2004 FORD F-150 Complaints

TL* THE CONTACT OWNS A 2004 FORD F-150. THE CONTACT STATED THAT THE DRIVER WAS EXITING A PARKING AREA WHEN A LOUD NOISED WAS HEARD FROM UNDERNEATH THE VEHICLE. THE CONTACT INSPECTED THE VEHICLE AND FOUND THAT THE DRIVE SHAFT WAS FRACTURED IN HALF AND CAUSED DAMAGE TO THE FUEL TANK AND MUFFLER. THE VEHICLE WAS TOWED TO THE CONTACT'S HOME. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WERE 146,000.

TL* THE CONTACT OWNS A 2004 FORD F-150. THE CONTACT STATED THAT THE VEHICLE BURNED AND WAS COMPLETELY DESTROYED AFTER BEING PARKED FOR SEVEN HOURS. THE FIRE DEPARTMENT DETERMINED THAT THE FIRE ORIGINATED UNDERNEATH THE ENGINE COMPARTMENT. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WERE 47,000.

HAD A LOUD WHINNING NOISE I COULD HEAR WHEN DRIVING, BUT WHEN I LET OFF THE GAS IT WOULDN'T BE AS LOUD AND PRETTY MUCH GO AWAY. IT WAS NOT TIRE NOISE OR HUM. JUST HIT A 100,000 MILES AND THE NOISE HAD GOTTEN A LOT LOUDER. I READ LOTS INFORMATION ONLINE AND FOUND IT TO BE THE PINION BEARING. TOOK IT TO LOCAL REPAIR SHOP AND THEY CONFIRMED THAT THE PINION BEARING HAD GONE BAD. THIS IS VERY SURPRISING THAT SO MANY 2004 AND NEWER F150 OWNERS ARE HAVING THIS SAME PROBLEM AND NOTHING IS BEING DONE BY FORD. I THINK THEY ARE TURNING A BLIND EYE BECAUSE OF THE COST OF PARTS AND AMOUNT OF TIME OF LABOR. BESIDES THE PINION BEARING, ALSO HAD TO DO OTHER BEARINGS AND SEAL. TRUCK IS NOT DRIVEN HARD AT ALL. *TR

IT APPEARS THAT THERE WAS AN ISSUE WITH THE PARKING BRAKE LINKAGE. THERE HAD BEEN SMALL NOTICEABLE SHIMMY WITH THE BRAKES, WHICH HAVING BEEN FAIRLY RECENTLY REPLACED, DID CONCERN ME. HOWEVER, ON THE WAY HOME, I TAPPED THE BRAKE AT APPROX 35 MPH, I GOT A VERY LARGE CLUNK IN THE REAR. I CONTINUED TO DRIVE, VERY CONCERNED OVER WHAT MAY HAVE OCCURRED. HOWEVER, I WAS ON OPEN ROAD, 40 MILES FROM HOME. AS I CONTINUED TO DRIVE, I COULD TELL THERE WERE MAJOR ISSUES. IT WAS BAD WEATHER, AND I WAS IN MIDDLE OF NOWHERE. I CONTINUED HOME TO MY REPAIR SHOP. THEY INFORMED ME THE NEXT DAY, THAT THE PARKING BRAKE LINKAGE GOT FOULED UP, WRAPPED AROUND A BRAKE OR SOMETHING, EVENTUALLY TEARING IT ALL UP. THIS IS COSTING ME APPROX $500 TO REPLACE. AFTER RESEARCH, I SEE A TSB 08-11-1 WAS ISSUED. WHY NOT OWNERS NOTIFIED? THIS IS AN ISSUE THAT SHOULD HAVE BEEN SENT TO OWNERS FOR A FIX. I BLAME FORD. *TR

TL* THE CONTACT OWNS A 2004 FORD F-150. THE CONTACT STATED THAT THE FRAME MEMBERS WERE EXTREMELY CORRODED. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 109,000.

