1999 FORD F-150 Complaints

DRIVING F 150 ON HIGHWAY, GAS TANK TORPEDOES INTO ASPHALT, LEAKING FUEL, ALMOST REAR ENDED BY A TRACTOR TRAILER. GAS LEAKING, CALLED TOWING COMPANY FOR A FLATBED, COULD NOT BE TOWED BECAUSE LEAKING FUEL. RUSTED STRAPS. TOWING COMPANY SAID, THIS WAS THEIR FIFTH F 150 IN TWO WEEKS WITH FAULTY STRAPS. *TT

THE ODOMETER IN MY 1999 FORD F150 PICKUP DOES NOT LIGHT UP WHEN THE IGNITION IS TURNED ON UNTIL IT HAS BEEN DRIVEN FOR A WHILE. IT DOES EVENTUALLY COME ON BUT HAS TAKEN LONGER AND LONGER AS THE VEHICLE HAS AGED. THIS HAS BEEN A PROBLEM FOR MORE THAN 2 YEARS AND SEEMS TO BE GETTING WORSE. *TT

TL* THE CONTACT OWNS A 1999 FORD F150. WHILE DRIVING 70 MPH, THE CONTACT STATED THAT BOTH STRAPS FRACTURED CAUSING THE FUEL TANK TO HANG FROM UNDERNEATH THE VEHICLE. THE VEHICLE WAS TOWED TO THE DEALER AND IT WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 112,000.

THE ENGINE SURGES OR QUITS AS I AM DRIVING. THIS HAPPENS EVERY 8 TO 10 MILES. I CAN BE GOING 75 MPH ON THE FREEWAY WHEN IT QUITS AND I HAVE TO SHUT OFF THE IGNITION TO RESTART IT. THIS IS AT LEAST THE NINTH TIME THIS TRUCK HAS DONE THIS SINCE IT WAS NEW. I THINK YOU CAN IMAGINE WHAT IT'S LIKE TO BE GOING 75 MILES PER HOUR AND YOUR ENGINE QUITS AND YOU ARE LEFT WITH NO POWER STEERING, OR BRAKES. THIS WILL BE THE NINTH COIL I HAVE REPLACED ON THIS MOTOR. FORD IS COMPLETELY AWARE THAT THERE HAS BEEN A PROBLEM FOR YEARS WITH THIS SIZE MOTOR. I CAN'T BELIEVE AN ENGINE THAT SHUTS OFF AT 75 MILES PER HOUR HAS NOT BEEN CONSIDERED A SAFETY CONCERN BEFORE. *TR

TL* THE CONTACT OWNS A 1999 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 20 MPH HE HEARD A LOUD DRAGGING NOISE. THE VEHICLE WAS PULLED OVER TO THE SIDE OF THE ROAD AND THE CONTACT NOTICED THAT THE FUEL TANK WAS HALF WAY DETACHED FROM THE VEHICLE. ONE OF THE STRAPS WHICH HELD THE FUEL TANK IN PLACE WAS FRACTURED AND THE OTHER WAS SEVERELY RUSTED. NO FUEL LEAKED FROM THE TANK. THE MANUFACTURER WAS NOTIFIED AND THEY STATED THAT THERE WERE NO RECALLS RELATED TO THE FAILURE. THE OWNER PURCHASED NEW STRAPS FROM AN INDEPENDENT MECHANIC AND REPAIRED THE VEHICLE HIMSELF. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 200,000. THE VIN WAS UNAVAILABLE.

MY DAUGHTER WAS DRIVING MY 1999 FORD F150 TRUCK (APPROX. 145,000 ODOMETER MILES) AT 35 MPH WHEN ONE (PROBABLY THE FRONT), OR BOTH, GAS TANK STRAPS BROKE. SHE DRAGGED THE TANK ABOUT 300 YARDS BEFORE STOPPING. BOTH STRAPS WERE BROKEN BY THAT TIME AND THE TANK WAS ON THE GROUND WITH A DEEP DENT THE SIZE OF A BASEBALL AND THE METAL SCRAPED CLEAN IN THE FRONT RIGHT BOTTOM CORNER OF THE TANK. IN ATTEMPTING TO STRAP UP THE TANK, THE DAMAGED PORTION WAS SCRAPED ON THE GROUND, WHICH OPENED A SEAM UP AND FUEL BEGAN LEAKING. I HAD TO UNBOLT AND TAKE OUT THE FUEL PUMP BECAUSE I COULDN'T FIGURE OUT HOW TO DISCONNECT THE FUEL LINE FITTINGS. THE FUEL INTAKE HOSE WAS SNAPPED OFF. I HAD TO CLIP/CUT THE FUEL SENSOR WIRES BECAUSE I COULDN'T UNLATCH THE SENSOR WIRES. ANOTHER SMALL HOSE CAME OFF (FUEL OVERFLOW HOSE?) EASILY. I WAS THEN ABLE TO PULL THE TANK OUT FROM UNDER THE TRUCK AND DRAIN THE LEAKING GASOLINE INTO A GAS CAN AND HAVE THE TRUCK TOWED. A USED TANK WAS FOUND WITH THE ORIGINAL FUEL PUMP IN IT TO REPLACE THE DAMAGED TANK AND A NEW GAS GAUGE SENSOR ATTACHED. *KB

