2004 FORD F-150 Complaints

TL* THE CONTACT OWNS A 2004 FORD F-150. WHILE THE VEHICLE WAS PARKED, A STRONG ODOR OF FUEL WAS NOTICED AROUND THE VEHICLE. THE CONTACT NOTICED FUEL LEAKING ONTO THE GROUND. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 04V443000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 90,000.

BOTH REAR SUICIDE DOORS WILL NOT OPEN, THE LATCH MECHANISM IS BROKEN AND APPARENTLY COST OVER $700.00 TO FIX BOTH. IN ADDITION I HAVE REPLACED THE WHEEL BEARING ON ALL WHEELS TWICE AND NOW ANOTHER ONE IS GOING BAD. IT SEEMS LIKE I NEVER HAVE A PERIOD WHEN ALL THE BEARINGS ARE GOOD.

THE FRAME OF MY 2004 F150 IS ALMOST COMPLETELY ROTTEN FROM THE FRONT OF THE LEAF SPRING ALL THE WAY UP TO THE DRIVERS DOOR. THE BED SUPPORTS ARE ALSO ROTTED COMPLETELY OFF MAKING THE BED UNSAFE AND UNABLE TO USE.

TL* THE CONTACT OWNS A 2004 FORD F-150. WHILE THE VEHICLE WAS PARKED, THE BRAKE LINES FRACTURED MORE THAN TWICE. THE CONTACT MENTIONED THAT THE BRAKE LINES HAD EXTENSIVE RUST AND CORROSION. THE CONTACT STATED THAT THE REAR DRIVER SIDE BRAKE LINE FRACTURED ON THE FIRST OCCASION. ON THE SECOND OCCASION, THE REAR PASSENGER SIDE BRAKE LINE FRACTURED. THE PARTS WERE REPLACED, BUT THE FAILURE RECURRED WITH BOTH REAR BRAKE LINES. THE VIN WAS NOT AVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 40,000.

WITHIN A FEW WEEKS OF PURCHASING MY VEHICLE IN FEBRUARY AFTER PULLING INTO A PARKING LOT THE CHECK ENGINE LIGHT CAME ON. I ALSO NOTICED IT WAS MAKING A TICKING NOISE LIKE A DIESEL ENGINE BUT IT'S NOT A DIESEL. I WENT TO GET THE CODES AND FOUND IT WAS A RETARDED VARIABLE VALVE TIMING ISSUE CODE P0022. I LOOKED ONLINE AND WENT TO MULTIPLE SHOPS AND MECHANICS TO FIGURE OUT THE PROBLEM. AFTER PAYING TO REPLACE THE VCT SOLENOIDS IT WAS APPARENT THAT THAT WAS NOT THE ISSUE CAUSING THE TIMING PROBLEM. FOR WEEKS I NOTICED THE TRUCK SHAKING AND AT ONE POINT IT ACTUALLY STALLED AS I WAS PULLING OUT OF A PARKING LOT INTO A BUSY ROAD AND IT STALLED AS I WAS GOING INTO THE ROAD WHICH CAUSED THE ON COMING TRAFFIC TO SLOW AND STOP TO AVOID HITTING ME IN THE MIDDLE OF THE ROAD. AFTER SPENDING WEEKS IN THE DEALERSHIP SERVICE SHOP AND A LARGE SUM OF MONEY THEY FOUND THEY NEEDED TO REPLACE THE ENGINE ENTIRELY. I HAVE WITNESSED THIS ISSUE HAPPENING TO MANY MANY OTHERS ONLINE AND IN PERSON WHO HAVE THE SAME YEAR RANGE WITH THE 5.4L 3 VALVE TRITON ENGINES. THIS IS ABSOLUTELY UNACCEPTABLE FOR SO MANY VEHICLE TO HAVE THE SAME ISSUE ESPECIALLY WHEN IT HAS UNDER 100,000 MILES. IT IS NOT ONLY VERY POOR QUALITY FOR SUCH A LARGE PRICE BUT ALSO A SAFETY HAZARD TO THE OWNER AND OTHERS AROUND THESE VEHICLES.

