2006 FORD F-150 Complaints

IN JUNE 2015, THE AIR BAG LIGHT IN MY FORD F150 ILLUMINATED, INDICATING A PROBLEM. I TOOK MY VEHICLE TO A FORD DEALERSHIP. THEY TOLD ME THAT THE DEPLOYABLE RESTRAINT SYSTEM, SPECIFICALLY THE PRETENSIONER, HAD MALFUNCTIONED AND POSSIBLY WOULD FAIL TO FUNCTION AS INTENDED IN THE EVENT OF A CRASH. THE SERVICE TECHNICIAN INDICATED THAT THE RESTRAINT SYSTEM IS CONNECTED TO MY AIR BAGS, WHICH MIGHT FAIL TO WORK IN A CRASH, INCREASING THE RISK OF INJURY. AFTER PAYING THE DIAGNOSTIC FEE, I WAS GIVEN A REPAIR ESTIMATE OF AN ADDITIONAL $392.21. NOT WANTING TO RISK INJURY IN THE EVENT OF A CRASH, I HAD THE PRETENSIONER REPLACED. THE BUCKLE PRETENSIONER IS A CRITICAL SAFETY DEVICE THAT SHOULD NEVER FAIL UNDER NORMAL USE. MY VEHICLE HAS NEVER BEEN IN AN ACCIDENT. IT IS MY UNDERSTANDING THAT SOME PRETENSIONERS HAVE FAILED DUE TO SIMPLE SEAT POSITION ADJUSTMENTS, WHICH, TO ME, IS EVIDENCE OF A POOR DESIGN. FORD HAS RECENTLY RECALLED MANY 2013 ' 2014 VEHICLES FOR POORLY MADE PRETENSIONERS, RECOGNIZING THE SAFETY ISSUE SURROUNDING THEM. I REQUESTED THAT FORD REIMBURSE ME FOR THE COST OF THE PRETENSIONER BUCKLE; HOWEVER, FORD DENIED THIS REQUEST. I HAVE THE ORIGINAL PRETENSIONER AND ALL RECEIPTS AVAILABLE.

MORNING OF JULY 23,2015, I WAS DRIVING ABOUT 25 MPR SPEED WHEN NUMBER THREE SPARK PLUG BLOW OUT OF THE CYLANDERHEAD ON MY F-150 TRITON V8. TOOK IT TO THE LOCAL MACHANIC SHOP WALTON'S. THREE HOURS LATER, WALTON'S HAD TO REPLACE AND RESLEEVE NUMBER THREE CYLANDERHEAD AND REPLACED ELECTRICAL SPARKPLUG WIRE, PLUS REPLACED ALL EIGHT SPARK PLUGS. ALL AT A COST OF $543.00. NOT ONLY THIS HAPPENED TO ME BUT WALTON'S STATED THAT I WAS THE 10TH PERSON THIS WEEK THIS HAS HAPPENED TOO. I PRESENTED THE PART TO MY LOCAL FORD DEALERSHIP WHERE WE BOUGHT THE TRUCK (HALL'S FORD MOTOR COMPANY) BRAND NEW IN 2006 AND PAID CASH TO THE SUM OF $30,000.00. I ASKED THEM IF THEY KNOW OF THIS PROBLEM WITH TRITON V8'S. THEY STATED THEY DID BUT NO KNOW RECALLS AND THEY TOO HAD SEVERAL REPAIRS COME IN FOR THE SAME THING IN THE PASS WEEK. THEY ALSO STATED THAT THE FORD MOTOR COMPANY WAS AWARE OF THIS MATTER BUT NEVER LET THERE CUSTOMERS KNOW ABOUT THIS PROBLEM YET BECAUSE THERE WAS NO RECALL ON FILE TO LET THEM KNOW. THIS THING WHERE THE SPARK PLUGS COME FLYING OUT OF AN ENGINE CAN BE VERY HAZARDS, IT COULD CAUSE A CRASH OR EVEN GIVE A PERSON A HEART ATTACK BECAUSE THE TRUCK SOUNDS LIKE WORLD WAR III GOING OFF UNDER THE HOOD AND IT MAY EVEN START A FIRE. THIS MATTER NEEDS TO BE TAKEN CARE OF BY FORD.