HAD THE SAME PROBLEM AS MENTIONED MULTIPLE TIMES IN THIS LIST. ACCELERATING PAST 40 MPH, THE TRUCK SLIPPED OUT OF GEAR AND REV'D UP TO ABOUT 4000RPM. DID THE SAME THING REPEATEDLY AFTER THE FIRST INCIDENT. APPARENTLY A BROKEN SNAP RING. HARD TO BELIEVE THIS IS NOT CONSIDERED A SAFETY HAZARD, AND SOMETHING THAT SHOULD BE FIXED VIA RECALL?? *TR

ON FRIDAY, NOVEMBER 22, 2013 WHILE DRIVING TO WORK ON THE FREEWAY, I FELT SEVERAL "THUMPS" PRIOR TO THE REAR LEFT TIRE ON MY F-150 BLOW. THERE WAS NO LOAD IN THE TRUCK NOR WAS I TOWING. I WAS ABLE TO SAFELY GET ONTO THE SHOULDER. AAA RESPONDED AND ATTEMPTED TO CHANGE THE TIRE. HE WAS UNABLE, AS SOME OF THE TIRE TREAD WAS WRAPPED AROUND THE AXLE. WE ALSO OBSERVED THE PARKING BRAKE CABLE BROKEN. A TOW TRUCK WAS THEN DISPATCHED TO MOVE MY F-150 TO A GARAGE. DAMAGE NOTED TO THE TRUCK WAS A SNAPPED PARKING BRAKE CABLE AND A KINKED HYDRAULIC LINE. I AUTHORIZED THE GARAGE TO REPAIR THE BRAKE SYSTEM AND GET MY TRUCK BACK ON THE ROAD. BY THE TIME THEY WERE ABLE TO GATHER THE REPAIR PARTS, IT WAS THE FOLLOWING WEDNESDAY (DAY BEFORE THANKSGIVING) WHEN I ABLE TO GET IT BACK. FIRST THING I NOTICED WAS THE BROKEN TRAILER ELECTRICAL CONNECTOR ON THE BUMPER. DISCUSSIONS WITH THE TOW COMPANY AND THE GARAGE DETERMINED THAT THE DAMAGE WAS CAUSED BY FLYING RUBBER. THAT WEDNESDAY AFTERNOON I TOOK THE TRUCK TO DISCOUNT TIRE TO HAVE THE DAMAGED TIRE REPLACED UNDER THE ROAD HAZARD WARRANTY I HAD PURCHASED FROM THEM. EXAMINATION OF THE REMAINING THREE LTX M/S TIRES REVEALED ANOTHER TIRE WITH A DELAMINATION BULGE. DISCOUNT REPLACED TWO OF THE TIRES UNDER THE WARRANTY WITH LTX M/S2?S, AND I PURCHASED TWO MORE. I DID NOT WANT TO TAKE ANY MORE RISKS WITH THE REMAINING LTX M/S'S. *TR

TL* THE CONTACT OWNS A 2004 FORD F150. THE CONTACT STATED THAT BOTH FRONT SUSPENSION SPRINGS WERE BROKEN. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE AND THE CURRENT MILEAGE WAS 93,000.

DRIVING DOWN MY STREET THE WINDOW JUST CRASHED DOWN! IT FELL SO FAST AND HARD THAT I HAD TO LOOK TO MY RIGHT SIDE TO SEE WHAT HIT ME! AT THAT POINT I REAR ENDED A CAR THAT SLOWED DOWN! ALL THIS IS DO TO A CHEAP PLASTIC CLIP THAT FAILED AND RELEASED THE WINDOW. *TR

TL* THE CONTACT OWNS A 2004 FORD F150. THE CONTACT STATED THAT ON MULTIPLE OCCASIONS THERE WAS A STRONG ODOR OF GAS FUMES COMING FROM THE ENGINE COMPARTMENT AT RANDOM. THE FAILURE WAS NOT DIAGNOSED NOR WAS THE VEHICLE REPAIRED. THE CONTACT WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER(S): 11V385000 (FUEL SYSTEM, GASOLINE), 06E056000 (FUEL SYSTEM, GASOLINE), 04V443000 (FUEL SYSTEM, GASOLINE) AND 04V200000 (FUEL SYSTEM, GASOLINE) BUT CONTINUED TO SMELL THE STRONG FUMES OF GASOLINE INTERMITTENTLY. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 15,000.