2006 FORD F-150 Complaints

TL* THE CONTACT OWNS A 2006 FORD F150. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 5 MPH, THE BRAKE PEDAL WAS DEPRESSED AND THERE WAS A DELAYED RESPONSE. THE VEHICLE HAD BEEN PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER 08V208000 (SERVICE BRAKES, HYDRAULIC). THE FAILURE RECURRED BECAUSE THE RECALL REMEDY FAILED TO CORRECT THE PROBLEM. THE CONTACT DIAGNOSED THE VEHICLE AND REPLACED THE MANIFOLD HOSE HIMSELF. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 92,000.

I WAS DRIVING DOWN US 281(BUSY 3 LANE HIGHWAY) IN SAN ANTONIO AND THE ENGINE SHUT OFF CAUSING ME TO COAST TO A STOP IN THE MIDDLE OF TRAFFIC. ONCE I GOT OFF OF THE ROAD, THE ENGINE STARTED UP LIKE NOTHING WAS WRONG. AFTER I INSPECTED THE FLUIDS AND SAW EVERYTHING CHECKED OUT, I GOT BACK ON THE HIGHWAY ONLY TO HAVE THE ENGINE SHUT OFF AGAIN. I CALLED FORD TO SEE IF THERE WAS AN ISSUE REPORTED OR A RECALL, AND THERE WAS NOTHING. I FOUND OVER 300 COMPLAINTS ON VARIOUS FORUMS BY TYPING IN --2006 F150 FAILSAFE--IN THE SEARCH ENGINE. I THINK THIS IS A REAL SAFETY ISSUE THAT FORD NEEDS TO ADDRESS BEFORE SOMEONE GETS KILLED ON THE ROAD. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

TL* THE CONTACT OWNS A 2006 FORD F150. THE CONTACT STATED THAT THE STEERING WHEEL BECAME UNSTABLE WHILE DRIVING AT AN UNKNOWN SPEED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER MULTIPLE TIMES. THE DIAGNOSIS WAS TO REPLACE THE STEERING SHAFT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 48,000.

WHEN STOPPED AT A RED LIGHT MY ENGINE BEGAN TO REV. AT VERY HIGH RPM'S AND THE TIRES BURNED OUT WHEN I SHIFTED THE TRANSMISSION INTO NEUTRAL. I PURCHASED THIS TRUCK IN DEC. 2013 AND THIS WAS APPROX. THE 7TH INCIDENT OF SUDDEN ACCELERATION. IT SEEMS TO ONLY HAPPEN WHEN STOOPED OR SLOWING DOWN. ANY HELP IN THIS MATTER WOULD BE DEEPLY APPRECIATED. THANKS IN ADVANCE. *TR

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT WHILE INSIDE OF THE VEHICLE, SHE WOULD SMELL GASOLINE FUEL. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION AND THEY STATED THAT THE FUEL INJECTOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 89,000. *TR

I TRIED TO START MY TRUCK, BUT IT WOULDN'T START. IT TURNED OVER PERFECTLY BUT WOULD NOT START. IT HAD STARTED TWICE EARLIER IN THE DAY. THE FUEL PUMP DRIVER MODULE, LOCATED ABOVE THE SPARE TIRE ON THE FRAME OF THE TRUCK, HAD CORRODED AND FAILED.

I BROUGHT MY TRUCK IN TO MY LOCAL FORD DEALER BECAUSE THE CHECK ENGINE LIGHT CAME ON. IT IS A 2006 F150 4.6L - AFTER HIS INSPECTION, THE MECHANIC STATED THAT THE BOTTOM OF THE #2 SPARK PLUG (MANUFACTURE INSTALLED) HAD DISINTEGRATED AND FELL INTO THE HEAD CAUSING SO MUCH DAMAGE TO THE #2 CYLINDER THAT I HAVE TO REPLACE THE ENTIRE ENGINE AT A COST OF OVER $6,000 PLUS TAX. IT WILL TAKE OVER A WEEK TO FIX AND I DO NOT HAVE ANOTHER VEHICLE. I WOULD LIKE FORD TO REIMBURSE ME FOR THE EXPENSE. I HAVE WRITTEN TO THEIR "CUSTOMER CARE"( [XXX]) DEPARTMENT, BUT HAVE HAD NO HELPFUL OR SATISFACTORY RESULTS. THIS IS A KNOWN ISSUE AS FORD HAS ISSUED A TSB AND DEVELOPED A TOOL TO ASSIST WITH THE REMOVAL OF FAULTY SPARK PLUGS. *TR

THE FRAME BROKE WHERE THE FRONT DIFFERENTIAL MOUNTS, THIS LET THE FRONT AXLE TWIST AND YOU CAN NOT STEER THE TRUCK!!! I THINK THIS IS VERY DANGEROUS, IF YOU WERE GOING OVER 5 MPH. YOU COULD NOT TURN.FORD FACTORY REP. SAYS THE TRUCK IS OUT OF WARRANTY SO NOT THERE PROBLEM, THEY WILL NOT DO ANYTHING ABOUT IT. FORD SHOULD FIX THIS AT THERE EXPENSE AS THIS A SAFETY CONCERN. HOW MANY OTHER FORD PICK UPS HAVE HAD THIS SAME PROBLEM BUT NOT REPORTED IT BECAUSE THEY DID NOT HOW TO OR WHO TO COMPLAIN TO. THE NTSB SHOULD LOOK INTO THIS VERY CAREFULLY TO SEE IF THIS IS A MAJOR PROBLEM. *TR

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT THE VEHICLE WAS HESITANT TO ACCELERATION. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE SPARK PLUGS WERE DEFECTIVE AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 90,000 AND THE CURRENT MILEAGE WAS UNKNOWN.

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 30 MPH THE POWER STEERING FAILED WITHOUT WARNING. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE TO HER RESIDENCE. THE FAILURE WAS NOT DIAGNOSED BY A DEALER OR INDEPENDENT MECHANIC. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATELY FAILURE MILEAGE WAS 154,618.