TRUCK STARTS MAKING A LOUD TICKING NOISE COMING FROM ENGINE, I HAVE ALWAYS GOTTEN OIL CHANGES AND HAVE NO CLUE WHAT THIS IS BUT IT HAS LOWERED POWER ALSO. IT IS STILL MAKING THE TICKING/RATTLING NOISE AND ITS LOUD. CARRIED TO FORD DEALERSHIP AND WAS TOLD IT WOULD COST $2000.00 OR MORE. TOLD THIS IS NORMAL. I DON'T THINK A GASOLINE ENGINE SHOULD SOUND LIKE A DIESEL. THIS SEEMS TO BE A MANUFACTURER ISSUE AND FORD NEEDS TO TAKE RESPONSIBILITY FOR THE PROBLEM.

ENGINE STARTED TO IDLE ROUGH AND LOOSE ACCELERATION WHILE DRIVING UP HILL. STALLED A COUPLE TIMES WHILE STOPPED AND IDLING. THE ENGINE WOULD LAG WHILE ACCELERATING FROM A STOP. I TOOK THE TRUCK TO A LOCAL FORD DEALER AND FOR THE FIRST 3 TIMES, THEY COULDN'T FIND A PROBLEM. UPON THE FOURTH TIME AT THE DEALER, THEY SAID IT WAS THE CAM PHASER AND THAT THE ENGINE NEEDS REPLACED, AT 72,000 MILES. WHEN ASKED ABOUT THIS BEING FORD'S PROBLEM, THEY STATED THAT "IT HASN'T AFFECTED 1 MILLION VEHICLES, SO NO, NOT THEIR PROBLEM". THIS WAS A VERY CRITICAL SAFETY ISSUE, AS I WOULD LOOSE ACCELERATING POWER WHILE DRIVING.

TL* THE CONTACT OWNS A 2004 FORD F-150. WHILE REVERSING, THE VEHICLE ACCELERATED INDEPENDENTLY. THE CONTACT SHIFTED INTO DRIVE AND THE VEHICLE CONTINUED TO ACCELERATE. THE VEHICLE CRASHED INTO A POLE AND A FENCE. THE AIR BAGS FAILED TO DEPLOY. THE CONTACT SUSTAINED A BRUISED ARM THAT DID NOT REQUIRE MEDICAL ATTENTION. IN ADDITION, THE FRONT AND THE REAR PASSENGER SUSTAINED NECK, HEAD, BACK AND KNEES INJURIES THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 170,000.

TL* THE CONTACT OWNS A 2004 FORD F-150. WHILE DRIVING AT APPROXIMATELY 40 MPH IN THE RAIN, WATER POURED INTO THE REAR WINDOW OF THE CAB OF THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN REPLACED THE GASKET AROUND THE REAR WINDOW AND THE LAMP ASSEMBLY. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 31,000. UPDATED 11/19/15*LJ

MY HUSBAND WAS DRIVING HOME THIS PAST SUNDAY AND WAS STARTING TO TURN INTO THE DRIVE WHEN THE LEFT PASSENGER WINDOW FELL DOWN INTO THE DOOR. HE HAD NOT PUT IT DOWN OR UP - IT JUST FELL DOWN. THIS IS NOW THE 4TH WINDOW WE HAVE REPLACED IN THIS TRUCK. THE OTHER THREE HAVE BEEN REPLACED, TO THE TUNE OF $350.00 EACH. WHEN I BROUGHT THIS TO THE ATTENTION OF THE SERVICE MANAGER AT THE LOCAL FORD DEALERSHIP, HE SAID THERE WAS NOTHING THAT HE COULD DO - THE WINDOW REGULATORS JUST BREAK. I CONTACTED THE FORD 800 NUMBER AND WAS TOLD THE SAME THING - NOTHING TO BE DONE - JUST A BROKEN PART - EVEN THOUGH IT HAPPENS A LOT. HE SAID THERE WAS NO RECALL ON IT SO THERE WAS NO HELP THEY COULD GIVE. SO, I GUESS I'LL BE PAYING ANOTHER $350.00 AND PRAY THEY DON'T START DROPPING AGAIN SINCE FORD WON'T ADMIT THEY HAVE A PROBLEM.