2015 FORD F-150 Complaints

My electronic shift on the Fly four wheel system keep dropping in gear while I'm operating the vehicle and it's dragging my back tires this is happening without me operating it

"My 2015 Ford F-150 is experiencing an intermittent, complete loss of the Output Shaft Speed (OSS) signal within the 6R80 transmission lead frame. While driving at speed, the speedometer suddenly drops to zero, the 'wrench' light illuminates, and the vehicle performs an unintended, harsh downshift into a lower gear (Limp Mode/3rd gear). This creates an immediate safety hazard of rear-wheel lockup or a sudden loss of acceleration in traffic. i took my vehicle to a local repair shop where they could not duplicate the fault. i then called my local ford dealer who informed me unless it would duplicate the fault or show a code they could not repair the vehicle due to it being against warranty policy.

Vehicle unexpectedly down shifting while driving causing vechile to jerk. After parking truck, truck presents a no start condition and unlit gear selector lights. While driving truck will go in and out of limp mode. I have scheduled a appointment to bring the truck in for a diagnostic test 03/31/2026.

Noticeably rough transitions between gears, particularly in the 3-4 and 4-5 shift ranges. sometimes a jerking sensation before shifting gears, not consistent. took vehicle to transmission shop. they found nothing mechanically wrong with transmission.

Door Latches freeze in cold temps and prevent my doors from latching closed. I held an extended warranty on my vehicle and reported to my local dealership, but they would not repair since I could not replicate the issue after the fact. The newer models of my vehicle have this listed as a recall item, but they fail to recognize that the same thing is happening to my vehicle.

Lead frame failure in transmission. Causing vehicle to be inoperable and towed to dealer. Very expensive repair. Contacted Ford directly due to large reports online of failure and previous years being covered. Ford declined to do anything.

Transmission slipping and bangs into and out of gears downshifts without doing anything when transmission services there was lots of metal fragments on the magnet2 no change and after having transmission reprogrammed no change

The contact owns a 2015 Ford F-150. The contact stated that while driving at 30 MPH, the transmission unexpectedly downshifted to first gear. The contact stated that occasionally the transmission unexpectedly upshifted to 3rd gear and seized. The contact stated that the failure was intermittent but became a recurring failure. The contact stated that the WRENCH symbol was intermittently illuminated. The contact had taken the vehicle to an independent mechanic, who diagnosed the vehicle and determined that the molded leadframe on the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 131,000.

While driving on the highway at approximately 70 mph, the vehicle unexpectedly downshifted without any prior warning or indication of an issue. This sudden loss of speed created a hazardous situation, as the vehicle travelling behind me was forced to swerve quickly to avoid a rear-end collision. Immediately following this, the check engine light illuminated. From that point forward, the transmission would not shift below 3rd gear for the remainder of my commute. This significantly impacted the drivability of the vehicle and made continued driving concerning, particularly in traffic conditions. After arriving at my work, I retrieved the diagnostic trouble code, which was identified as P0721 (Output Shaft Speed Sensor). Notably, there were no prior warning signs, drivability issues, or alerts indicating a potentail failure before this incident occurred. Given the sudden and unpredictable nature of this event, especially at highway speeds, I am concerned about the safety implications of this issue. A failure of this kind, without warning, creates a substantial risk not only to the driver but also to surrounding traffic.

Wipers failed to operate normally while driving. Wiper started moving very slow then stopped moving even with wet windshield. Upon research the problem was a seized passenger side pivot in the wiper linkage that required replacement of the Wiper Linkage assembly. No warning or noticeable problems until this occurred and vehicle was difficult to operate in rainy conditions.