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR ROUTINE MAINTENANCE. WHILE AT THE INDEPENDENT MECHANIC, THE CONTACT WAS NOTIFIED THAT SEVEN OF THE EIGHT SPARK PLUGS IN THE VEHICLE WERE FRACTURED AND NEEDED TO BE REPLACED. THE CONTACT STATED THAT ONE OF THE FRACTURED SPARK PLUGS REMAINED IN THE CYLINDER HEAD. THE MECHANIC STATED THAT THE CYLINDER HEAD HAD TO BE REMOVED FROM THE ENGINE TO REMOVE THE FRACTURED SPARK PLUG. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE; HOWEVER, THE CONTACT WAS NOT OFFERED A REMEDY FOR THE FAILURE. THE FAILURE MILEAGE WAS 84,000.

TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE DRIVING AT 20 MPH, THE BRAKES AUTO ENGAGED WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 80,000. UPDATED 09/03/15*LJ UPDATED 10/26/2017*CN

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT THE STEERING WHEEL BECAME TIGHT AND LOOSENED UP AT RANDOM TIMES WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE DRIVESHAFT WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 160,000.

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT WAS UNABLE TO SHIFT THE GEAR INTO DRIVE OR REVERSE, ONLY NEUTRAL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE CLUTCHES AND BANDS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 28,854. UPDATED 7/16/15*CN THE CONSUMER STATED THE TAIL SHAFT HOUSING HAD A HAIRLINE FRACTURE/CRACK WITH. THE REPAIRMAN BELIEVED THE PART WAS DEFECTIVE. THERE WAS NO WEAR ON THE INSIDE OF THE TRANSMISSION, BEARING OR SEALS. UPDATED 08/04/15*JB

WHILE IN PASSING LANE OF THREE LANE WEST BOUND ROUTE 3 ENGINE SHUT DOWN, HAD TO NEGOTIATE TWO LANES OF HIGHWAY TRAFFIC TO GET TO SHOULDER WHILE COASTING. VEHICLE TOWED TO REPAIR SHOP. FUEL PUMP CONTROL MODULE FAILURE. MODULE CORRODED, HOLES THRU BACK OF MODULE WHERE IT MOUNTS TO FRAME. *TR

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 10 MPH, THE DRIVE SHAFT SEPARATED FROM THE VEHICLE. THE CONTACT WHO WAS A CERTIFIED MECHANIC REPAIRED THE REAR AXLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 106,000.

2006 F-150 LOST ALL POWER FUNCTION WHILE TRAVELING DOWN THE INTERSTATE. I LOST POWER STEERING AND BRAKES. THE CAUSE IS A CORROSIVE FUEL PUMP CONTROL MODULE. AFTER TAKING WITH MY LOCAL FORD DEALER I WAS MADE AWARE THAT THIS IS MAJOR SAFETY ISSUE AND ONE THAT FMC REFUSES TO RECOGNIZE. THIS INCIDENT COULD HAVE RESULTED IN A MAJOR ACCIDENT. I WAS LUCKY ENOUGH TO BE ABLE TO SIGNAL TO THE CARS AROUND ME THAT I WAS HAVING TROUBLE - HOWEVER I WAS STILL ALMOST REAR ENDED TWICE BEFORE BEING ABLE TO PULL OFF TO THE SIDE OF THE ROAD. *TR

THE ENGINE BUCKS,MISSES AND DOESN'T COME UP TO SPEED. THERE IS NO ADVANCED WARNING AS WHEN THIS WILL HAPPEN, THUS MAKING PULLING OUT INTO TRAFFIC A HAZARD! THE GARAGE WHERE I HAD THE PROBLEM FIXED WAS SURPRISED TO HEAR MY DESCRIPTION OF MY TROUBLE. THEY HAD A F150 IN THE WEEK BEFORE WITH THE SAME ISSUE!! THIS GENTLEMAN'S TRUCK ACTUALLY SHUT OFF IN TRAFFIC,SO I CONSIDER MYSELF LUCKY! *TR