2020 FORD EXPLORER Complaints

The contact owns a 2020 Ford Explorer. The contact stated while driving at undisclosed speeds, the passenger’s side rear brakes were scraping. There were no warning lights illuminated. The vehicle was taken to the local dealer for NHTSA Campaign Number: 23V675000 (Power Train). The vehicle was repaired; however, the brake failure persisted. The manufacturer was not notified about the failure. The failure mileage was approximately 40,000.

Failure of panoramic moon roof gasket, and in adequate drainage system installation. This causes substantial water intrusion into vehicle. Flooding of drivers side floor causes extremely slippery and wet conditions when operating the pedals. Water migration into vehicle has potential to impact electronics, causing further damage and dangerous driving conditions. Vehicle has been inspected and problem confirmed by the dealership, who contracted a water leak specialist to identify the issue. No warnings prior to appearance. Issues has been ongoing for the past 3 months - 1,000 miles and 4 months after the end of bumper to bumper warranty.

Drivers assist failed and caused me to cross lanes into the cable barrier on interstate 40 causing 18,000 dollars worth of damage now the parking assist no longer works

We turned the vehicle on and a parking brake error came up on the dashboard followed by the dashboard lighting up with a lot of warnings. The vehicle was turned off and back on but continued with the error. Because we were out at a store and not home, we tried to drive it. We placed it in reverse and when put in drive, the brakes did not work with engaged. There was a small bumped that was able to stop the vehicle. I called Ford and they offered to run diagnostics on the vehicle for next week but could not guarantee a paid rental for the length of time needed for the repair. After exiting the vehicle, letting it rest for 5 minutes and restarting again, we were able to drive home with the brakes working again.

While driving my Explorer at night on an unlit road in north western New Jersey the instrument cluster in my car displayed a warning message stating, “Check Headlight System, See Manual”. I pulled over and inspected my cars exterior lights for abnormalities, found none. With the headlamp warning light still on I proceeded on my way home when approximately 10 miles further down the road my driver side low beam turned off completely drastically reducing my visibility of the road ahead of me. Making it incredibly unsafe to me and the passengers in my car. On my way home I got pulled over by a local police officer for an out headlight. I explained the issue and they let me off with a warning. I immediately brought my car to my local Ford dealership to be further inspected. They proposed that the headlamp control module was causing the issue by diagnosing using their “pin test”. After replacing the module ($1,000) at the dealership I drove the car less than 10 miles away from the dealership and the headlamp warning light turned back on and the driver side low beam turned off once again leaving me stranded without light on the road. This cycle continued several times and Ford had no explanation as to why it’s happening. I was sent a quote to pay full price for the repair ($2,500) because I was out of Ford’s 36,000 mile limited warranty. A new car that leaves me without a driver side low beam on a dark road poses an incredible risk to me and my passengers as well other drivers and is unacceptable. Not only is an out headlight illegal and a ticket able offense what if there was an animals or debris on the road while I was driving with my 8 month old niece? My down the road sight is exponentially reduced because the driver side low beam is out. The car had less than 36,500 miles when this issue first occurred and it’s been an ongoing problem ever since. An LED headlamp is supposed to be a “lifelong” vehicle part and it’s failing before the car is fully broken in.

We are having issue with the “Check Headlamp System Check Owners Manual” display on the dash. Took it in for repair under warranty. They replaced passenger side headlamp. The warning still appears on dash. Is this an electrical issue? Will this cause a fire if it’s a short somewhere? Will the lights just malfunction going down the road if issue is not corrected? These are all questions I have and am concerned about my family’s safety…

Transmission failure at 48k miles under normal driving conditions. Down shifts from 7th to 6th gear you hear noticeable clunk and vehicle jerks as described under Ford TSB 20-2337

During the past 4 months or so, I have noticed burning sensation in my eyes and tightness in my throat and lungs whenever I get into the vehicle even when the ignition is not even turned on yet. Recently, it got to the point that I am experiencing headaches while driving. I don't feel these sensations when driving my old 2016 Honda Civic or being inside any other car. Last December 2023, I brought and left the vehicle for a week to Future Ford of Clovis dealership in Clovis, CA for diagnostic tests. They did not find anything wrong and no report was made since they did not find anything that might have caused any issues. As of this writing, the problem persists and I do not feel safe anymore being inside this 3-year-old vehicle, let alone drive it.

Trunk hatch will not close or open properly, intermittently works, rear camera display turns off, does not work at times, display controls work intermittently

The contact owns a 2020 Ford Explorer. The contact stated that while driving at an undisclosed speed, the pre-collision assist, service engine, four-wheel drive service, and advancetrac service warning lights illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the front axle. The vehicle was not repaired. After investigating the failure, the contact related the failure to Technical Service Bulletin: 21-2174. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was 60,000.