2004 FORD F-150 Complaints

TL* THE CONTACT OWNS A 2004 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 70 MPH, THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE SPARK PLUGS NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 140,000. THE VIN WAS NOT AVAILABLE. *TR

DRIVING DOWN THE HIGHWAY AND HEARD LOUD NOISE AND TRUCK CAME TO A STOP, PULLED OFF SAFELY TO SIDE OF THE ROAD FOUND OUT IT WAS MISFIRE IN CYLINDER 2. ONLY HAVE HAD TRUCK FOR 5 MONTHS NOW NEEDS A BRAND NEW ENGINE. *TR

I STARTED UP MY TRUCK IN MY DRIVEWAY AND BEGAN TO LOWER THE DRIVER AND PASSENGER SIDE WINDOWS WHEN THE DRIVERSIDE WINDOW JUST FELL DOWN. *TR

TL* THE CONTACT OWNS A 2004 FORD F-150. THE CONTACT STATED THAT ALL FOUR WINDOWS FAILED TO OPERATE AND COULD NOT BE CLOSED. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS WHERE IT WAS ADVISED TO THE CONTACT THAT THE WINDOW MECHANISM NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED AND THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 47,835. *TR UPDATED 7/15/13 *CN

MY TRUCK HAD BEEN PARKED IN MY DRIVEWAY OVERNIGHT. THIS MORNING WHEN I CRANKED UP THE TRUCK, THE PASSENGER AIRBAG DEPLOYED WITH NO WARNING. THERE WAS NO CRASH OR PREVIOUS INCIDENT SUCH AS HITTING SOMETHING WEEKS AND MONTHS BEFORE THIS. SOME RECALLS FOR THE DRIVER SIDE SUGGEST THAT A DASH LIGHT WILL INDICATE A PROBLEM WITH THE AIRBAG, HOWEVER, THIS WAS NOT THE CASE FOR MY TRUCK. THE AIRBAG SHATTERED THE WINDSHIELD SENDING SMALL PIECES OF GLASS FLYING ON THE INSIDE AND EXTERIOR OF THE TRUCK. BESIDES THE SHOCK, HOURS LATER MY HEARING IS STILL NOT THE SAME ON MY RIGHT SIDE. *TR

WHEN DRIVING AT RELATIVELY LOW SPEED, THE HOOD LIFTED VIOLENTLY. THE DRIVER WAS ABLE TO STOP THE TRUCK SAFELY. THE PORTION OF THE HOOD WHICH SECURES THE HOOD STRIKER GAVE WAY, ALLOWING THE HOOD TO OPEN SO VIOLENTLY THAT THE GRILLE FLEW OFF. THE HOOD WAS PROPERLY CLOSED/LATCHED BEFORE THE INCIDENT, AND THE STRIKER WAS STILL IN THE LATCH (COMPLETE WITH PIECES OF ALUMINUM TORN OFF OF THE HOOD) AFTER THE INCIDENT. IT APPEARS THAT GALVANIC CORROSION (STEEL STRIKER ON ALUMINUM HOOD) LIKELY CAUSED THE ISSUE. SINCE THIS TRUCK IS IN A FLEET, THE REMAINDER OF THE F-150S OF THE SAME BODY STYLE (MY2008 AND OLDER) WERE CHECKED, 65 OF 580 TRUCKS HAD EITHER CRACKING OR CORROSION AROUND THE STRIKER BAR WHICH MAY LEAD TO THIS ISSUE. NOTE - THIS IS AN ONTARIO, CANADA FLEET BUT THESE ISSUES LIKELY AFFECT US-SOLD VEHICLES. *TR

TL* THE CONTACT OWNS A 2004 FORD F-150. THE CONTACT STATED THAT WHILE THE VEHICLE WAS BEING SERVICE FOR REGULAR MAINTENANCE, THE DEALER DIAGNOSED THAT THE REAR AXLE NEEDED TO BE REPLACED DUE TO A DESIGN FLAW. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 50,938. *TR

TL* THE CONTACT OWNS A 2004 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 65 MPH, THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS DIAGNOSED THAT THE SPARK PLUGS AND COIL ASSEMBLERS NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 64,000. *TR

REPLACED TWO WINDOW REGULATORS IN VEHICLE. DRIVER'S WINDOWN AND PASSENGER WINDOW.

TL* THE CONTACT OWNS A 2004 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING ON A GRAVEL ROAD APPROXIMATELY 15 MPH, A RATTLING NOISE EMITTED FROM THE FRONT END OF THE VEHICLE. THE FAILURE RECURRED WHENEVER THE VEHICLE WAS IN MOTION. IN ADDITION, THE STEERING WHEEL WOULD SLIGHTLY VIBRATE. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.