1997 FORD EXPLORER SPORT Complaints

I THINK THE REAR DOOR OF FORD EXPLORERS SHOULD BE INVESTIGATED. I HAVE A 1997 FORD EXPLORER XLT. THE WELD THAT HOLDS THE REAR DOOR AT THE TOP IS STARTING TO COME APART. I WAS INFORMED THAT THIS IS AN ENGINEERING DEFECT ON FORD EXPLORERS BY A FORD BODY SHOP. WHY HAS THERE NOT BEEN A RECALL ON THIS ISSUE? I HAVE ALSO SEEN THIS ON SEVERAL OTHER EXPLORERS. I WAS TOLD THAT THIS OCCURS BECAUSE THE SHEET METAL USED ON THE DOOR IS SO THIN THAT IT DOES NOT SUPPORT THE WEIGHT OF THE REAR DOOR THAT GOOD.*JB

THE PROBLEM I'M HAVING INVOLVES A 1997 FORD EXPLORER SPORT (4.0L-5SPD-NON-AUTO CLIMATE CONTROL)--THE TEMP IS NOT CONTROLLABLE AND REMAINS HOT ALL THE TIME EXCEPT FOR MAX A/C--THIS PROBLEM SEEMS TO COMMONLY INVOLVE BUT IS NOT NECCESSARILY LIMITED TO THE BLEND DOOR, BLEND DOOR ACTUATOR AND HEATER BOX--TO MY KNOWLEDGE THERE HAVE BEEN NO DEATHER OR INJURIES CAUSED BY THIS PROBLEM BUT IT IS SIGNIFICANT NON THE LESS . *AK

I PURCHASED A 1 OWNER,USED 1997 FORD EXPLORER IN APRIL 2004.IT HAS 105.000.3 MONTHES LATER,THE TRANSFER CASE WENT.WHEN MY MECHANIC HAD IT ON THE LIFT,HE SAW THAT THE TRANSMISSION HAD ALREADY BEEN REBUILT.NOW 6 MONTHES LATER,THE TRANSFER CASE,WHICH CAME OFF OF A 1997 EXPLORER WITH 60,000 MILES ON IT,IS GOING BAD.I HAVEN'T EVEN PUT 10,000 MILES ON IT SINCE HAVING IT REPLACED IN AUGUST.I SPOKE TO OTHER FORD EXPLORER OWNERS,AND THEY TOO HAVE HAD TO REPAIR,OR REPLACE THE TRANSMISSIONS AND OR TRANSFER CASES MULTIPLE TIMES IN THEIRS.IT IS GETTING EXTREMELY COSTLY TO HAVE THIS PROBLEM FIXED.AS WELL AS THE INCONVENIENCE OF HAVING TO FIND A RIDE WHILE ITS IN FOR SERVICE.IS THIS A FAMILIAR COMPLAINT? I WAS NOT TOLD BY THE DEALER OF ANY TRANSMISSION PROBLEMS,OR THE FACT THAT THE ORIGINAL TRANSMISSION WAS PREVIOUSLY FIXED.IS THERE ANYTHING I CAN DO?PLEASE HELP.*AK

BLEND DOOR CRACKED ON 1997 FORD EXPLORER, CAUSING LACK OF ABILITY TO DEFROST WINDOWS. I LIVE IN WISCONSIN AND THE WINDOWS FOGGED UP BADLY. VERY DIFFICULT TO DRIVE WHEN IT'S 20 BELOW OUT AND THE DEFROSTER DOESN'T WORK. COST TO REPLACE AIR PLENUM WITH REVISED, REDESIGNED ONE ABOUT $900. *AK

I DRIVE A 1997 FORD EXPLORER XLT. THE DRIVER'S SIDE SEAT BELT TODAY BECAME UNLATCHED WHEN I HIT THE BREAKS HARD. THIS IS THE SECOND TIME THAT THIS HAS HAPPENED. HAD I HIT ANOTHER CAR, I WOULD HAVE GONE THROUGH THE WINDSHIELD. FORD WANTS TO CHARGE ME $100 FOR THE REPAIR. *JB

TRANSFER CASE HAD TO BE REPLACED. UPON INVESTIGATION THERE WAS A SAFETY NOTICE FROM FORD, BUT NO RECALL. THE REPAIR SHOP SAID IT WAS THE THIRD EXPLORER THEY HAD FIXED FOR THE SAME PROBLEM IN A WEEK.*AK

