2006 FORD F-150 Complaints

THE PASSENGER ASSIST HANDLE ATTACHED TO THE A PILLAR ON THE PASSENGER SIDE OF THE VEHICLE FAILED AT BOTH CONNECTION POINTS TO THE A PILLAR WHILE MY WIFE WAS ENTERING THE VEHICLE. MY WIFE WAS STANDING ON THE RUNNING BOARD AT THE TIME OF THE FAILURE OF THE ASSIST HANDLE, THE HANDLE COMPLETELY SEPARATED FROM THE VEHICLE AND SHE FELL OFF THE RUNNING BOARD WITH THE HANDLE IN HER HAND, LANDING ON HER BACK AGAINST A CURB IN THE PARKING LOT. THIS IS THE THIRD FAILURE OF THIS PART SINCE THIS VEHICLE WAS PURCHASED NEW ON 10/06/2006. THE FIRST FAILURE OCCURRED WITHIN THE FIRST 12 MONTHS OF OWNERSHIP. THE SECOND FAILURE HAPPENED WITHIN THE FIRST 36 MONTHS OF OWNERSHIP. AFTER EACH INCIDENT, FORD REPLACED THE DEFECTIVE PART WITH AN IDENTICAL PART. THE FIRST TWO INCIDENTS DID NOT RESULT IN INJURY TO MY PASSENGER. FORTUNATELY, MY WIFE WAS NOT SERIOUSLY INJURED IN THE RECENT EVENT. *TR

I WAS DRIVING HOME AND SLOWED DOWN TO 15 MILES PER HR TO MAKE A LEFT HAND TURN AND HEARD A BIG BANG I DID NOT KNOW WHAT HAPPENED AT THE MOMENT I CONTINUED TO PROCEED ON AND THE NOISE WAS LOUD LIKE AN EXHAUST LEAK BUT TO COME FIND OUT THE NEXT TWO DAYS ON THINKING WHAT TO DO I PULLED OFF THE #4 PLUG IT WAS OUT OF THE MOTOR ALREADY IT ACTUALLY BLEW OUT OF THE ENGINE. WHAT ARE MY RIGHTS IF ANY? *TR

ABS SENSOR SHORTED OUT AND FUSED TO WIRE HARNESS FOR WHOLE ELECTRICAL SYSTEM, FORD CLAIMS NO RECALL, COULD HAVE CAUSED MAJOR FIRE, NOTED COMPLAINT #10195595 WAS VERY SIMILAR. CAUSED $2300 DOLLAR REPAIR. *TR

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING 15 MPH, THE COVER TAIL GATE FELL AND DETACHED FROM THE VEHICLE. THE FAILURE RECURRED AND THE ENTIRE PART THAT COVERED THE TAIL GATE WAS MISSING. THE VEHICLE WAS TAKEN TO A REPAIR SHOP HOWEVER, THE VEHICLE WAS NOT REPAIRED AND THE PART WAS STILL MISSING. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT NO ASSISTANCE WAS PROVIDED. THE VIN WAS UNAVAILABLE. THE CURRENT AND FAILURE MILEAGE WAS 62,000.

THE PASSENGER SIDE SEAT BELT HAS BECOME UNUSABLE DUE TO NOT COMING OUT TO BE ABLE TO BELT IN PASSENGERS. ALSO, IT WILL NOT RETRACT FULLY. THIS IS A SERIOUS SAFETY ISSUE, DUE TO SEAT BELT LAWS AND REGULATIONS AND PASSENGER SAFETY ISSUES, AND SHOULD BE ADDRESSED AND FIXED ON ANY FORD THAT IS HAVING SUCH ISSUES OR SIMILAR ISSUES. *TR

ON JULY 1, 2012, MY 2006 FORD F-150 SUPER CREW TRUCK CAUGHT ON FIRE WHILE SITTING IN MY DRIVEWAY. THE TRUCK HAD BEEN SITTING UNTOUCHED FOR A WEEK WHEN IT CAUGHT ON FIRE WITHOUT ANY EXPLANATION. FIRE INVESTIGATORS WERE UNABLE TO DETERMINE THE CAUSE OF THE FIRE BECAUSE THE TRUCK WAS APPROXIMATELY 90% BURNED. *TR

