2020 FORD EXPLORER Complaints

The contact owns a 2020 Ford Explorer. The contact stated that while exiting the vehicle, she observed the front driver's side seat control housing separating, hindering the use of the seat controls. The failure was later observed in the front passenger’s side seat. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 16,000.

I had an oil change at the Feldman Ford Dealership on or around 3/7/2023. On 4/14/2023 at or at round 5-6 pm; I was traveling southbound on I-75 when my 2020 Explorer suddenly slowed down from 70 miles per hour to around 40 miles per hour while I’m in the farthest lane and it wouldn’t go pass 45 miles per hour almost causing the vehicle behind to rear end me. The dash displayed a reading stating the oil pressure is low and to get engine serviced. I put on my hazards and safely made it to exit off of the freeway. I stopped at a gas station because the engine was making a loud screaming noise. I called my salesman from Feldman Ford and explained what was happening and what the dash was saying so he asked me to shut off the engine and to check the oil. So when I opened the hood I saw oil everywhere and the engine was so hot that the heat was burning my face. The dipstick was indicating that the oil was low to empty. He stated that’s impossible you just had an oil change 4-5 weeks ago and the engine appears that it’s not cooling. So he advised me to put in 2-3 quarts and get on my knees to see if any oil is leaking underneath and there was no leak after I put in 3 quarts of oil. So he asked how far was i from home i told him no more than 15 minutes, then he asked me to start the car to see if the noise diminished and it was not as loud so he said to see if I could get the car home because I had my 1 month old grandson and my daughter with me and he will have a tow truck to come and get it. I made it a block from my home then the car shut off and wouldn’t start. So I had family to come get my daughter and grandson and I stayed with the vehicle until 930/10 pm when the tow truck arrived and my vehicle has been at the Feldman Ford service lot ever since 4/14/2023 and it has not been fixed or worked on. I was told that the oil pump failed causing 2 or 3 seals to go bad in the back and front of the motor. The Ford app displayed engine issues 2 months prior to my purchase.

17 recalls, multiple recalls for the same thing with the rear view camera Currently have another recall on the rear view camera with no exact date on when remedy will be available. Sounds like a qualifying lemon to me.

Both front seats have brackets that have broken and come apart. Service says this is seen all the time. Pants and skirts get caught in it all the time.

The Radio would not keep stations and eventually was almost always static. I took it to the Ford dealership that I purchased from since it is supposed to have a full warranty. They are now saying that it has water leaking in from the roof and it has damaged the OEM (?) system. They don't know if Ford will cover under warranty so I now sit with no vehicle as they wait for a decision. When and if it gets repaired I will now have to worry about other damage that will be caused by a leaking roof vehicle.

Car hesitates on acceleration; almost hit by oncoming traffic. Dealer reports a broken axle on 4 wheel drive assembly. Apparently there is an open investigation on this?

I have had the previous recall for my rear camera/display screen repaired in 08/2022. However, recently I have had my display screen start to glitch and turn off intermittently. Sometimes this happens while I am driving. Other times is happens while I am in reverse and the reverse camera does not work. When the reverse camera is not functioning there is concern for unseen dangers. I have videos of this but I cannot upload them into the form.

My passenger side low beam Headlamp stopped working in Nov 2022. I had a "check headlamp" warning light. I took it to the dealer on 12/09/22. They stated that they found code B155A:96 requiring replacement of the LED control module, requiring part #JX7Z-13C788-L (total cost $1112.25). Headlamp was operational approx 1 week. Returned to the dealership 12/16 with a non-functioning light. They installed RT Headlamp asset, performed calibration, and adjusted horizontal position. Requiring part #MB5Z-13008-AG (total cost $1750). The headlight remained operational for approx 6 months. The "Check Headlamp" warning light has come on again and I will need to have further repair. Having an intermittently functioning or non-functioning Headlamp makes driving at night or in the rain both unsafe and illegal. The cost of this repair was not covered by warranty.

Child Safety Lock - rear right door Regardless of position of safety lock - door is not fully operational. Generally does not open from the inside, however one out of ten times estimated door will open. No way to turn child safety lock on to secure. Had independent inspector and retail location look at vehicle. They recommended replacing the latch. Further research shows that Ford Broncos from 2020 to 2022 have similar issue with same door (right, rear). Would like investigated to ensure not impacting other vehicles being the issue year and manufacturer are the same.

Upon starting and before driving (still parked) steering column started making vibrating, creaking, cracking, screeching noises when adjusting to proper driving position and seems to be beginning to fail. This is worse when the vehicle has been heated by hot summer temps. I have video with audio too. I've attached Ford's TSB 22-2144 and the NHTSA ID# 10210476