2006 FORD F-150 Complaints

FORD'S IWE SOLENOID HAS A TENDENCY TO MALFUNCTION DUE TO A POOR DESIGN. TSB 06-8-15 WAS ISSUED TO REPLACE THESE SOLENOIDS, BUT ONLY IF THERE WAS A PROBLEM AND ONLY IF IT WAS GIVING A PROBLEM. MY VEHICLE WAS IN STORAGE FOR 5 YEARS AND AFTER IT WAS BROUGHT OUT AND TO NY, THE WATER LEAKED ON THE SOLENOID DUE TO THE INADEQUATE DESIGN, CAUSING THE IWE'S TO MALFUNCTION. I STILL DON'T KNOW WHAT EXACTLY IT DID BUT DRIVING THE CAR DOWN THE ROAD, IT CAUSED ME TO FEEL LIKE I WAS DRIVING OVER SMALL SPEED BUMPS WITH THE FRONT DRIVERS SIDE TIRE. I'M AFRAID THAT IF THIS FAILED AT A HIGH RATE OF SPEED IT COULD CAUSE THE IWE TO ENGAGE AND POSSIBLY LOCK UP ONE OF THE FRONT TIRES. *TR

VEHICLE STARTED LOSING POWER AND UNABLE TO RUN CORRECTLY. TOOK TO GARAGE AND FUEL PUMP DRIVE MODULE WAS RUSTED WITH CIRCUITS BEING EXPOSED TO THE SALT AND MOISTURE ELEMENTS WHERE THERE WAS A LARGE HOLE IN BACK OF UNIT. NEW ONE WAS INSTALLED WITH SPACERS TO HELP PREVENT SALT AND MOISTURE FROM COLLECTING WHERE BACK OF MODULE MOUNTS ONTO AXLE BRACKET. VEHICLE RAN BETTER BUT ALSO HAD TO INSTALL NEW COIL DUE TO A CYLINDER MISSING. RUNS OK WITH WORK THAT WAS PERFORMED. MODULE SHOULD NOT HAVE BEEN INSTALLED AGAINST THE BRACKET SO SALT AND MOISTURE COULD COLLECT AND RUST IT SO BADLY AND CAUSE IT TO FAIL. FORD SHOULD PAY FOR THIS REPAIR DUE TO THE WAY IN WHICH THE MODULE WAS INSTALLED SO IT WOULD RUST SO BADLY. *TR

TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE DRIVING APPROXIMATELY 45 MPH, THE VEHICLE FAILED TO ACCELERATE AND THE SERVICE VEHICLE WARNING INDICATOR ILLUMINATED CONTINUOUSLY. THE VEHICLE WAS TAKEN TO A DEALER. THE TECHNICIAN DIAGNOSED THAT A SENSOR WAS FAULTY. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 89,069. UPDATED 04/10/15*LJ UPDATED 11/5/2015*JS

