2020 FORD EXPLORER Complaints

Out of nowhere, there was an issue with downshifting between 4th and 3rd gear. A loud clunking noise started every time on the downshift. I took it to a transmission shop, they diagnosed that there was significant issues downshifting from 8 to 7, 7 to 6, and 4 to 3. I was notified it was still within manufacturers warranty so I took it to a ford dealership. They felt the issue when test driving it then notified me that it needs “a total tear down of the transmission” but didn’t tell me the specifics of the issue. All of this happened without any warning lights showing on the dash.

On 02/05/24 my 2020 Explorer XLT alerted me that the pre collision assist was not available, to service advancetrack, Hill Start assist not available, 4wd fault service required, and to see manual. The alert went away after I restarted the car, but it came back on again 02/06/24. In addition to the alerts on the dashboard, the vehicle had delayed acceleration after standing at redlights. I took it to the dealership who told me I needed part #7p238 MOD ASY DRV LN CONTR, they also informed me the part was not covered under my extended warranty plan. I called Ford manufaturers directly, spoke with Miracle who informed me that Ford would not offer any financial assistance with replacing this switch. The price is $770. The vehicle has 70,666 miles.

There is an exhaust leak under the car that propagates into the ventilation system and also when a door is open while idling. This is a known issue for some models with the 3.0L engine under emission recall (21E11), but does not include my VIN even though the powertrain is identical. Dealer replaced some flex tubing to try and correct, but that did not work. It's a safety issue because the smell is strong and there's no way to tell how much carbon monoxide is present to the passengers.

The contact owns a 2020 Ford Explorer. The contact stated that the front passenger’s side headlight intermittently failed to illuminate with the "Check Headlamp System See Owner’s Manual" message displayed on the instrument panel. The failure persisted, and the driver’s side headlight also failed to illuminate as needed. The vehicle was taken to a dealer where the contact was given an estimate for the repair. The contact decided to replace both front headlight modules which corrected the failure; however, the warning message remained on the instrument panel. A week later, the driver’s side headlight failed to illuminate as needed, after which the passenger’s side headlight also failed to operate as designed. The dealer and manufacturer were notified of the failure and informed the contact that there were no recalls on the vehicle. The vehicle was not repaired. The failure mileage was approximately 57,000.

The contact owns a 2020 Ford Explorer. The contact received notification of NHTSA Campaign Number: 23V675000 (Power Train) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer and several unknown dealers were made aware of the issue and confirmed that parts were not yet available. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

Randomly one day, the transmission started lurching on downshift between gears 3 and 4. This pattern continued, regardless of driving status without any malfunction indicator lights. This sudden downshift, lurching, caused a rapid decelleration in the vehicle causing me to step on the brakes while in traffic to address the issue. The vehicles issue was identified and confirmed by the dealer and is currently being addressed with no solution being presented. As previously mentioned, this mechanical issue happened suddenly, without any sort of warning lamp or message and without any previous issue and appeared randomly, on a commute home from work.

The back hatch has opened 4 times with no warning. The vehicle was in motion. First Time September 2021: I was backing out of my garage, the hatch came open and hit my garage door, it bent the hatch and it was repaired by RT Auto Centerville Iowa and garage door had to be replaced. Second time November 2021: I was backing out of my driveway and it came open with no warning, no damage. Third Time October 2022 I was backing out of my garage, the hatch came open and hit my garage door again, no warning, Repaired by Copeland Repair Center Oskaloosa Iowa Fourth Time February 2023: I was backing out of my garage, the Hatch opened with no warning & hit my garage door, the hatch, and camera were completely replaced and the vehicle had to be painted by Copeland Repair Center Oskaloosa Iowa. Prior to the fourth incident, I contacted FORD Motor company and was advised there was no recall or complaints on this issue and was told to go to the FORD Dealership. I went to the Ford dealer and was advised to take the problem to the repair shop, it was not FORD's issue that they had check it and found nothing wrong. Since the camera and hatch have been totally replaced, this has not happened. I am worried to have passengers in the back row seats due to this issue, for fear it will come open and someone will get injured. I purchased this vehicle new in May of 2020 from Junge Motors, North Liberty, Iowa. [XXX] [XXX] [XXX] [XXX] I only have one of the 3 Estimates. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6

The contact owns a 2020 Ford Explorer. The contact stated while driving at approximately 55 MPH, there was an abnormal sound coming from the rear of the vehicle. The contact stated no warning light was illuminated. The contact had taken the vehicle to an independent mechanic who checked the vehicle visually and became aware that there was fluid leaking from the differential onto the driveshaft. The mechanic referred the contact to a dealer to have the vehicle diagnosed. The vehicle was not repaired. The contact researched online and related the failure to NHTSA Campaign Number: 21V154000 (Suspension). The manufacturer was informed of the failure. The failure mileage was approximately 65,000.

The chrome trim on the 2020 Ford Explorer inside door handle and window switches is separating/peeling off and is very sharp. My neice sliced her finger and was bleeding from the inside passanger door handle chrome that is peeling/separating from the handle when opening the door to exit the vehicle. I have cut my finger on the chrome tipped window switches.

Issues with the rear liftgate opening and closing on its own it will close open and partially close partially open at random in the middle of the night at random it keeps going till it kills my battery It closes when your underneath and causes a safety concern if you were not aware and get out of the way quick enough. Took it to dealership it needs a wiring harness due to corrosion and a switch. I see other people reporting the same with water leaks causing corrosion.