ON 7/16/11 THE GAS TANK STRAPS BROKE AND DROPPED THE GAS TANK ON THE GROUND WHILE I WAS DRIVING TO THE STORE AT ABOUT 35 MPH. I PAID $94.00 TOWING FEE, $242.03 TO REPLACE THE STRAPS ETC. FORTUNATELY THE TANK DID NOT BREAK OPEN, OR GET RIPPED FROM THE VEHICLE CAUSING A FIRE OR SPILL TWO WEEKS PRIOR I PAID OVER $300.00 TO GET THE BOLTS REMOVED FOR THE STARTER AS THEY HAS CORRODED IN PLACE - STEEL BOLTS INTO AN ALUMINUM TRANSMISSION - GENIUS! *KB

TL* THE CONTACT OWNS A 1999 F-150. THE CONTACT STATED THAT THE FUEL STRAPS WHICH HELD THE FUEL TANK IN PLACE FRACTURED, ALLOWING THE FUEL TANK TO DETACH FROM THE VEHICLE AND FALL ONTO THE GROUND. AS A RESULT, FUEL SPILLED OUT FROM THE FUEL TANK. THE DEALER AND MANUFACTURER WERE MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE FAILURE AND CURRENT MILEAGES WERE 115,000.

TL * THE CONTACT OWNS A 1999 FORD F-150. THE CONTACT WAS DRIVING 55 MPH WHEN THE FUEL TANK STRAPS FRACTURED DUE TO CORROSION. AS A RESULT, THE FUEL TANK DETACHED FROM THE VEHICLE. THE CONTACT MENTIONED THAT NO FUEL SPILLED AND BOTH OF THE STRAPS WERE FRACTURED. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP WHERE THE FAILURE WAS CONFIRMED AND THE CONTACT WAS ADVISED TO HAVE THE FUEL TANK STRAPS REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 175,000. UPDATED 09/02/11*LJ UPDATED 09/14/11

I PURCHASED MY 1999 FORD F-150 4X 4 WITH A TRITON 5.4 V-8 ENGINE USED. THE ENGINE HAD APPROXIMATELY 140,000 WHEN I PURCHASED IT. I ONLY DRIVE IT TO AND FROM WORK IN LAS VEGAS, NV (APPROXIMATELY 25 MILES ROUND TRIP) AT SPEEDS BELOW 50 MPH. THE ENGINE BLEW THE BACK PLUG AT 163,000. BECAUSE IT WAS THE BACK PLUG THE LABOR TO REPAIR WAS HIGH (PULL THE ENGINE). THE DIFFERENCE IN PUTTING HELICOILS (ALL EIGHT PLUGS) IN AND A NEW ENGINE WAS NOT THAT MUCH DIFFERENCE SO I ORDER A LONG BLOCK FULL ENGINE FROM FORD WITH STIPULATIONS IT CORRECTED THE DESIGN FLAW. THE ENGINE COST ALMOST $7000 WHEN ALL WAS DONE AND COMPLETE. FORD WARRANTY THE ENGINE 3 YEARS AND 75,000 MILES. I FIGURED THIS CORRECTED THE ISSUES WITH THE SPARK PLUGS BLOWING OUT. WELL AT THE 4 YEAR POINT AND APPROXIMATE 25,000 MILES THE NEW ENGINE BLEW A PLUG. FORD AND THE DEALER (WHOM WE PURCHASED THE ENGINE FROM) SAY IT IS OUR PROBLEM. THE DEALER (PARTS MANAGER) ACTUALLY SAID SINCE I WAS NOT A FREQUENT CUSTOMER AND HAD PURCHASED THE TRUCK USED THEY DID NOT SEE A WAY TO HELP. I HAVE RESEARCHED THIS ISSUE ON THE INTERNET AND BELIEVE IT IS DESIGN FLAW IN THE HEAD. I AM IN THE PROCESS OF HAVING STEEL INSERTS PUT IN ALL OF THE SPARK PLUG HOLES SO I MIGHT GET USE OUT OF A HEFTY INVESTMENT IN A MOTOR WITH A KNOWN ISSUE WHICH FORD WILL NOT BACK. I OWN A FORD CROWN VICTORY, A MERCURY MARQUIS LS, AND THE F-150 TRUCK . . . THESE ARE THE LAST VEHICLES I WILL OWN FROM FORD. *TR