2023 FORD EXPLORER Complaints

Around 20,000 miles, I took my vehicle to the dealer due to rattling and knocking in the front right wheel well and it was discovered the stabilizer arm was cracked. Received the vehicle back, and approximately 1000 miles later, there is rattling at the front driver and passenger wheel well and squeaking going down the road. The sounds coming from vehicle are that of a 40-year-old vehicle.

The contact owns a 2023 Ford Explorer. The contact stated while driving 60-70 MPH, the rear subframe bolt detached, and destroyed the axle. There were no warning lights illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 23V675000 (Power Train). The vehicle was towed to the local dealer, where it was diagnosed and determined that the rear axle was damaged, and the horizontal bolt had fractured in half. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was approximately 20,000.

I have had 4 Ford Explorers that have the same problem that Ford has not commented on when I complain. If the car is parked facing down a hill with less than 1/4 tank of gas it won't start. The design of the tank precludes gas from reaching the engine. Unable to start the car, it cannot be brought out of park and rolled to a flat location. This time I had more than 1/4 of a tank and the same problem occurred. This happened in my driveway but what if you're on a street with an incline?

popping/rattling sound coming from front passenger side and transmission is shifting hard at lower gears. vehicle is in shop waiting on repairs. front struts bad and had to be replaced at 12,555 miles. transmission software had to be upgraded and wiring harness for transmission under vehicle had to be repaired.

The contact owns a 2023 Ford Explorer. The contact stated while driving 27 MPH, a vehicle abruptly exited a parking lot without adhering to oncoming traffic. While attempting to avoid striking the vehicle, the contact activated the parking brake. The contact stated that after releasing the parking brake, the contact became aware that the parking brake handle became loosened and appeared to have disconnected from the socket. The contact later became aware that the parking brake had become inoperable. The vehicle was taken to a dealer, and it was confirmed that the parking brake was inoperable and needed to be repaired. The contact was informed that the repair was not covered under warranty and the contact was provided an estimate for the repair. The manufacturer was notified of the failure, and the contact was provided a case number. The contact was later referred to the NHTSA Hotline to file a complaint. The vehicle was not repaired. The failure mileage was approximately 20,000.

The contact owns a 2023 Ford Explorer. The contact stated that while driving at various speeds, there was an abnormal rattling and popping sound coming from the passenger's side. The contact also stated that the steering wheel would veer to the left or right directions independently while driving. No warning lights were illuminated. The vehicle was taken to a local dealer where it was diagnosed that the front passenger's strut needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The approximate failure mileage was 10,000.

On 11-21-24, I was traveling down the interstate going at 60mph when a car began to urgently brake, I proceeded to hit the brakes as well and my car would not stop, at the time of the impact no air bag deployed, driver seat belt did not lock, my driver seat moved, no pre-collision assist came up for this accident. No prior issues or lights on dash.

While driving on a two lane, rural road at dusk, with adaptive cruise control turned on, the car suddenly applied the brakes (hard) and a red warning briefly appeared on the dashboard. (It was on too brief to read.) The brakes were released quite quickly, but the vehicle had slowed approximately 20 MPH. There was no other traffic on the road at the time. No animals were crossing the road when the incident occurred. The weather was clear and visibility was good. Although it was dusk, the landscape was clearly visible without headlights. This is a rental vehicle and I have not used cruise control since the incident. NOTE: Had another vehicle been driving behind my vehicle, it could have rear ended it. This is a rental vehicle. Rented from Enterprise in Woodland CA. The registered owner is EAN Holdings LLC of Tulsa.

The contact owns a 2023 Ford Explorer. The contact stated while driving 15-20 MPH, the vehicle stalled on several occasions. The vehicle was restarted after fifteen minutes. The vehicle failed to unlock from inside or outside with the key. The contact stated that several unknown warning lights were illuminated. The vehicle was taken to the local dealer, where it was diagnosed and determined that the ground wire had caused the failure. The vehicle was repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 10,000.

The contact's wife owns a 2023 Ford Explorer. The contact stated while driving at various speeds, there was an abnormal knocking sound coming from the front end of the vehicle. The vehicle was taken to the dealer, where it was determined that the front struts had failed and needed to be replaced. The vehicle was repaired; however, the failure recurred several times. The dealer replaced the front struts three times; however, the failure persisted. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 24V091000(Suspension, Steering); however, the VIN was not included. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 2,000.