2012 FORD F-150 Complaints

vehicle died when driving (and has continued to die when driving). Seems to sputter as if downshifting and then totally stalls out, causing safety concern when driving in traffic and randomly dying. Luckily had somewhere to pull off of the road and not cause an accident. Have confirmed with auto repair shop that the main concern is the powertrain control module. Shop has been able to replicate this happening as they have driven it as well. No warning lamps/lights/etc present prior to this happening.

Driving on freeway and truck downshifted and almost control, orange wrench was on display, speedometer stopped working and I could barley get to 30 mph...finally was able to pull off freeway...turned -off...waited and turned back on...engine light was on...it drove alright for alittle bit, than it downshifted to first and would shift had to pull over and shut it down again and restart...made it home...next day took to AUTO ZONE...Code reads P0720 OSS SENSOR FAULT...Ford had a SAFETY RECALL19S07 for trucks 2011-2013 ...I did not receive any letter for that or the Customer Satisfaction Program 19N01...same issue and cannot drive my truck, it is unsafe...had to drop-off at FORD Dealership to repair and update software on transmission...it should be repaired at no charge, having to pay for Rental.

The contact owns a 2012 Ford F-150. The contact stated that while driving at an undisclosed speed, the transmission warning light illuminated, and the transmission inadvertently downshifted. Additionally, the vehicle would not accelerate above 30 MPH while driving. The contact restarted the vehicle to correct the failure; however, the check engine warning light illuminated. The vehicle was taken to an independent mechanic, who diagnosed that the output speed sensor needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 136,000. The contact wants to reimbursed for the cost of the repairs.

The contact owns a 2012 Ford F-150. The contact stated while driving 60 MPH, the vehicle lost electronic functions. The vehicle then shifted abnormally before downshifting into first gear, causing the vehicle to come to a sudden stop. The contact stated that he was able to maneuver the vehicle to the shoulder of the roadway before the vehicle went into LIMP Mode. After restarting the vehicle, the electronic functionality returned. The vehicle was taken to the dealer, who diagnosed a failure with the powertrain control module. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 16V248000 (Power Train). The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 127,000.

The problem with this vehicle is the body control module has gone out. It controls everything from the safety functions to back up cameras and engine function and starting. My truck first, lost its back up camera within the first year of purchase, then the driver side, turn signals, stopped working, the battery drains overnight, and the latest issue is that the truck will turn off while driving down the road. Three months ago, the engine cut off and all systems locked up while I was driving 45 mph in town. There are no issues with any other system in the truck. Mechanics have tested everything and state. It is only the body control module. I am unable to purchase a body control module from Ford and my mechanic, the Ford mechanics, the Ford distributor for this region, nor Carmax, where I bought the car can get the part because Ford says that all of their shelf held parts for this vehicle type are defective. They state is a known issue and there is no date for resolution at all. The date on the shelf hold is zero month zero day zero year meaning no date. The body control module in this series of Ford F1 50s is a “known issue” to Ford. Due to their semi conductor manufacturer contract that has lapsed for this older technology, they state that the 4000 vehicle’s that currently require this part are not they’re greatest concern. They stated that there is an indefinite “shelf hold” on this part due to their only being less than 50 of them available for anyone to purchase. Those parts that are being held are also suspect of defect. Since I have only owned this vehicle for two years and it is under the extended warranty, I purchased with it having only 19,000 miles on it that I have put on it, it seems that they should at least allow me to buy one of the shelf, held pieces to replace mine. Please help the 4000 of us. Please encourage them to do what’s right for all of us. I still owe $17k on a non-running vehicle Carmax or Ford wont buy back.

The contact owns a 2012 Ford F-150. The contact stated that on several occasions while driving at approximately 70 MPH, the vehicle unexpectedly downshifted to third gear. The contact also stated that while driving at various speeds, the vehicle downshifted to first gear with the service vehicle warning light illuminated and DTC code: P0720 (Powertrain Control Module) was illuminated on the instrument panel. The contact veered to the side of the road. The contact stated that after several attempts, she was able to restart the vehicle. The vehicle was taken to the dealer where the contact was informed that the vehicle had exceeded the timeframe for Customer Satisfaction Program: 19B05,19S19, 19S07. The contact was advised to call the manufacturer for assistance. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and the contact was referred to the NHTSA Hotline. The failure mileage was approximately 167,000.

The contact owns a 2012 Ford F-150. The contact stated while driving 65 MPH, the vehicle lost power steering functionality with the traction control warning light illuminated. Due to the failure, the vehicle was towed to an independent mechanic where it was discovered that the power steering angle sensors were defective, and the rack and pinion needed to be replaced. An unknown dealer was notified of the failure and the contact was informed that there were no recalls on the VIN. The manufacturer was not notified of the failure. The vehicle was not repaired and remained in the possession of the dealer. The failure mileage was approximately 141,000.

The contact owns a 2012 Ford F-150. The contact stated that while driving at various speeds on several occasions, the transmission down shifted inadvertently, and the tires locked up and the vehicle skidded. The contact veered over to the side of the roadway and turned off and restarted the vehicle. Additionally, the contact stated that when the brake pedal was depressed, the brake lights failed to illuminate as designed. The wrench warning light was illuminated. The vehicle was turned off and restarted and the wrench light disappeared. The contact stated that after driving for a few miles, the transmission downshifted, and the wheels locked up. The vehicle was taken to an independent mechanic to be diagnosed and it was determined that the transmission range sensor needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 160,000. The consumer stated the failure mileage is incorrect, it was 142,000.

Automatic transmission dropped out of gear while driving on the Interstate going around 60-65mph today. The wheels locked up and the vehicle just reved like it was in neutral. From other Ford owners (Unintended downshift into first gear can cause an abrupt wheel speed reduction, which could cause the rear tires to slide until the vehicle slows down. This condition could result in a loss of vehicle control, increasing the risk of a crash) My truck shows no mileage and the airbag light is on.No inspection has been performed as of today. Recall # 19507

As your driving advance track failure light comes on and you lose power steering. Steering gets real tight and hard to turn. Almost got in a car accident but was able to turn the steering as hard as i could just to make the turn. Drive for a little while then all of a sudden power steering kicked back on. It happen every time i drive my truck.