2004 FORD F-150 Complaints

I LEAVE MY WINDOWS UP ON THE TRUCK. IT IS COLD (WINTER TIME) TRUCK WAS IN THE GARAGE. I WENT TO THE GARAGE AND THE WINDOW ON THE PASSENGER SIDE WAS DOWN. I CRANKED THE TRUCK, PUSHED THE BUTTON AND THE WINDOW WOULD NOT COME UP. I TOOK THE TRUCK TO THE DEALER THEY SAID THE FRONT DOOR WINDOW REGULATOR HAD TO BE REPLACED. THIS COST $344.66 TO REPLACE THE REGULATOR. SINCE THE FIRST REPLACEMENT, THE TWO BACK WINDOWS HAVE DONE THE SAME THING. I ASSUME IF MY TRUCK IS HAVING THIS PROBLEM OTHERS ARE ALSO. THIS APPEARS TO BE A DEFECT AND THE COMPANY SHOULD PAY FOR THE REPAIRS. *TR

WITH HEADLIGHT SELECTOR SWITCH IN THE AUTO POSITION THE HEADLIGHTS CAN SUDDENLY TURN-OFF WHILE DRIVING. I PURCHASED THE VEHICLE NEW AND HAVE ALWAYS HAD THE HEADLIGHT SWITCH IN THE AUTO POSITION SINCE DAY ONE. WHEN DRIVING AT NIGHT THE HEADLIGHTS SUDDENLY SHUT-OFF WHILE GOING DOWN THE HIGHWAY, VERY NEARLY LOST CONTROL OF VEHICLE WHEN TRYING TO PULL OVER AND STOP. THE PARK LIGHTS STILL WERE FUNCTIONING AND GOT THE HEADLIGHTS BACK ON BY SWITCHING THE HEADLIGHT SWITCH TO THE MANUAL POSITION. PER DISCUSSION WITH DEALER BELIEVE THE BODY CONTROL MODULE QUIT WORKING. SPECIFICALLY, A RELAY IN THE BCM HAS FAILED BUT IS NOT REPLACEABLE. REPAIR COST IS OVER $400.00 TO CHANGE MODULE. CAN'T AFFORD RIGHT NOW TO FIX. RESEARCH ON INTERNET FOUND NUMEROUS OTHER SIMILAR FAILURES/SYMPTOMS BUT NOT CLEAR IF HAPPENED WHILE VEHICLE WAS BEING DRIVEN. *TR

TL* THE CONTACT OWNS A 2004 FORD F-150. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 11V107000 (AIR BAGS). THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 148,000.

TL* THE CONTACT OWNS A 2004 FORD F-150. WHILE AN INDEPENDENT MECHANIC WAS PERFORMING A ROUTINE TUNE-UP ON THE VEHICLE, THE NUMBER THREE SPARK PLUG FRACTURED INSIDE THE ENGINE AND WAS UNABLE TO BE RETRIEVED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 127,000.

ORIGINAL OWNER OF 2004 FORD F150 FX4. FROM STOP THE REAR END WILL VIBRATE AS I ACCELERATE. IT'S BEEN DOING IT FOR QUITE A WHILE. I BELIEVE IT STARTED AROUND 40000 MILES. I ONLY HAVE 54000 ON IT CURRENTLY. SO IT HAS BEEN LIKE THIS FOR AT LEAST 3 OR 4 YEARS. IT SOUNDS LIKE THIS IS A PRETTY COMMON ISSUE. DOES SHOULD DEFINITELY FIX THIS KNOWN ISSUE. *TR

TL* THE CONTACT OWNS A 2004 FORD F-150. THE CONTACT STATED THAT THERE WAS RUST FORMING ON THE REAR DRIVER AND PASSENGER SIDE TIRE WELLS. THE FAILURE RECURRED CONTINUOUSLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE ENTIRE REAR PANEL NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 84,800.

