2020 FORD EXPLORER Complaints

My new 2020 FORD EXPLORER had had on at least 4 occasions, the last being in July 2021 (mileage was approximately 7,280 miles at the time). This problem has only occurred when parked in my garage, I turn on the Explorer with my foot firmly on the brake and put the vehicle in Reverse (with foot still on brake) the vehicle starts reversing with force even though my foot is hard on the brakes. I then push down even harder on brakes. I am fighting to keep the Explorer from roaring out of the garage. Luckily I haven't hit anyone or anything, but had I not reacted as quickly I could easily have caused serious injury. I reported this problem to my local dealer two times, the first about 10 months ago and the second incident was reported to the dealer when I took it in in August 2021 for numerous alerts received in July 2021 for: POWERTRAIN MALFUNCTION/ REDUCED POWER; PRE-COLLISION ASSIST NOT AVAILABLE; HILL START ASSIST WARNING, PRE-COLLISION ASSIST NOT AVAILABLE. The dealer said all the alerts came from one power module which will be fixed this week when the part arrives at the dealer. The dealer also said that the recent Reverse power surge I advised them of is probably related to all of the alerts listed above and that this should take care of the problem. I never received any warnings, messages or other symptoms of this problem - it has always been a shock when it happens.

I have already complained to dealer about constant hesitation and jerking, going from 1st to 2nd and sometimes 2nd to 3rd gear on automatic transmission, as well as slight loss of power going up inclines under 30mph. They told me a road test and transmission test showed nothing wrong. Incident I am reporting happened back in May2021. I was making a right hand turn onto a busy road from a parking lot, from a complete stop. As I pulled out onto the road, going from 1st to 2nd gear, the car completely stalled for about two seconds. I almost was rear-ended because of the stall. I had to take my foot off the gas and then put a lot of pressure on the gas pedal to get the car moving again.

The contact owns a 2020 Ford Explorer. The contact stated the day he purchased the vehicle, the rearview camera turned blank as he was reversing out of the dealer parking lot. The warning message "Back Up Brake Assist Is Not Functioning" appeared on the instrument panel. The dealer diagnosed that the rear-view camera needed to be replaced. The contact stated that the vehicle was repaired however, the failure recurred while driving. The vehicle was taken back to the dealer and was repaired, however the failure persisted. The vehicle was taken back to the same dealer. The manufacturer was made aware of the failure and informed the contact that the VIN was not included in NHTSA campaign number: 20V575000 (Visibility) due to the manufactured date. A case was opened and the contact was referred to the NHTSA for assistance. The vehicle was not repaired. The approximate failure mileage was 10. Consumer stated 5th camera has been installed.

Vehicle would not start and every warning lamp and alert triggered on the dashboard. Tried remote start which was successful, but vehicle shut off 5 seconds later and the above alerts/warning lamps repeated. Vehicle would not start and just repeated all of the warning lamps/alerts. Waited 20 minutes, car started without issue; however, when put into reverse WITH FOOT ON THE BRAKE the vehicle started to drive backwards WHILE FOOT WAS STILL ON THE BRAKE! No amount of pressure on the brake pedal stopped the vehicle. Had to depress and repress the pedal to stop the vehicle. Rear cameras failed to activate as well. Luckily no one was injured. This is the third time this has happened, the third time I have reported to the NHTSA, and the third time I have reported it to my local dealership without resolve.

The contact owns a 2020 Ford Explorer. The contact stated that upon rapid acceleration at various speeds, exhaust fumes from the tailpipes would enter the cabin of the vehicle. The contact also stated that after heavy rains, water-filled the spare tire compartment located in the rear of the vehicle. One day while his wife was driving and coming to a complete stop, the water spilled out of the compartment and flooded the cabin floor of the vehicle. Once the contact discovered where the water was located, he vacuumed up nearly four gallons of water out of the spare tire compartment. As a result of the internal water intrusion, there were several electrical failures. The forward collision warning light would illuminate on the instrument panel without any vehicles in near proximity. The contact also stated that his wife received multiple alerts on her phone through the Ford app that an intruder had attempted to open the tailgate however, each alert was a false alarm. The contact had taken the vehicle to a dealer where the service manager agreed to have the vehicle thoroughly inspected. The vehicle remained in the possession of the dealer. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 1,000.

The car jerks when it is downshifting between 2nd and 3rd gear. It was inspected by a dealership in TN (we were out of town from MI) and the Ford dealership there was unable to identify the issue as they did not have a transmission tech. We have 15K in miles on our car. We contacted Ford CS and the car was driven by a car hauler back to a dealership in MI. They have 1 transmission person. At this time, we have had a rental car for over 2 weeks at a cost of over $1200. They cannot service the vehicle until next week leaving us without a vehicle for over 3 weeks. Ford has been difficult to work with and meanwhile I continue to pay my lease, they are only offering $35/day for 10 days for rental car and have no idea when the car will be fixed. I have asked for credit on our lease and formal follow up on this and they are slow to reply leaving us stranded to find our own way home. Very disappointed as this seems to be a known issue with the 2020 Explorers and the new power train.

Turned the car on and immediately the headliner above the drivers seat started smoking. Within seconds there was an actual fire and had to call the fire department. Ford does NOT seem concerned about it at all. Are not sending it to be investigated at all from my understanding, My car has sat for 2 months now with no answers still. We do not know what caused the fire or exactly where the fire started.

Rear camera will intermittently cause the screen to display distorted or total blue screen upon placing the vehicle in reverse

On two separate occasions while using the cruise control, the vehicle continued to receive warnings on the dash that the 4-wheel drive, hill assist, emergency braking, etc. were all unabled and service would be required. The cruise control then also disabled and I was unable to use it again until I pulled over, stopped and re-started the vehicle. Upon doing this, the system seemed to reset and all warning lights went off. I contacted a local Ford dealer about this issue and was told that their loaner 2020 Explorer has the same issue and they're unable to pinpoint the problem. They've had it in and out of service for 4 months. Their machine is unable to find any errors. They feel like it may be something to do with the body control module. Since my vehicle is apparently not the only 2020 Explorer experiencing this issue, I thought it would be worth reporting.

Transmission - available for inspection upon request (yes) Vehicle will lunge or stall as it searches for the right gear. Have had the vehicle to Ford Authorized Dealers 3 times with varying degrees of success. Now problem has reoccurred and is worse that ever. Searches for the right gear, lunges, sometimes will not go into gear at all. Feel unsafe driving the vehicle. Currently have a 4th apt with Ford to look at the transmission. No warning lights or messages present on the dash.