2021 FORD EXPLORER Complaints

The drivers side door latch mechanism malfunctions and causes the door to unlatch or does not allow the door to latch. This is a safety hazard. I know two other ford owners with vehicles after 2021 that is having this same issue. This calls for a recall!

Sun roof fabric/covering came off tracks and is now sagging. Many forums on this issue. When driving if windows are down, the fabric flaps in the wind and sounds like it will fly off. I no longer drive with the windows down. If it continues to sag, could obstruct rear view.

LED low beam headlight failures. Our 1st headlight failure occurred in January 2025 at 51,248 miles (Passengers Side), our 2nd failure occurred in December 2025 at 64,356 miles (Drivers Side). My claim is Ford decided to embrace LED technology with out properly performance testing it. LED headlights are new on the explorer platform since 2020, the platinum & ST trims are the only ones that utilizes LED's to my knowledge. The design intent was life of car which clearly is not occurring. Ford should have completed more testing and/or designed a serviceable headlight for all internal components. The cost of these lights is astronomical ($1600 a pop w/o labor or diagnosis fee). As reference we also own a 2006 Audi S4 & a 2012 F150 XLT. The Audi has ~170K miles on it and the F150 has ~130k miles on it. Both have the original headlights and bulbs within them. Both older technology and both still working as intended. The headlights in the 2021 car BOTH failed in terms of the low Beam LED components failing in under 4 years. Seems to be a common issue in over 50% of 6th Generation Platinum trim level explores on the market. Numerous others have experience similar issues. Asking for a recall for these. Again only on Platinum & ST trims so not nearly as many at the average XLT level trims.

I was informed by the dealership that the engine issue with my 2021 Ford Explorer is the same issue for which a recall was issued. However, because my vehicle’s VIN was not included in the recall, I was required to pay for the engine replacement. I attempted to work with the dealership to have them coordinate with the manufacturer, but they declined to do so. I then contacted the manufacturer directly to file a complaint and request a review of the issue. I was advised that there was nothing they could do because my VIN is not listed under the recall. I am requesting that the manufacturer investigate this matter further and reimburse me for the repair costs if it is determined that the issue is applicable to my vehicle.

While applying brakes coming to a stop light, the vehicle gave a message stating service brakes. The brakes still felt normal. Then after a few minutes, the brakes felt like they suddenly stopped working and then the rear tires started locking up and releasing. The frong brakes felt like they were not working at all. Stopping distance approximately tripled and not really any way to adjust braking pressure. Releasing the pedal would give a 2ish second delay before the brakes would reapply upon hitting the pedal again, and withing 1 second would lock up the rear brakes again, starting the cycle over again. Took approximately 3 applications to fully stop in a safe manner. Luckily I was already driving slow due to the warning and was able stop before hitting the car in front. Was driving approximately 30 mph when this happened. Under normal circumstances and driving distances this would have not been possible. The car was taken to the Ford. They determined there was internal failure in the Electronic Brake Booster. The fix was to replace the full assembly (EBB, ABS, etc), and flush the brake fluid. Along with diagnostics of the issue, the cost was $4,100.87 to fix. Since replacing the EBB assembly, the problem has gone away. There were no other indictions of an issue before this happened. I know other Explorer years, and other models that use this same component have been recalled for similar issues as well, and think there is a issue with this module as well.

2024 - 19k miles. Both rear shocks were leaking. Dealer replaced both at no charge. 2025 - 30k rear shock shows signs of leaking. Dealer states no leak. 2025 - 32k Tire shop says shock is leaking. I told them the dealer said it was not. they took pictures. 2025 - Arrive at dealer (2nd time same issue) Dealer states no warranty because I did not pay for replacements. They stated had I payed for replacements I would have a 2 year warranty. Since it's been over a year I have to pay for it. Left dealer called Ford and filed a complaint. Case # XXX-XXX or XXX? Under 40k miles and going on 3 sets of shocks. Online forums readily show this is a known problem that Ford will not acknowledge. Furthermore their warranty of 1 year vs 2 based on payment or warranty replacement should be illegal! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Police car started to run rough at low speed. Stalled in middle of road. Scanned codes and code for Catalytic converter showed up along with misfires from numerous cylinders. Brought to dealer and was told needed plugs and a wire. Vehicle was returned and the same issue occurred. Fixed again. Picked up and once again the same issue started. Turned around and brought it back to dealer. The mechanic stated he never checked the catalytic converter as he was never told it had a code for the converter being bad. Two weeks later I am informed that Cylinder 5 is bad. No compression. Two issues. Ford upped the warranty on the catalytic converters because of this common problem. The tech sheet shows that a bad cat will cause misfires, but never checked. Second issue is the recall 24s55 was for fords with a 3.o liter engine, built in Chicago, between the dates of 7/21 and 10/21. My vehicle was built in Chicago on 9/21 and has a 3.0 liter engine. I also received the post card regarding the recall and we had brought it t o the dealer. 24s55 states the valve could cause engine failure. Well now I have a bad engine. Ford says no recall even though prior Chief brought to dealer after receiving postcard for recall.

Rear differential/axle bolt broke, destroying other parts and making vehicle unsafe at the moment and then inoperable. Vehicle had previously had the recall work done for this exact issue prior to any issues/damage. Dealership is repairing the vehicle under warranty, but made sure to tell us that this is a known issue and the only true way to “fix” the issue is to install an aftermarket brace (at our cost).

When given gas to move from a complete stop, vehicle lost all power. After vehicle lost all power to rear wheels, warning lights flashed on cluster. Manually moved vehicle to side of road and checked under SUV to see rear axle was at a unusual angle and later discovered rear axle bolt on road. Vehicle was towed to dealership, which originally completed recall repair in July of this year, for this known issue. Repairs have been completed after 2 weeks, and was informed by dealership it was roughly 6 thousand in damages.

The fabric from the moonroof has come loose on the sides and blocks rear visibility if open. This is apparently an issue with many vehicles.