2020 FORD EXPLORER Complaints

The contact owns a 2020 Ford Explorer. The contact stated that after pulling into the driveway of the residence, the vehicle failed to shift into park(P). The vehicle was turned off. The vehicle was taken to a dealer, where it was diagnosed that there was parking system damage within the transmission, and the transmission shaft needed to be replaced. The vehicle was not repaired. The contact believed that the failure was associated with NHTSA Campaign Number: 23V069000 (Power Train). The manufacturer was notified of the failure and a complaint was filed. The failure mileage was approximately 65,000.

The contact owns a 2020 Ford Explorer. The contact stated while driving 15 MPH, the vehicle failed to accelerate and there was an abnormal cracking sound coming from underneath the vehicle. The contact was able to pull to the side of the road. The contact stated that upon inspecting the vehicle, she became aware that the rear axle had detached. The vehicle was towed to the dealer, where it was determined that the failure was related to NHTSA Campaign Number: 23V675000 (Power Train). The vehicle was being diagnosed. The vehicle was not repaired. The manufacturer was notified of the failure and a case was opened. The manufacturer referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 22,000.

Ford changed a part that my vehicle has and now the new part does not have my sensor and requires my car to be reprogrammed.

The contact owns a 2020 Ford Explorer. The contact stated while driving 40 MPH, there were exhaust fumes inside the vehicle. There were no warning lights illuminated. The vehicle was taken to the dealer and a diagnostic was performed. The dealer stated there were 2 cracks in the exhaust system, causing the exhaust to enter the cabin of the vehicle. The dealer also stated that both flex pipes needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 27,000.

The contact owns a 2020 Ford Explorer. The contact received notification of NHTSA Campaign Number: 23V675000 (Power Train) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2020 Ford Explorer. The contact stated while driving 20–30 MPH and downshifting, the contact detected an abnormal clunking sound coming from the vehicle. The driver pulled to the side of the road. There were no warning lights illuminated. The vehicle was taken to the local dealer, where it was diagnosed that the transmission needed to be replaced. The vehicle was repaired. The manufacturer was contacted, opened a case, and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 69,160.

On [XXX] I was driving my 2020 explorer east bound on [XXX] just past the [XXX] intersection in Aurora, CO when all kind of warning lights lit up on the dashboard. (Parking brake engaged, pre collision prevention system failure, ABS light, check break system and other warning lights as well) the vehicle had a hard time stopping when I applied brakes almost caused a collision. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

While driving, the car shifts gears and does not allow me to drive at the speed I’m at and engine strata to rev. I have to pull over, put the car in park for it to go back. I have had this issue “fixed” twice at the ford dealer. I just recently took it in and they charged me $175 to reprogram the vehicle for this issue, and it happened again 2 days later. My concern is that occurs when I’m driving, and causes me to stop, and if I am not in a place where I can stop it could be dangerous.

Took vehicle to Ford dealer to investigate whining noise at acceleration from a cold start. No warning lights. Dealer verified whine noise. Also found leak in transmission cooler. Removed and replaced transmission cooler. Not covered by a recall, although there is a recall for some vnn vehicles of same year and model for this defect.

The contact owns a 2020 Ford Explorer. The contact stated while driving and shifting to another gear it was difficult to shift and jolted the vehicle. There was an abnormal clunking noise detected. The maintenance light was illuminated. The vehicle was taken to an independent mechanic who stated that a transmission replacement was needed. The vehicle was taken to the local dealer where it was diagnosed that the transmission needed to be replaced but was not repaired. The manufacturer was contacted and referred to the NHTSA Hotline. The failure mileage was approximately 44,000.