2008 FORD EXPLORER Complaints

WHILE STATIONARY, WHEN THE KEY IS PUT IN THE IGNITION TO START THE VEHICLE, SOMETIMES THE POWER SEAT WILL GO BACKWARDS AND THE INTERIOR DOME LIGHTS GO ON. LAST NIGHT, WHILE DRIVING BETWEEN 30 TO 50 MPH, THE SEAT MOVED BACKWARDS AND THE INTERIOR DOME LIGHTS CAME ON. THIS IS DANGEROUS AS I COULDN'T REACH THE PEDALS. I HAD TO MOVE THE SEAT FORWARD WITH THE SEAT ADJUSTER BUTTONS WHILE THE VEHICLE WAS IN MOTION DOWN THE HIGHWAY. THIS CONTINUED ON AND OFF FOUR TIMES IN A SPAN OF 2 MILES. FINALLY, I PULLED TO THE SIDE OF THE ROAD AND SHUT THE ENGINE OFF. I RESTARTED THE ENGINE AND DROVE HOME WITHOUT THE SEAT MOVING AGAIN, BUT I KEPT MY HAND DOWN BY THE SEAT ADJUSTMENT BUTTON THE WHOLE WAY HOME. THIS PROBLEM HAPPENS A LOT WHEN THE VEHICLE IS STATIONARY. THIS IS THE THIRD TIME THIS HAS HAPPENED IN THE PAST YEAR WHILE THE VEHICLE WAS MOVING. TWICE THIS VEHICLE WAS IN FOR REPAIR, BUT THE DEALERSHIP CAN'T FIND THE PROBLEM. THEY HAVE REPLACED THE SEAT MOTOR ONCE.

TL* THE CONTACT OWNS A 2008 FORD EXPLORER SPORT TRAC. WHILE DRIVING APPROXIMATELY 15 MPH, THE STEERING WHEEL BECAME LOOSE AND FRACTURED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE CONTACT WAS MADE AWARE OF NHTSA CAMPAIGN NUMBER: 17V181000 (STEERING); HOWEVER, THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

I SMELLED A STRONG ODOR OF COOLANT WHILE DRIVING MY VEHICLE DURING MY WORK DAY. SUDDENLY, STEAM CAME POURING OUT OF THE ENGINE COMPARTMENT, AND I STOPPED AND LET THE VEHICLE COOL OFF. UPON INSPECTION, I FOUND THAT THE SEAM ON THE PLASTIC THERMOSTAT HOUSING HAD SPLIT, POURING COOLANT ALL OVER THE CENTER OF THE ENGINE. PARTS NEEDING TO BE REPLACED WERE THE THERMOSTAT, RUBBER GASKETS AND THE ENTIRE THERMOSTAT HOUSING, UPPER AND LOWER. I REPLACED THIS PART MYSELF, AS I USED TO BE A FORD MECHANIC. I DID THIS REPAIR MYSELF, AND IT COST APPROXIMATELY 200.00 WITH THE COOLANT REPLACEMENT COST. AGAIN, THIS CAN CREATE A HAZARDOUS CONDITION, AND SHOULD NOT BE HAPPENING ON A CAR WITH 80K AND ONLY 7 YEARS OLD.

WHILE IN OPERATION, VEHICLE SEAT GOES BACK AND FORTH, INTERIOR LIGHTS COME ON AND GO OFF AND PEDAL HEIGHTS MOVE. UPON SOME TRIAL AND ERROR INVESTIGATION, TRYING TO REPLICATE THE PROBLEM, I FOUND THAT IT WAS DIRECTLY RELATED TO KEY CHAIN MOVEMENT. ANY BUMPS, MODERATE BRAKING OR HARD BRAKING RESULTED IN THE SEAT BEING THROWN BACK AND THE INTERIOR LIGHTS COMING ON. ( THIS IS A HUGE SAFETY HAZARD, AND COULD EASILY CAUSE A CRASH, ESPECIALLY AT NIGHT ) THE IGNITION TUMBLER IS FAULTY. ONCE THE IGNITION TUMBLER WAS REPLACED AT THE DEALER, THE PROBLEMS HAVE NOT REOCCURRED. I WAITED A NUMBER OF MONTHS TO REPORT THIS SO THAT I WOULD BE SURE THE SOLUTION WORKED AND DID NOT RE-OCUR. I CONTACTED FORD MOTOR COMPANY, WHO REFUSED TO ASSIST. THIS REPAIR COST APPROXIMATELY 300.00

VEHICLE LURCHES IN AND OUT OF GEAR. VEHICLE LURCHES INTO REVERSE FROM PARK, AND IS DELAYED FROM PARK TO DRIVE. VEHICLE FEELS LIKE IT HAS BEEN BUMPED HARD FROM BEHIND AS IT IS DOWNSHIFTING. IN SNOW ESPECIALLY, THIS CAN CAUSE A SIGNIFICANT SDAFETY HAZRD AND RISK OF ACCIDENT. THESE EVENTS OCCUR WHEN VEHICLE IS STAIONARY, AND WHILE IN MOTION THERE IS A SIGNIFICANT DELAY IN TRANSMISSION ENGAGEMENT, WHICH CAN CAUSE A COLLISON. DEFINITE HAZARD WHEN PULLING OUT IN TRAFFIC, WHEN IT DOES NOT RESPOND NORMALLY. THE FIX FOR MOST UNITS IS EXPENSIVE, REQUIRING REPLACEMENT OF VALVE BODY IN THE TRANSMISSION. MY PARTICULAR VEHICLE WAS 5 YEARS OLD AND HAD 63000 MILES ON IT WHEN THE PROBLEM OCCURRED. FORD REFUSED TO ASSIST WITH THIS REPAIR.