NOTICED STEERING WHEEL VERY HARD TO TURN. CHECKED POWER STEERING FLUID WHICH WAS OK. RESEARCHED PROBLEM ONLINE AND FOUND DOZENS OF SIMILAR COMPLAINTS REPORTED ON FORD CUSTOMER FORUMS AND ELSEWHERE ONLINE MENTIONING THAT THE U-JOINT(S) ON THE LOWER STEERING SHAFT POSSIBLY RUST AND CORRODE AND BECOME VERY STIFF. WHEN TURNING CORNERS WHEEL DOES NOT READILY RECENTER ITSELF. FEARFUL THAT STEERING JOINTS COULD FAIL, SEIZE OR BREAK RESULTING IN A COMPLETE LOSS OF STEERING AND SERIOUS INJURY OR DEATH. SAW THAT FORD REDESIGNED THE STEERING SHAFT AFTER 2006 AND THE NEW FORD PART LOOKS MUCH DIFFERENT THAN THE ORIGINAL SHAFT IN MY 2006 TRUCK. SPRAYED SOME PENETRATING OIL ON BOTH U-JOINTS YESTERDAY AND STEERING WAS NOTICEABLY MUCH EASIER WITHIN 5 MINUTES. THEN SPRAYED SOME LIQUID WRENCH LUBRICATING OIL (LIGHTWEIGHT AEROSOL OIL) ON BOTH JOINTS AND DROVE THE TRUCK. STEERING WAS LIKE NEW AND STEERING WHEEL EASY TO TURN. DO NOT KNOW HOWEVER IF THIS "OILING FIX" WILL LAST. FORD IS AWARE OF THIS ISSUE AS THEY REDESIGNED THE STEERING SHAFT/U-JOINTS AND HAD HUNDREDS OF COMPLAINTS. DEFECT IN DESIGN OF CRITICAL STEERING COMPONENT, FORD IS AWARE AND REDESIGNED STEERING SHAFT AND U-JOINTS. NOTE: OTHER CUSTOMERS WITH NON-FORD VEHICLES AND FORD VEHICLES OTHER THAN THE F-150 HAVE REPORTED NUMEROUS SIMILAR COMPLAINTS. *TR

TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE DRIVING APPROXIMATELY 25 MPH, THE TRANSMISSION CHANGED FROM TWO WHEEL DRIVE TO FOUR WHEEL DRIVE INDEPENDENTLY. THE FAILURE RECURRED MULTIPLE TIMES. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 72,000. UPDATED 3/4/15*CN THE CONSUMER STATED THE CAUSE OF THE FAILURE WAS A FAULTY SOLENOID. UPDATED 10/15/2015 *JS

THE ENGINE BEGAN TO TICK ON TOP. LATER IT BEGAN TO TICK ON THE BOTTOM. THE ENGINE LIGHT CAME ON AND I HAD IT CHECKED. THE CODE SAID IT WAS A CAM SENSOR. AS IT TURNED OUT THE ENGINE WAS NOT GETTING THE PROPER AMOUNT OF OIL DUE TO A CLOGGED A OIL PORT RESTRICTION. END RESULT HAD TO REPLACE THE ENGINE. WHILE AT THE SERVICE CENTER ANOTHER TRUCK CAME IN WITH THE SAME PROBLEM WITH SIMILAR MILEAGE. NOW MY SON WHO HAS A 2005 FORD F150 IS EXPERIENCING THE SAME ISSUES WITH HIS TRUCK WITH 96000 MILES THAT'S THREE THAT I KNOW OF. *TR

THE SEAT GETS WHOLE BECAUSE OF MEDAL BAR AND NOT ENOUGH CUSHION ON THE SIDE OF IT SO CAUSES IT HOLES. *TR

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING AT 60 MPH, THE VEHICLE STALLED. THE VEHICLE RESTARTED BUT THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN DIAGNOSED THAT THE FUEL PUMP CONTROL MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 87,000. THE VIN WAS UNAVAILABLE.

VEHICLE SUDDENLY STALLED WHILE DRIVING. WAS ABLE TO COAST TO A STOP AND PULLED OVER, BUT WAS STUCK IN A BUSY INTERSECTION FOR 15-20 MINUTES BEFORE THE TRUCK WOULD RESTART. WAS ABLE TO MAKE IT TO A PARKING LOT BEFORE IT STALLED AGAIN. TOWED TO A DEALERSHIP WAS INFORMED IT WAS A CORRODED FUEL CONTROL MODULE. DOING A LITTLE RESEARCH CONFIRMED THIS IS A VERY COMMON PROBLEM AND SHOULD BE ADDRESSED AS A POTENTIALLY DANGEROUS SITUATION COULD EASILY OCCUR. *TR

WHILE DRIVING THE FORD 2006 F150 IT JUST STARTED RUNNING SLUGGISH AND STOPPED. I WAS ABLE TO GET OFF THE SIDE OF THE ROAD. *TR