I HAD TAKEN MY VEHICLE TO THE DEALERSHIP ON THREE SEPARATE OCCASSIONS DUE TO COOLANT LOSS AND THE TEMPARATURE GUAGE READING COOL. ON EACH OCCASSION THEY REPLACED THE THERMOSTAT. THE LAST TIME WAS JUST PRIOR TO THE EXPIRATION OF THE EXTENDED WARRANTY. I SPECIFICALLY REQUESTED THAT IT BE TESTED AND CHECKED THOUROUGHLY BECASUE I DID NOT WANT TO REPLACE AN ENGINE AFTER THE WARRANTY EXPIRED. THEY REPLACED THE THERMOSTAT. SHORTLY AFTER I EXPERIENCED THE SAME DIFFICULTY. I TOOK THE VEHICLE TO A PRIVATE GARAGE AND THEY REPORTED THAT THE HEAD GASKETS HAD FAILED AND WERE LEAKING. I CONTACTED THE SERVICE MANAGER AT THE DEALERSHIP AND HE REQUESTED THAT I BRING THE VEHICLE TO THEM FOR TESTS. SEVERAL DAYS LATER THE SERVICE DEPARTMENT CALLED AND INFORMED ME THAT THE HEAD GASKETS HAD FAILED AND THAT COOLANT WAS ENTERING THE CYLINDERS. THEY OFFERED TO REPLACE THE ENGINE FOR $4600.00. NOT GOING TO HAPPEN.*AK

ON FEBRUARY 16, 2004 AT APPROXIMATELY 2:30 PM I WAS PULLING MY WIFE'S 1997 FORD EXPLORER SPORT INTO A DIAGONAL PARKING STALL. I HAD ALMOST COME TO A COMPLETE STOP WHEN THE ENGINE BEGAN TO ROAR AND THE CAR BEGAN TO ACCELERATE AGAINST MY BRAKING. I PRESSED AS HARD AS I COULD ON THE BRAKE PEDAL BUT THE CAR CONTINUED TO MOVE FORWARD UNTIL IT STRUCK A CAR OPPOSITE MY PARKING STALL. I PUSHED THE GEAR SHIFT INTO NEUTRAL AND TURNED OFF THE ENGINE. I CHECKED MY RIGHT FOOT POSITION AND CONFIRMED THAT I WAS ONLY PRESSING ON THE BRAKE PEDAL. WHEN I RELEASED THE BRAKE PEDAL THE CAR ROLLED BACK A COUPLE OF FEET. I SHIFTED THE CAR INTO PARK AND RESTARTED THE ENGINE AND BACKED THE CAR UP ANOTHER 3 FEET. THE SUDDEN ACCELERATION HAS NOT RECURRED BUT I AM CONCERNED THAT IT MIGHT AGAIN. *JB

THE HEATING SYSTEM STOPPED OPERATING AND CAUSED POOR VISIBILITY TO THE DRIVER BECAUSE THE WINDSHIELD COULD NOT BE DEFROSTED. AN INDEPENDENT AUTO MECHANIC DETERMINED THAT THE ENTIRE HEATING SYSTEM NEEDED TO BE REPLACED. *NM

I HAVE A 1997 FORD EXPLORER SPORT AND IT IS DOWN FOR THE SECOND TIME WITH A TIMING CHAIN PROBLEM. THE FIRST WAS WHEN I BOUGHT THE USED VEHICLE IN 1999 FROM A CAR LOT IN LYNNWOOD, WA IT HAD 49,000 MILES ON IT AND IT NEED THE TIMING CHAIN ASSEMBLY REPLACED. NOW 4 YEARS LATER IT IS SITTING AT A SHOP NEEDING A SECOND TIMING CHAIN ASSEMBLY REPLACED. IT SEEMS VERY ODD THAT THIS WOULD OCCUR TWICE WITH A VEHICLE IN ITS LIFE TIME. THE VEHICLE ORIGINATED FROM CANADA IN 1996, SO I AM NOT SURE IF IT HAD THE CORRECT MILEAGE WHEN I PURCHASED THIS VEHICLE. THE BILL IS MINIMUM $4500.00 AND THE VEHICLE IS ONLY WORTH LIKE $6000.00 IN WORKING ORDER. VERY DISAPPOINTED IN FORD PRODUCTS, THEY ARE NOT BUILT TO LAST. *CB