TL* THE CONTACT OWNS A 2008 FORD EXPLORER. WHILE DRIVING APPROXIMATELY 55 MPH, A STRONG BURNING ODOR EMITTED INSIDE THE CABIN. THE VEHICLE WAS MANEUVERED TO THE SIDE OF THE ROAD. THE CONTACT INSPECTED UNDERNEATH THE HOOD AND NOTICED THAT COOLANT LEAKED CONTINUOUSLY ONTO THE GROUND. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE THERMOSTAT HOUSING WAS REPLACED. IN 2014, THE THERMOSTAT AND THERMOSTAT HOUSING WERE BOTH REPLACED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 76,194.

SEVERAL TIMES, WHILE DRIVING, THE DRIVERS SEAT MOVED INDEPENDENTLY BACKWARDS AT VARIOUS SPEEDS. THE VEHICLE WAS STOPPED SAFELY. TWO DEALERSHIPS DIDN'T HAVE ANY REFERENCE TO THIS PROBLEM, WANTED TO PERFORM DIAGNOSTIC ANALYSIS AND REQUESTED THE NHTSA WEBSITE THAT WAS MENTIONED. THIS WEB SITE PROVIDED CLUES TO POSSIBLE REMEDY THE PROBLEM. THE VEHICLES EASY ENTRY/EXIT FEATURE MOVES THE DRIVERS SEAT BACKWARDS TO ALLOW THE DRIVER EASY ENTRY/EXIT FROM THE VEHICLE. THIS FEATURE IS THE POSSIBLE FAULT AND WAS DISABLED. TO TEST THIS DISABLING CONCEPT AND STILL DRIVE THE VEHICLE SAFELY SEVERAL PIECES OF WOOD WAS PLACED ON THE FLOOR BETWEEN THE FRONT AND MIDDLE ROW SEATS. THE WOOD LIMITS BACKWARD MOVEMENT OF THE DRIVERS SEAT TO ONE HALF INCH FROM THE NORMAL DRIVING POSITION. VEHICLE CONTROL IS STILL MAINTAINED FROM THIS SLIGHTLY BACK POSITION SHOULD THE EASY ENTRY/EXIT FEATURE NOT BE THE CAUSE OF THE UNINTENDED SEAT MOVEMENT. A YEAR OF DRIVING, WITH THE EASY ENTRY/EXIT FEATURE DISABLED, THE SEAT HAS NOT MALFUNCTIONED. FEEL CONFIDENT THAT THIS DISABLING CONCEPT SOLVED THE PROBLEM. WILL STILL DRIVE WITH WOOD IN PLACE AS INSURANCE.

WHEN DRIVING AT HIGHWAY SPEEDS FOR MORE THAN 15 MINUTES, THE TPMS REGISTERS MONITOR THEN SENSOR FAULT READING. AT REDUCED SPEED, OFF THE HIGHWAY, THE FAULT MESSAGE DISAPPEARS. THE DEALER CAN NOT REPAIR PROBLEM UNTIL FAULT READING REMAINS CONSTANT. IT HAS BEEN MORE THAN 6 MONTHS, NUMEROUS VISITS TO THE DEALER AND MULTIPLE CALLS TO FORD CUSTOMER SERVICE. I BELIEVE THAT A FEDERALLY MANDATED SAFETY FEATURE THAT IS NOT WORKING PROPERLY AND CAN NOT BE DIAGNOSED, SHOULD BE CONSIDERED A PROBLEM.

DRIVING THE CAR IT BEGAN TO LOSE POWER, THEN GET POWER, THEN IT SHUT OFF. RESTARTED THE CAR, STARTED DRIVING AND IT SURGED UNEXPECTEDLY THEN BEGAN TO LOSE POWER AGAIN, THEN IT SHUT OFF. THIS SCARED MY WIFE BECAUSE SHE DIDN'T KNOW IF IT WAS GOING TO SURGE OR LOSE POWER. TOOK IT TO A MECHANIC AND FINALLY AFTER A LOT OF DIAGNOSTICS THEY DETERMINED IT WAS THE ECM OR ELECTRONIC POWER CONTROL MODULE. I HAVE RESEARCHED THIS AND A LOT OF PEOPLE HAVE HAD THIS PROBLEM.. FORD KNOWS OF THE PROBLEM BUT WILL NOT REPLACE THE MODULE. OTHERS HAVE WRITTEN OF THIS SAME PROBLEM. HTTPS://WWW.YOUTUBE.COM/WATCH?V=UCUSQJ3-EVK I JUST WISH SOMEONE WOULD LOOK INTO THIS DO SOMETHING ABOUT IT.

TL* THE CONTACT OWNS A 2008 FORD EXPLORER. WHILE THE VEHICLE WAS COMING TO A COMPLETE STOP, A LOUD NOISE EMITTED FROM THE REAR END OF THE VEHICLE. THE VEHICLE WAS MERGED TO THE SIDE OF THE ROAD, WHERE THE CONTACT NOTICED THAT THE REAR DRIVER SIDE TIRE DETACHED BECAUSE TWO LUG NUTS FRACTURED. THE FAILURE ALSO RECURRED WITH THE FRONT PASSENGER SIDE TIRE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND THE LUG NUTS WERE REPLACED EACH TIME. THE MECHANIC WAS UNABLE TO DETERMINE THE CAUSE OF THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE AND VIN WERE UNAVAILABLE.