STEERING BECAME VERY HARD TO TURN. WOULD NOT CENTER AFTER TURNING, WOULD LOCK ON WET ROADS. I HAD TO TURN THE STEERING WHEEL BY HAND TO GET IT BACK TO CENTER. I CHECKED TO FIND THE U JOINTS ON STEERING SHAFT WHERE RUSTED SO I LUBED WITH OIL. STEERING BECAME MUCH BETTER. I WENT TO A LOCAL FORD DEALER THEY SAID THERE WAS NO RECALLS AND KNEW OF NO PROBLEMS WITH THE STEERING ON THE F150'S. THE FORD DEALER WANTED ME TO LET THEM TAKE EVERYTHING APART BUT SAID IT COULD RUN INTO A LOT OF MONEY DEPENDING ON WHAT THEY FIND. SO FOR OVER THREE YEARS I'VE BEEN OILING THE JOINTS ON THE SHAFT AND LIVING WITH THE PROBLEM. WAITING FOR TOTAL FAILURE TO SUE FORD FOR POOR DESIGN OF THE STEERING COLUMN SHAFT JOINTS. *TR

I WAS DRIVING ON THE HIGHWAY WHEN ALL OF MY GAUGES WENT DEAD INCLUDING THE SPEEDOMETER, A COUPLE OF MINUTES LATER THEY CAME BACK ON AND WHEN THEY DID THE AIRBAG WARNING LIGHT STARTED BLINKING RAPIDLY. A FEW MOMENTS LATER THE GAUGES WENT DEAD AGAIN, WHEN THEY CAME BACK ON THE SECOND TIME THE AIRBAG WARNING LIGHT STARTED BLINKING RAPIDLY AND ERRATICALLY. SINCE THAT TIME MY GAUGES HAVE FAILED 3 MORE TIMES WITH THE SAME BEHAVIOR FROM THE AIRBAG WARNING LIGHT. I DID SOME RESEARCH ONLINE AND FOUND THAT EVEN THOUGH FORD HAS NOT RECALLED THIS PROBLEM IT HAS BEEN EXPERIENCED BY HUNDREDS OF 2006 FORD F150 OWNERS. *TR

I HAD A FUEL INJECTOR FAIL THAT COMPLETELY RUINED THE ENGINE AT 71K MILES. I HAD TO HAVE IT REPLACED. I WAS VERY SURPRISED TO SEE THAT MY PROBLEM WAS EXACTLY LIKE THE FORD 2005 CUSTOMER SATISFACTION PROGRAM 07M08 PROBLEM. MY TRUCK WAS BUILT IN 2005, BUT TITLED AS A 2006. I HAVE TALKED AND WROTE TO FORD BUT THEY WOULD NOT HELP ME. I TOLD THEM I STILL HAVE THE FAILED INJECTOR AND THEY WOULDN'T EVEN LOOK AT IT TO SEE IF IT WAS ONE OF THE DEFECTIVE PARTS THAT SPURRED THE 07M08 PROGRAM. I BELIEVE FORD NEEDS TO EXPAND THE CUSTOMER SATISFACTION PROGRAM 07M08 TO INCLUDE 2006 MODELS. I WOULD LOVE FOR THE NHTSA TO PRESSURE FORD TO REVISIT THIS ISSUE. THIS WAS HARD FOR ME BECAUSE I STILL HAVE THE INJECTOR THAT FAILED. I KEEP IT AS A REMINDER OF THE $8,000 I HAD TO SPEND ON A NEW ENGINE. I BELIEVE THE NHTSA SHOULD PRESSURE FORD TO ADMIT WHICH INJECTORS WERE AN ISSUE SO PEOPLE LIKE ME HAVE LEVERAGE TO FIGHT GIANTS LIKE FORD THAT IN THIS CASE SCREWED THEIR CUSTOMER. *JS

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT BOTH OF THE DECALS ON THE VEHICLE WERE FADED AND DELAMINATED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT CONTACTED. UPDATED 07/13/12*LJ UPDATED 07/17/12