2004 FORD F-150 Complaints

Frame Failure, A licensed technician said my vehicle is dangerous to drive and cannot be fixed because of the advanced rusting of the frame. As I read the history of some Ford Trucks I find this is a continuing problem with no recalls and wonder why they can continue to manufacture faulty, dangerous products

Problem is already a recall item, took in to get fixed and the warning light continues to stay on.

The contact owns a 2004 Ford F-150. The contact stated while starting his parked vehicle, he found that the vehicle would not start. The contact self-diagnosed and bypassed the starter solenoid using a screwdriver and started the vehicle. The vehicle slipped out of the park and rolled backward. The contact was backed over by the vehicle and had received injuries to his ribs and stomach. He had lacerations and abrasions to his back and chest. The contact was able to get out from under the vehicle and attempted to stop the vehicle which was rolling. The contact jumped into the passenger side and attempted to brake but could not. The contact attempted to push the shift lever into "park" but the gear would not engage. The vehicle rolled and crashed into the rear end of a parked vehicle. The contact's vehicle had damage to the rear bumper and the rear end of the other vehicle had the bumper and trunk crumpled. The police were not called and the contact did not seek medical attention. The contact was able to start the vehicle and drove it to his residence. The contact then examined the undercarriage and determined that the transmission linkage cable had been resting on the doughnut of the exhaust system. The contact stated that the outer cable shell had melted and the metal cable was exposed. The contact diagnosed that the exposed cable had contributed to the vehicle slipping out of gear. The contact had not taken the vehicle to a dealer or an independent mechanic. The vehicle had not been repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 260,000.

The truck has had a complete body frame failure. The entire frame is rusted through with large holes. I am unable to put it on a jack to change the tires. It has failed inspections and has not been inspected since 2019. I have a 1992 ford truck that has NO rust issue on the frame. This year is a complete design failure where they used substandard steel or other garbage. It is a safety hazard.

There hasn't been any accidents but the rails underneath of the truck bed are rotting completely off the truck and I feel that would be a safety problem if it collapses and I don't understand why they're so rusty when the rest of the truck is not it this could be a problem!

Hitch broke off due to ford common frame rot. Frame is rotted from leaf spring shackle and back

Door latch not working. Doors flies open. Frozen or stuck. Doesnt latch all the time very dangerous . Happens parked and while driving

TL* THE CONTACT OWNS A 2004 FORD F-150. THE CONTACT STATED THAT WHILE THE VEHICLE WAS AT AN INDEPENDENT MECHANIC FOR ROUTINE MAINTENANCE, THE TECHNICIAN NOTICED THAT THE SUBFRAME WAS SEVERELY RUSTED THROUGH. THE VEHICLE WAS LATER TAKEN TO TONY BETTEN & SONS FORD, INC (3839 PLAINFIELD AVE NE, GRAND RAPIDS, MI 49525) WHERE THE CONTACT WAS INFORMED THAT THE DRIVER'S AND PASSENGER'S SIDE SUBFRAME WERE SEVERELY RUSTED, AND THAT THE SUBFRAME NEEDED TO BE REPLACED. THE SUBFRAME WAS NOT REPLACED NOR WAS THE VEHICLE REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 167,000.

THE TOP OF PASSENGER DASH HAS BECAME A STICKY SURFACE AND THE PAINT WILL RUB OFF. TRUCK ONLY HAS 60K MILES BECAUSE IT'S MY HUSBANDS PRIDE. VEHICLE STAYS IN A GARAGE WITH NO NATURAL LIGHT THAT COULD CAUSE PROBLEM.

WHILE DRIVING ON THE FREEWAY I NOTICE A NOISE AND A LOSE OF POWER PULL OFF AND HAD TRUCK TOWED TO DEALER THEY CALLED ME TOLD ME NEEDED NEW MOTOR I WAS SHOCKED ONLY HAS 154000 MILES ON IT WHAT THE HELL DEALER TOLD ME $9000 TO REPLACE MOTOR WHAT TOLD THEM I WOULD BE THERE TO PICK UP TRUCK WITH TOW TRUCK WELL THEY CALLED ME BACK SAID $7000 STILL WAY TO MUCH BUT I NEED THE TRUCK CANT BUY A NEW ONE SO I HAD TO GET 2 LOANS TO REPLACE MY MOTOR THEN I FIND OUT THE MOTOR IN A 2004 F 150 HAS A MAJOR ISSUES BUT THE DEALER NEVER TOLD ME ANYTHING OF THE SORT SO NOW I HAVE A TRUCK WITH THE SAME MOTOR AS BEFORE THAT COST ME A LARGE AMOUNT OF MONEY I DIDN'T HAVE FORD SHOULD STEP UP AND TAKE CARE OF THE PROBLEM SO NOW I HAVE 2 LOANS TO PAY OFF HOPE TO HELL THIS MOTOR LAST AND THEY WONDER WHY PEOPLE GO POSTAL IF FORD DOSENT RESOLVE THIS I WILL NEVER BUY A FORD PRODUCT AGAIN !!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!