door's exterior B-pillar trims needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 100,000.

The contact owns a 2017 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2017 Ford Explorer. The contact stated that the check engine warning light was illuminated intermittently. The vehicle was taken to the dealer, where DTC code: P219C was retrieved. The dealer informed the contact that the engine needed to be taken apart for further diagnostic testing. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 34,820.

Safety Recall Notice 24S02 / NHTSA Recall 24V031 for my 2017 Explorer was done in January 2024 and I received the letter in February 2024. The parts still aren't available after 9 months which is unacceptable. I am now having to use long strips of duct tape on my windshield to hold these loose parts in place which affects my vision to drive and my windshield wipers to work correctly. I wasn't in any accident but concerned about what may happen. This has been going on since July 2024 when I went to the beach and we were going down interstate the piece came loose. We have been using duct tape since that has to be replaced weekly Nothing should take this long and replacements parts need to be made available to repair as soon as possible.

The contact owns a 2017 Ford Explorer. The contact stated that after restarting the vehicle, the message "Power Steering Assist Fault" was displayed, and the steering wheel became difficult to turn in either direction. The vehicle was later towed to the residence. The cause of the failure was not yet determined. The manufacturer and local dealer were notified of the failure, but no assistance was offered. The contact was informed that the VIN was not included in the NHTSA Campaign Number: 17V530000 (STEERING). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 50,000. The VIN was not available.

In 2022 I had the water pump replaced on my 2017 Ford Explorer as it was leaking and i was getting fluids into the oil tank. The mechanic advised that it could destroy the entire engine and cause massive safety issues when driving. Had repairs done at Forder Dealership. On September 26, 2024, I took my 2017 Ford Explorer into the Ford Dealership for another issue and found out that my water pump was cracked again, leaking antifreeze, and that it needed to be replaced. Again, if not replaced massive safety issue could occur when driving. Earlier in September when driving the vehicle on the highway the entire vehicle shut down, lost the power steering, and the vehicle literally died in the parking lot of a tire shop. Replaced the alternator but still had issues with the engine after the replacement which now I learned could have been from the antifreeze leaking out of the water pump. Ford will not cover the replacement of the water pump because it 9 months past the warranty.

The contact owns a 2017 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the front driver's side windshield exterior A-Pillar trim had detached. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 65,000. VIN tool confirms parts not available.

The contact owns a 2017 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact stated that the dealer had removed both trim pieces and had broken the trim pieces and had not replaced the parts. The failure mileage was 33,787. VIN tool confirms parts not available.

In November of 2020 Ford Motor Company issued a recall on vehicles manufactured in their Chicago plant for transmissions torque converter issues under customer satisfaction program 20B27/20N07 which was in effect until November 30, 2021. It was not until September 2022 that I personally started having issues, I took my vehicle to Bob Bell a Ford Dealership for a check engine light issue and completing their diagnostics they confirmed it was a torque converter issue. However, I was advised that my warranty had just ended and it was no longer under warranty to be fixed and I would have to pay out of pocket. I contacted Ford Customer Support Division and they opened case number [XXX] in reference. They advised me the recall was over and to contact the NHTSA who can investigate the matter and issue a new recall for my vehicle. I am requesting an investigation into this matter and Ford be held liable to replace the transmission as a recall and refund me the $195.00 I paid for the diagnostic fee. The transmission issue has affected a large number of vehicles which Ford obviously were aware of and those owners whose issues started after the expiration date of the program should not be penalized and made to pay out of pocket especially when this is a know problem and documented problem with the Explorers manufactured out of the Chicago plant. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)