I OWN A 2004 FORD HERITAGE 4X4 AND THE FRAME IS LITERALLY RUSTING AWAY ON OR ABOUT THE 10TH OF MARCH THE BRACKET THAT HOLDS THE REAR DRIVER SIDE LEAF SPRING ROTTED AWAY AND PUNCHED THROUGH THE BOTTOM OF MY BED. I WAS ONLY GOING 30 WHEN IT HAPPENED SO EVERYONE WAS SAFE. I ALSO HAD TO REPLACE THE TRAILER HITCH LAST YEAR BECAUSE THE FRAME WAS SO ROTTED AWAY. I STOPPED AT A STOP SIGN AND WHEN I WENT TO GO I SAW MY TRAILER JUST GO UP AND SLAM BACK DOWN ON THE GROUND. LUCKILY I WAS NOT GOING 65 MPH OTHERWISE I WOULD HAVE HAD A ACCIDENT. THE BACK OF THE FRAME NOW IS PAPER THIN. FORD SHOULD DO A RECALL ON THESE FRAMES. I HAVE OWNED MANY FORD AND NEVER HAD RUST THIS BAD. *TR

TRUCK REAR END SHAKES VIOLENTLY UPON ACCELERATION AT ANY SPEED OR FROM A STAND STILL. I HAD THE REAR END SERVICED AND HAD THE FLUID FLUSHED, BUT IT ONLY CORRECTED THE ISSUE FOR A SHORT AMOUNT OF TIME. AS TIME GOES ON, THIS ISSUE ONLY WORSENS. FORD HAS ISSUED A SERVICE BULLETIN FOR A DEFECTIVE CLUTCH PACK(S) IN THE REAR DIFFERENTIAL, BUT NOT A RECALL. THIS MAKES THE VEHICLE FEEL UNSAFE AND MAKES ACCELERATION UNEASY, ESPECIALLY WHEN MERGING INTO MOVING TRAFFIC. *TR

I HAVE 2004 F-150 WITH 92,000 MILES ON IT , I BOUGHT IT 3 YEARS AGO WITH 70,000 ON IT MAKING A SLIGHT TAPPING NOISE . I TALKED WITH MANY PEOPLE AND AND THE DEALER SAYING THAT THIS IS THE WAY THE ENGINE IS DESIGNED AND SHOULD BE FINE.YESTERDAY DRIVING DOWN A MAJOR HIGHWAY IN NORTHERN VIRGINIA TRAVELING AT 65 MPH MY TRUCK STARTED MAKING A NOISE FROM THE ENGINE AND SHUT OFF , I HAD GOOD OIL PRESSURE ,WATER TEMP WAS FINE I PULLED IT OFF THE HIGHWAY, NEVER TO START AGAIN. I HAD IT TOWED TO A LOCALE FORD DEALER IN FAIRFAX VA.AFTER READING FROM FORD FORUM WEB SITE AND HEARING THE HORROR STORIES I FEEL I AM IN FOR A HUGH REPAIR BILL.I ALSO SEE THERE IS A CLASS ACTION SUIT AGAINST THE FORD MOTOR COMPANY FOR NOT STANDING BEHIND THEIR VEHICLES WHEN THERE SEEMS TO BE A MAJOR FLAW IN THE ENGINES DESIGN. APROX. COST OF A NEW ENGINE IS BETWEEN 7 AND 10,000 SOME CONSUMERS STARTED TO HAVE PROBLEMS AS EARLY AS 12,000 MILES, I BABY MY TRUCK, THE HEAVIEST THING I HAVE HAULED IN IT IS A 6 FT. CHRISTMAS TREE FOR MY LIVING ROOM.I BABIED MY TRUCK TO WHAT MEANS JUST TO HAVE A HIGH REPAIR BILL LIKE SO MANY OTHERS??? I HOPE YOU CAN HELP . PLEASE/THANK -YOU IN ADVANCE *TR

2004 FORD F-150. CONSUMER WRITES IN REGARDS TO VEHICLE FRAME RUST PROBLEMS. *SMD CONSUMER SENT ADDITIONAL CORRESPONDENCE. *SMD THE VEHICLE HAD TO BE TOWED TO THE REPAIR SHOP, BECAUSE THE BRAKES WENT OUT. THE REAR BRAKE LINES, HOSES, CALIPERS, MASTER CYLINDER AND PADS WERE REPLACED. UPDATED 03/09/15. *JB