2017 FORD EXPLORER Complaints

. The contact owns a 2017 Ford Explorer. The contact received notification of NHTSA Campaign Number: 25V347000( ); however, the part to do the recall repair was unavailable. The local dealer was contacted and it was confirmed that the part was not available. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had experienced the failure causing the B- Pillar trim to eject from the vehicle and the fused was blown. The failure mileage was 102,000.

The contact owns a 2017 Ford Explorer. The contact received notification of NHTSA Campaign Number: 25V347000 ( STRUCTURE); however, the part for the repair was unavailable. The contact stated the manufacturer had exceeded a reasonable amount of time for the remedy to be available. The contact stated that while driving approximately mph unknown, the A-pillar trim on the driver's side of the windshield detached, hitting the vehicle behind them. The contact stated that after speaking to the other vehicle's driver, there was no damage found. The contact continued to drive. The dealer was contacted, and it was confirmed that the VIN was not included in a recall for the A-pillar trim. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the issue. The failure mileage was approximately 110,000.

Odometer Fraud. The contact purchased a 2017 Ford Explorer. The contact stated it was discovered that there was a mileage discrepancy. The vehicle was a dealer sale. The contact was provided a report at the time of the purchase by the dealer. At the time of purchase, the vehicle mileage was 55717. After obtaining the Carfax report, it was discovered that the mileage was 80,758. No other agency was contacted. The VIN was not provided.

UNKNOWN. The rubber seals and plastics that hold my windhield in place are all cracking and fading significantly faster than they should be. The windshield has started leaking due to the fact that ford has not ensured that the peices were up protected

I have a 2017 Ford Explorer, that has a recall of A pillar trim piece, which I have been trying to get replaced since 2024. To date the dealership is telling me they don’t have the part. This part on the driver side has come off and I am concerned the passenger side will. I can only hope it does not come off and cause damage to other vehicles. Ford has issued a recall and is not provided the necessary part. This is a safety concern and I wish to file a complaint.

The contact owns a 2017 Ford Explorer. The contact stated that while driving at 55-60 MPH the front windshield trim on the passenger side had detached and almost hit another vehicle. The other side was also loose. The contact received the recall notification letters for NHTSA Campaign Number: 24V031000 (Structure) and NHTSA Campaign Number: 25V347000 (Structure). The vehicle was taken to the local dealer who ordered the parts 2.5 months ago. The vehicle was not diagnosed or repaired due to the parts being backordered. The manufacturer was contacted, who confirmed the status of the parts. Additionally, a case was opened and closed. The failure mileage was approximately 65,000.

The dashboard cover has come unglued from the part of near the front windshield. It first bubbled up then became unglued and rolled up. There’s white material underneath that appears to have swollen up like wet cork board. Also, this part of the dashboard is no longer flush like the parts to right and left of the distressed area. Additionally, the exposed white part reflects in my line of sight causing limited visibility which is a safety concern to me. Based on my research, this issue is being reported by owners of the 2017 and 2018 Ford Platinum Explorer models particularly. This issue is not something that I can repair as a DIY and since others are reporting the same exact issue with the same models, I tend to believe there’s a defect.

I am filing a safety complaint regarding my 2017 Ford Explorer XLT with the 3.5L V6 engine due to a known internal water pump design defect. The water pump is located internally and driven by the timing chain. When it fails, coolant can leak directly into the engine crankcase and mix with motor oil instead of leaking externally where it would be easier to detect. This creates a serious safety hazard because the engine can suffer catastrophic damage, sudden failure, loss of power, or complete shutdown, sometimes with little or no warning. In my case, the vehicle experienced symptoms consistent with internal water pump failure, including my car overheating out of nowhere, forcing me to coast to the side of the highway in very unsafe conditions. This defect can destroy the engine and create dangerous driving conditions, especially if power loss occurs while driving with children or passengers, thankfully I didn't have any of my three children with me when this happened. This appears to affect many Ford Explorer vehicles from similar model years, and numerous owners have reported similar failures. The repair cost is extremely high because replacement often requires major engine disassembly or full engine replacement. I am currently financing this vehicle with a balance of $14,000 left to pay and have already paid close to $28,000. This is extremely unfair and the cost to repair is close to $5,000. I don't see a way for myself to afford that. I believe Ford should be required to address this issue because: The design can allow coolant contamination inside the engine without obvious external leakage. Failure can occur suddenly and create safety risks. Repair costs are excessive for what appears to be a widespread defect. Owners may not receive sufficient warning before catastrophic failure. I am requesting that NHTSA investigate this defect for safety implications and determine whether a recall or broader manufacturer accountability is warranted. Thank you for your time.

Recall on exterior a-Pillar trim. Been to dealer Star Ford, Glendale, CA multiple times they are claiming Ford has not sent any parts to them. Almost seven months has passed, no parts from recall notice. What's going on? NHTSA Recall 24V031 [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

While driving on the freeway the exterior b-pillar became partially detached from the drivers side of vehicle, causing the pillar to hang off the side. Very unsafe as it can strike another vehicle, or pedestrian. Part is now being held on by duct tape so it stays in place. The b-pillar part is attached to the electronic key number pad. Since this part was detached, the dome lights inside of the vehicle, stay illuminated for 10 mins after exiting. When entering the vehicle and turning it on to drive, the dome lights will not turn off until a speed of 5-10 MPH is reached. I have noticed abnormal car battery drainage because of these events. Additionally, the rear lift-gate no longer functions since the b-pillar detachment. Unable to open rear lift-gate at all. Unable to use the electronic keypad. Spoke to the dealership at least 10 times now and the same reason is given: “we have not received the parts.” They have stated that the parts were ordered for my vehicle in November of 2025. It is now the end of April 2026. Notice of this recall was 5-23-2025