1998 FORD F-150 Complaints

TL* THE CONTACT OWNS A 1998 FORD F-150. WHILE DRIVING 30 MPH, THE VEHICLE LOST POWER AND THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE PASSENGER SIDE CYLINDER HEAD NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 60,000.

FRAME SO RUSTED CAN'T GET A STICKER, ORIGINAL PAINT ON TRUCK. FORD WAS FACTORY UNDERCOATED WITH RUBBER TYPE UNDERCOATING. WHICH PEALED OFF AND LEFT LOTS OF RUST ON ENTIRE FRAME. NOT SAFE FOR INSPECTION. TOLD BY GARAGE, TO JUNK IT. BOUGHT NEW IN 1998.

TL* THE CONTACT OWNS A 1998 FORD F-150. THE CONTACT STATED THAT THE FUEL TANK STRAPS FRACTURED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE STRAPS FRACTURED DUE TO CORROSION AND PUNCTURED A HOLE ON THE FUEL TANK, WHICH RESULTED IN A FUEL LEAK. THE VEHICLE WAS THEN TOWED TO THE DEALER, WHO OFFERED TO REPLACED THE STRAPS FREE OF CHARGE, BUT REFUSED TO REPLACE THE FUEL TANK UNDER NHTSA CAMPAIGN NUMBER: 11V385000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 170,000.

SHOCK UPPER MOUNT SIMPLY FELL OFF CAUSING DRIVER SIDE REAR SHOCK TO DRAG GROUND. AFTER FURTHER INSPECTION ALSO NOTICED AT THE LOCATION OF THE RUSTED OUT MOUNT LOCATION THAT THE REAR WIRING FOR THE TAIL LIGHT WERE SEVERED CAUSING TRUCK TO NOW BE STUCK IN PARK. ALSO WHILE INSPECTING NOTICED REAR FRAME IS SIMPLY FALLING APART AND OTHER AREAS THROUGHOUT THE FRAME ARE WEAK AS WELL. THIS IS A HUGE SAFETY CONCERN AFTER DOING RESEARCH I AM FINDING MANY ACCOUNTS OF THE SAME ISSUE ONLINE BUT NO MANUFACTURE RECALLS. WHY ISN'T FORD DOING ANYTHING ABOUT THIS ISSUE? I'VE NEVER SEEN FRAMES DO THIS. TRUCK NEEDS FULL FRAME REPLACEMENT.

TL* THE CONTACT OWNS A 1998 FORD F-150. WHILE PARKED, THE CONTACT DISCOVERED THAT BRAKE FLUID WAS LEAKING FROM THE MASTER CYLINDER ONTO THE SPEED CONTROL DEACTIVATION SWITCH AND THE ELECTRICAL CONNECTOR WITHOUT WARNING. THE CONTACT STATED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 05V388000 (VEHICLE SPEED CONTROL). THE VEHICLE WAS NOT TAKEN TO THE DEALER OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 176,000.

TL* THE CONTACT OWNS A 1998 FORD F-150. AFTER PARKING THE VEHICLE IN THE DRIVEWAY, THE VEHICLE ROLLED BACKWARDS OUT THE DRIVEWAY AND INTO THE STREET. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE SHIFT CABLE ASSEMBLY WAS FAULTY AND THE STEERING COLUMN NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT WAS INFORMED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 97V171000 (POWER TRAIN). THE FAILURE MILEAGE WAS 270,000. UPDATED 5/18/15*CN THE DEALER INSTALLED A NEW SHIFTER CABLE. UPDATED 05/29/15*JB

