2023 FORD F-150 Complaints

The contact owns a 2023 Ford F-150. The contact received notification of NHTSA Campaign Number: 23V896000 (Power Train); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at various speeds, there were a rattling sound and grinding sounds coming from the drive train of the rear axle. The dealer was contacted. The manufacturer was not made aware of the issue. The failure mileage was approximately 16,100. VIN tool confirms parts not available.

The contact owns a 2023 Ford F-150. The contact stated while driving 45 MPH, the vehicle shut off and the wheels locked up unexpectedly. The check engine warning light was illuminated, with the message “Service Soon” displayed. The contact towed the vehicle to a dealer however, the dealer was unable to determine the cause of the failure, but the battery was replaced. On another occasion, the contact took the vehicle to a different dealer, and the engine block was replaced because it was cracked. The vehicle was not repaired after the most recent failure. The contact stated that the failure was now more frequent and occurred more whenever it rained. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 20.

On three separate occasions when I open my door, I get a “brake fault service soon” notification. I’ve done research and forums say this was a recall in the past. I’m aware my truck doesn’t have any current recalls but it has me wondering if it was ever fixed or if the repair was not good enough. I never owned the vehicle when the original recall came out so I’m not too sure what happened.

The contact owns a 2023 Ford F-150. The contact stated that while driving at an undisclosed speed, the message "Active Air DAM System fault detected" was displayed. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the driver's Side Active Air Dam Motor Actuator. The contact was informed that the part displayed signs of external damage as if the driver had struck an object. The vehicle was repaired, but the failure reoccurred. The vehicle was taken back to the dealer, who again diagnosed a failure with the driver's Side Active Air Dam Motor Actuator. The vehicle was not repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 4,000.

My 2023 Ford F-150 3.5 eco boost with 35,000 approx. started having issues about 2000 miles ago with the transmission. It tends to slip gears between 3-4, 4-5 and 9-10. Sometimes it isn’t bad but other times it feels like the transmission is going to drop out from the truck. I also have an issue where the truck shifts into neutral while driving but still displays it is in drive. This doesn’t happen often but 4 times now in 2,000 miles. When this occurs I can’t put the truck back into drive and go, I have to stop, turn off the engine and wait from 5-10 minutes before I can drive away. When these issues occur there is no check engine light and the dealer said there are no snapshots recorded.

The contact owns a 2023 Ford F-150. The contact received notification of NHTSA Campaign Number: 23V896000 (POWER TRAIN); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was made aware of the issue. The contact stated while driving 65 MPH and taking his granddaughter to practice, there was an abnormal sound coming from the vehicle. There were no warning lights illuminated. The vehicle was shuddering while depressing the accelerator pedal to the floorboard; however, the vehicle failed to respond. The contact came to a stop on the highway and then pulled over. The contact turned off and restarted the vehicle and shifted into drive however, the vehicle failed to respond. The dealer was contacted and informed the contact to reach out to Roadside Assistance however, the contact was unable to get assistance. The Police Department was contacted, and a tow truck operator was contacted. The contact’s wife was able to pick up the granddaughter. The dealer diagnosed the vehicle with rear axle failure. While the vehicle was at the dealer and shifted to park, the vehicle rolled backwards and was damaged. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 22,200. VIN tool confirms parts not available.

I was driving down the interstate and the vehicle was struck by lightning. The vehicle lost all electrical power. As a result, the brakes did not work. Luckily, I was able to safely coast to a stop in the median. If the brakes can be more than 90% compromised during complete electrical failure, the vehicle should have a mechanical emergency brake.

To Whom It May Concern, I am writing to formally report a recurring water intrusion issue with my vehicle, which poses a potential safety risk. Whenever it rains and the vehicle is parked outside, water consistently leaks into the passenger-side interior. While driving, especially during acceleration or braking, I can hear the sound of water moving within the passenger side area. Upon inspection, I have found water pooling in the front passenger footwell, where multiple electrical wires are located. Additionally, there is an electrical control box situated beneath the passenger seat that may also be exposed to moisture. I also discovered water leaking behind the rear seat area. This section contains two air vents, which may be contributing to the issue. The water intrusion raises serious concerns about electrical system integrity, especially given the presence of wiring and components in affected areas. Although my vehicle has not yet experienced electrical failure while driving, I am aware of multiple reports from other owners who have encountered similar leaks that led to sudden engine shutdowns, including while driving in traffic — a serious safety hazard. I brought my vehicle to the service center for evaluation, but as of now, I have not received any resolution or updates regarding a fix. I have several videos of the situation as well. Given the potential risk to both vehicle occupants and others on the road, I respectfully request that the NHTSA investigate this matter further to determine whether a recall or other safety action is warranted. Thank you for your attention to this serious issue.

The engine and/or power train malfunctioned, rendering the vehicle difficult to bring to a stop. The longer than normal stopping distance carried the vehicle past the stop line, crosswalk and into the intersection of a crossing roadway. Anyone in the crosswalk or vehicle in the crossing roadway in the path of the vehicle would have been impacted. By placing the gear selector into Neutral, the vehicle was finally brought to stop. It is at this point I noted the tachometer read approximately 3500 RPM then slowly reduced to normal idle RPM. These aforementioned symptoms have not recurred since. The incident was brought to the attention of the manufacturer who referred me to the service department (local Ford dealer) who, in turn, did not identify any malfunctions. Service instructed me to monitor the operation of the vehicle and advise them of any problems. No malfunction codes/warnings/lights were present immediately before or after the incident.

4 or more different trailers some new some old, have been towed by our truck. With all of them the truck gave a warning that the right turn signal was out, when hooked up to a GMC Sierra the taillights all worked fine. When this happens the brake lights go out and the blinker blinks quickly. While using a trailer with its own braking system, the truck gave a fault that the trailer battery was not charging and none of the lights worked, causing a huge safety concern when coming to a stop. After turning the truck off and back on it worked fine. We took it to a Ford dealer and was first told it was the trailer, they tried it on 3 trailers the tech had and the blinker issue happened on 2 of the 3. Then they told us our trailers were too old. We refused to take it back without further diagnostics. They performed a BCM update. The next time we hooked up a trailer was this past weekend and the same issue occurred. We are hesitant to bring it back in as we need the vehicle and last time the dealership had it for over 15 days. I Due to the nature of the issues, the problem either lies in the connector, wiring, trailer control module or worse case scenario the body control module. Ironically My husbands job recently bought a ford F550, an employee driving it while pulling a trailer said it did the same thing but with the left blinker. They hooked that trailer to a Chevy truck and all worked fine. This is clearly an issue with Fords Trailering system. What steps should we take to get this fixed. We haul a lot of trailers. The truck has just over 5000 miles on it.