2004 FORD F-150 Complaints

MY TRUCK GETS UP TO ABOUT 50 MPH THEN ACTS LIKE IT GOES INTO NEUTRAL , NO POWER TO THE BACK WHEELS. I'VE NOTICED THAT MORE THAN A FEW 2004 F-150 OWNERS HAVE THE SAME COMPLAINT. HAS ANY INVESTIGATION BEEN DONE AND IF SO WHAT WERE THE FINDINGS. I LIVE ON DISABILITY SOCIAL SECURITY AND CAN'T AFFORD TO HAVE A TRANSMISSION REPAIRED.I WAS ON A PAVED ROAD AT THE TIME. *TR

TL* THE CONTACT OWNS A 2004 FORD F-150. THE CONTACT NOTICED RUST ON THE REAR AXLE HOUSING. THE DEALER DIAGNOSED THAT THE AXLE WAS NEARLY RUSTED ALL THE WAY THROUGH AND THAT THE VEHICLE WAS UNSAFE TO DRIVE. THE VIN WAS EXCLUDED FROM NHTSA CAMPAIGN NUMBER: 15V608000 (SUSPENSION). THE MANUFACTURER WAS NOTIFIED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 76,000.

TAKATA RECALL : TRUCK IS SLIPPING IN FORWARD GEARS AND THE REVERSE WILL NOT MOVE EVEN IF U YOU REV IT UP IT'S LIKE IT'S IN NEUTRAL. ALL THIS HAPPENED WHEN I WAS LEAVING WORK TO GO HOME

LOUD RATTLING/VIBRATION THROUGHOUT THE TRUCK, CAUSING TIRES AT TIMES TO BOUNCE AND SLIP. OPENED DIFFERENTIAL AND CARRIER HAS MALFUNCTION.

HOOD PAINT AND ROOF PAINT PEELING UP FOR THE LAST 7 YEARS. IT STARTED WITH SMALL BLISTERING AND WHAT APPEARED TO BE JUST A FEW KNICKS ON THE HOOD. HOWEVER IT QUICKLY SPREAD AND THE ENTIRE HOOD AS WELL AS ROOF ARE IN NEED OF A PAINT JOB DUE TO RUST. I AM THE ORIGINAL OWNER AND HAVE APPS 129000 MILES ON IT.

UNKNOWN. MAJOR POPPING IN REAR END WHILE TURNING. WHEN TRUCK IS IN PARK I CAN ROLL IT BACK AND FORTH A GOOD 10 INCHES IN BOTH DIRECTIONS.

I WAS DRIVING DOWN THE ROAD WHEN MY LEFT REAR WINDOW WENT CRASHING DOWN INSIDE THE DOOR. AFTER DOING A LOT OF SEARCHING ON THE NET I FOUND THIS IS HAPPENING A LOT ON A NUMBER OF THE FORD F-150 TRUCKS, A CHEAP PLASTIC PART FAILS AND THE WINDOW FALLS DOWN. NO WARNING THE WINDOW JUST FALLS DOWN IN THE DOOR

THE FRAME UNDER MY F150 IS RUSTED THROUGH. I ONLY HAVE 81K MILES ON IT AND I DON'T UNDERSTAND WHY THE FRAME IS RUSTING SO BADLY. IT HAS ALREADY COST ME 2,400 TO HAVE A CERTIFIED WELDER REPLACE SOME OF THE SECTIONS THAT WERE RUSTED OUT. I KNOW JUST FOUND ANOTHER PART OF THE FRAME THAT IS RUSTED UNDER THE LEAF SPRING. THAT IS NOW GOING TO COST ME ANOTHER $500.00.

I WAS PULLING A TRAILER OVER THE CONTINENTAL DIVIDE WITH MY FAMILY AND STOPPED TO GET GAS IN LEADVILLE, COLORADO. AS I WAS PUMPING GAS I SAW SMOKE COMING FROM UNDER MY TRUCK BED. I LOOKED UNDER THE TRUCK AND SAW FLAMES NEAR MY SPARE TIRE. I STOPPED PUMPING GAS AND RAN TO GET A FIRE EXTINGUISHER. AFTER THE FIRE WAS OUT I OBSERVED THAT MY TAIL-PIPE HAD BROKEN AWAY FROM MY MUFFLER. THE HEAT FROM MY EXHAUST HAD MELTED THE RUBBER COATING ON MY REAR RIGHT BRAKE CABLE. THE HEAT HAD ALSO MELTED SOME PLASTIC NEAR MY SPARE TIRE. THE MECHANIC IN LEADVILLE WHO WELDED MY TAIL PIPE BACK TO THE MUFFLER TOLD ME THE MELTED PLASTIC CAME FROM AN EVAPORATIVE FUEL EMISSIONS SYSTEM MOUNTED NEAR MY SPARE TIRE. (BAD PLACE TO PUT IT IF YOU ASK ME) MY TRUCK BED-LINER ALSO STARTED TO MELT FROM THE HEAT. I CALLED FORD TO NOTIFY THEM OF THE SAFETY PROBLEM AND THEY ONLY RECOMMENDED THAT I TAKE IT TO A FORD DEALER AND HAVE IT LOOKED AT. I DOUBT I WILL EVER HEAR FROM THEM AGAIN. I'M NOT GOING TO PAY OUT OF MY POCKET TO HAVE THIS PROBLEM OFFICIALLY DIAGNOSED. I GUESS I'M JUST LUCKY TO BE ALIVE AND THAT THE WHOLE GAS STATION DIDN'T BLOW UP.

VIBRATION AT 45 TO 55. WHEN COLD STRONG JERK IN REAR END AREA AND SOMETIMES ON TURN TO RIGHT. ALSO COMES IN AT TIMES WHEN GOING TO PASSING GEAR. IT IS A DIFFERENTIAL ISSUE MORE THAN A DRIVE SHAFT ISSUE. ALL U JOINTS ARE TIGHT. NO IMBALANCE IN DRIVE SHAFT. HAVE GONE TO SPECIAL TEFLON GEAR OIL... THIS APPEARS TO BE DESIGN AND POSSIBLE SAFETY ISSUE.