2006 FORD F-150 Complaints

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT THE INSTRUMENT CLUSTER SHUT OFF WHENEVER THE TEMPERATURE WAS ABOVE 70 DEGREES. THE CONTACT MENTIONED THAT IT WOULD RETURN TO NORMAL ONCE THE TEMPERATURE WAS COOLER. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN STATED THAT THE INSTRUMENT CLUSTER NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 114,000. *TR

WHILE REPLACING THE SPARK PLUGS, EVERY PLUG BROKE OFF AND WAS VERY DIFFICULT TO REMOVE. MY MECHANIC GOT OUT THE FIRST SEVEN, BUT THE EIGHTH WOULD NOT COME OUT. IT SUBSEQUENTLY FELL INTO MY ENGINE, CAUSING IT TO SEIZE. I SHOULD HAVE GOTTEN ANOTHER 100,000 MILES OUT OF THIS TRUCK! *TR

THE LED DISPLAY THAT INDICATES THE MILEAGE, GEAR SELECTOR AND WARNING INDICATOR IS NO LONGER OPERABLE. FROM A QUICK WEB SEARCH AND A DISCUSSION WITH THE LOCAL FORD SERVICE DEPARTMENT THIS IS A KNOWN ISSUE THAT IS NOT CURRENTLY COVERED BY A RECALL. INABILITY TO VIEW MILEAGE AND WARNING INDICATORS RESULTS IN UNSAFE DRIVING CONDITIONS. *TR

DRIVING EAST ON I90 (ABOUT 20 MILES WEST OF STEWARTVILLE, MN) DURING FREAK MAY BLIZZARD. DUE TO ROAD CONDITIONS, COULD ONLY DRIVE BETWEEN 15-40 MPH. SUDDENLY THE ENGINE STOPPED RUNNING. I WAS ABLE TO START IT UP AGAIN AND DRIVE ABOUT 3 MINUTES AND THEN IT WOULD DIE AGAIN. THERE WAS NO PLACE TO PULL OVER, AS THE SHOULDERS OF THE ROAD WERE NOT CLEARED AND THERE WAS 12" OF WET HEAVY SNOW. MY TRUCK IS NOT 4WD SO WE WOULD HAVE GOTTEN STUCK. WE HAD TO DRIVE WITH THE HAZARDS ON, BUT IT WAS LOW VISIBILITY AND WE COULD EASILY HAVE BEEN HIT FROM BEHIND. WE COULD NOT GET OFF ON THE EXIT RAMP BECAUSE A SEMI TRUCK JACKNIFED AND THE EXIT WAS CLOSED. WE HAD TO CONTINUE THIS HAZARDOUS JOURNEY TO THE NEXT EXIT, WHICH WAS ABOUT 12 MILES AWAY, TO STEWARTVILLE, MN. WE FOUND A AUTO REPAIR SHOP AND DESCRIBED THE PROBLEM. THE MECHANIC SUSPECTED IMMEDIATELY THAT IT WAS THE FUEL PUMP CONTROL MODULE. HE SAID THAT HE HAS BEEN INSTALLING A LOT OF THESE LATELY ON F150S, ESPECIALLY 2006'S. HE SAID HE FELT THERE SHOULD BE A RECALL, AS IT IS WELL-KNOWN AMONG MECHANICS THAT THESE ARE FAILING AT AN ALARMING RATE. THE PROBLEM IS THAT THE MODULE IS LOCATED TIGHT AGAINST THE FRAME, NEXT TO THE SPARE TIRE, AND THE METAL OF THE MODULE (ALUMINUM) REACTS ADVERSELY WITH THE STEEL METAL OF THE FRAME, CAUSING OXIDATION BETWEEN THE TWO. THIS CAUSES THE MODULE TO BREAK AND FAIL, THUS SHORTING OUT THE CIRCUIT BOARD. FORD KNOWS THAT THIS IS A PROBLEM, AS THE REPLACEMENT PARTS HAVE SPACER PLATES TO KEEP THE MODULE & FRAME SEPARATED. FORD SHOULD ISSUE A RECALL ON THIS PART BEFORE SOMEONE GETS KILLED. WE COULD EASILY HAVE BEEN KILLED, AS WE COULD NOT PULL OFF THE INTERSTATE. THE PART IS RELATIVELY INEXPENSIVE (WE PAID $189 FOR THE PART). WE SHOULD HAVE BEEN NOTIFIED OF THIS ISSUE. *TR

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT WHILE REVERSING AT 3 MPH, THE VEHICLE STALLED AND WOULD NOT RESTART. AN INDEPENDENT MECHANIC DIAGNOSED THE VEHICLE AS HAVING A FAULTY FUEL PUMP AND/OR FAULTY FUEL DRIVER MODULE. THE MANUFACTURER WAS NOTIFIED BUT OFFERED NO ASSISTANCE. THE VEHICLE HAD NOT BEEN REPAIRED. THE VIN WAS UNAVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 103,000.

A DEER RAN OUT IN FRONT OF VEHICLE..ROAD WET AND IT WAS FOGGY..TRIED TO KEEP FROM HITTING DEER..BACK OF TRUCK FISHTAILED..LOSS CONTROL..HIT A DITCH AND EMBANKMENT...AIR BAGS DID NOT EMPLOY AND SEAT BELT DID NOT LOCK...HAD A FRACTURE IN L2 VERTEBRAE OF BACK..FORD HAS DENIED ANY FAULT IN AIR BAG OR SEAT BELT FUNCTION...TRUCK WAS TOTALED BY INSURANCE COMPANY..... *TR

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT WHILE TRAVELING 44 MPH, THE VEHICLE SHOOK VIOLENTLY THEN STALLED. THE VEHICLE WAS RESTARTED AND THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS TOWED TO A DEALER WHERE IT CONFIRMED THAT THE FUEL PUMP HAD FAILED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 111,600. THE VIN WAS UNAVAILABLE.

I WAS WARMING THE VEHICLE TO GO TO WORK, MY TRUCK JUST SUDDENLY STALLED, HAD TO GET A TOW TO THE NEAREST FORD DEALER, THE MECHANIC SAID THE FUEL PUMP MODULE UNIT WENT OUT, THE PART IS ON BACK ORDER OR EMERGENCY ORDER, I HAVE NO VEHICLE TO GET TO WORK, I NEED MY VEHICLE, THIS PART SHOULD BE ON RECALL FOR FORD F150. *TR

DRIVING VEHICLE DRIVE AND OVERDRIVE WENT OUT THIS IS TWO TIMES THIS HAPPENED FORD NEEDS TO PAY FOR REPAIRS OTHER PEOPLE HAVE SAME PROBLEM THIS PROBLEM SHOULD BE LOOKED INTO. *TR

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 65 MPH WITH THE CRUISE CONTROL ACTIVATED, THE ENGINE RPMS INCREASED AND THE VEHICLE WOULD NOT ACCELERATE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS. THE TECHNICIAN ADVISED THE CONTACT THAT THE TRANSMISSION WOULD HAVE TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 64,000. *TR