I HAVE A 1998 FORD F-150 V6 4.2 LITER WITH 92435 ORIGINAL MILES. I WOKE UP THIS MORNING AND STARTED MY TRUCK UP AND THERE WAS A LOUD KNOCKING COMING FROM THE MOTOR. MY ANTI-FREEZE WAS LOW. I NOW HAVE THE SAME PROBLEM AS EARLIER POSTS OF A BENT ROD AND NEED A NEW MOTOR. I BELIEVE FORD MOTOR COMPANY SHOULD HAVE HAD THIS MOTOR RECALLED AND PROPERLY FIX THE PROBLEM. GLAD THEY HAVE THE JOB BECAUSE I AM ABOUT TO LOSING MINE. WALKING 6 MILES TO WORK TODAY. *TR

TL* THE CONTACT OWNS A 1998 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 65 MPH, THE BRAKES FAILED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE BRAKE LINES WERE CORRODED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 200,000.

IN 2012, I REPLACED MY GAS TANK BECAUSE SEVERE CORROSION HAD EATEN NUMEROUS SMALL HOLES INTO THE TOP OF THE TANK SO IT COULD NOT BE FILLED OVER 3/4TH WITHOUT LEAKING. FLAKES OF RUST WERE FALLING ONTO THE TOP OF THE TANK FROM THE FRAME X-MEMBER CAUSING THESE HOLES. THE FRAME X-MEMBER WAS NOT ADDRESSED AND THE NEW GAS TANK BEGAN TO LEAK WITHIN A YEAR AND A HALF OF REPLACEMENT. THE ENGINE WAS JUST RECENTLY TUNED UP BY A FORD DEALER BECAUSE IT WAS INTERMITTENTLY VIBRATING. WITHIN 6 MONTHS OF THIS TUNE UP, THE ENGINE LOST FULL POWER WITH FINDING OF GROSSLY CONTAMINATED FUEL. THE 2 YEAR OLD TANK WAS PULLED AND THE TOP OF THE TANK WAS REVEALED TO BE METALLIC SWISS CHEESE EQUIVALENT, THIS TIME WITH NUMEROUS VERY LARGE HOLES THAT RAIN WAS EASILY PENETRATING INTO THE TANK VIA THE CAB-BED SPACE OPENING. THE X-MEMBER FRAME SUPPORT WAS CORRODED IN HALF. THE DEALER COULD NOT FIX IT AND I PAID FOR A SECOND NEW TANK AND FUEL PUMP($350 WITH SHIPPING TO HI), POR 15 COATED THE TOP OF THE NEW TANK MYSELF, AND PAID A LOCAL BODY SHOP$1042.00 TO PULL THE X-MEMBER AND REPLACE IT WITH A USED PART AS FORD NO LONGER STOCKS (LIKELY RUSTED TO BITS IN THEIR WAREHOUSE). THE NEW TANK AND USED X-MEMBER ARE NOW INSTALLED AND AWAITING AN ENGINE MECHANIC TO ADDRESS WHY THE ENGINE WON'T START UP DESPITE NEW TANK/FRESH FUEL/PUMP/FILTER. LIKELY ANOTHER $500 TO CLEAN FUEL INJECTION/ENGINE BRINGING 2 YEAR TOTAL FOR ROTTED X-MEMBER AND TWO GAS TANKS TO WELL OVER $3000. PERUSING YOUR DATA BASE, THE FRAME RUST ISSUE SEEMS TO BE A RECURRING THEME PARTICULARLY FOR THE 1997 YEAR MODEL. MY ASSESSMENT IS THERE WAS SOMETHING VERY ROTTEN IN 1998 F150 FRAME COMPONENTS AND OR CORROSION PROTECTIONS USED. LESSONS LEARNED: DON'T FIX THE TANK UNTIL YOU FIX THE X-MEMBER PROBLEM FIRST AND FORD F150 FRAMES/CORROSION PROTECTIONS CIRCA 1998 ARE GETTING A BAD REPUTATION WHICH IS LIKELY DESERVED. *TR

GEAR SELECTOR LEVER BECAME "SLOPPY" AND I COULDN'T DEPEND ON THE SELECTOR FOR PARK, OR DRIVE GEARS. *TR