1997 FORD F-150 Complaints

1. REGULAR BRAKING WAS DISABLED BY MALFUNCTIONING ABS FIRING. FOR NO APPARENT REASON, IN DRY AND SLOW CONDITIONS ON CITY STREETS, BRAKES WERE NOT ALLOWED TO ENGAGE PROPERLY, RESULTING IN THE TRUCK ROLLING FORWARD AS THE ABS SYSTEM FIRED. 2. IN TRYING TO STOP THE TRUCK, WITH THE BRAKES FULLY ENGAGED TO THE FLOOR, THE PEDAL VIBRATED FROM ABS ACTIVITY AND THE TRUCK CONTINUED TO ROLL FORWARD INTO INTERSECTION. AT FIRST THIS ONLY HAPPENED ON THE FIRST STOP OF THE DAY, EVERY FEW MONTHS OR SO. LATER IT HAPPENED FREQUENTLY. I FOUND THAT IF I QUICKLY SHUT OFF THE IGNITION THE (ELECTRONIC) ABS WOULD BE DEACTIVATED AND THE TRUCK WOULD STOP NORMALLY. 3. CHANGING FRONT BEARINGS AND ASSOCIATED SPEED SENSORS SOLVED THE PROBLEM. DEALER PART AND INSTALLATION WAS AROUND $1200, BUT GENERIC PARTS WERE AVAILABLE THAT SHAVED SEVERAL HUNDRED OFF THIS TOTAL REPAIR COST. *TR

1997 FORD F150, WE WERE ACCELERATING ON THE HIGHWAY FROM 30 MPH OUT OF A CONSTRUCTION ZONE BACK TO HIGHWAY SPEED (65MPH). THE TRUCK HAS AN AUTOMATIC TRANSMISSION AND CRUISE CONTROL. CRUISE CONTROL WAS NOT ACTIVATED. SUDDENLY, THE VEHICLE STUCK INTO FULL ACCELERATION MODE. SHARPLY APPLYING THE BRAKES HAD NO EFFECT IN SLOWING THE VEHICLE. THE FOOT ACCELERATOR WAS DOWN FULLY, THE FLOOR MAT WAS NOT INVOLVED. THE DRIVER TRIED TO LIFT THE FOOT ACCELERATOR WITH HER TOE, BUT IT WAS STUCK DOWN FULLY. IT COULD NOT BE LIFTED. WITHIN 2 MILES THE VEHICLE WAS ACCELERATING WELL PAST 100 MPH. CARS AHEAD WERE STOPPED AT A TRAFFIC LIGHT. IN DESPERATION WE REPEATEDLY HIT THE BRAKE HARD AND SUDDEN WITH FULL EFFORT. THERE WAS A POP AND THE ACCELERATOR CAME BACK UP. THE TRUCK WAS PULLED OVER AND INSPECTED THERE WAS NO APPARENT ISSUE WITH THE ACCELERATOR PETAL. IT MOVED EASILY AND NORMALLY. THE TRUCK WAS STARTED AND TEST DROVE, AND EVERYTHING INCLUDING THE CRUISE CONTROL WORKED NORMALLY. WE CONTINUED DRIVING WITHOUT ANY FURTHER INCIDENT. I ASSURE YOU IT WAS NOT DRIVER FAULT THERE IS SOMETHING THAT ACTIVELY PULLS THE ACCELERATOR DOWN EVEN WHEN THE CRUISE IS NOT ACTIVATED. HITTING THE BRAKE DID NOT STOP THE ACTIVATION. THIS WAS A CLOSE CALL AND WE HAVE VERY CREDIBLE WITNESSES AND DRIVERS TO EXPLAIN IN DETAIL WHAT HAPPENED. THE VEHICLE HAS ABOUT 189000 MILES ON IT AND HAS NEVER DONE THIS BEFORE THAT WE KNOW OF. WE BOUGHT IT USED, AND IT IS IN ORIGINAL CONDITION, NO AFTER MARKET GASKETS OR ALTERATIONS. JAMES GIBSON *TR

TL*THE CONTACT OWNS A 1997 FORD F150. THE CONTACT STATED THAT THE BRAKE LIGHTS ARE INOPERATIVE. AS A CONSEQUENCE, HE WAS UNABLE TO NOTIFY OTHER DRIVERS WHEN HE ATTEMPTED TO STOP. AN AUTHORIZED TECHNICIAN REPLACED THE WIRING ASSEMBLY IN THE BRAKE LAMP CONTROL AT AN EXPENSE OF $115.11. THE MANUFACTURER WAS NOTIFIED , BUT NO ASSISTANCE WAS PROVIDED. THE FAILURE AND CURRENT MILEAGES WERE 163,000. UPDATED 10/27/09 *CN THE CONSUMER STATED THE LIGHTS ONLY COME ON WITH EXTREME PRESSURE ON THE BRAKE PEDAL. UPDATED 10/28/09.*JB

1997 FORD F150 WITH 4.2L ENGINE. STARTED CAR IN THE MORNING. MADE A GRINDING SOUND AND STOPPED IT. RESTARTED THE MOTOR AND IT RATTLING LOUDLY AND STOPPED IT AGAIN. THE NUMBER ONE PISTON BENT THE CONNECTING ROD. *TR

PULL GEAR SHIFTER DOWN TO D1 AND SMOKE AND FIRE CAME OUT OF THE STEERING COLUMN: ALL OF THE INSTRUMENT LIGHTS WENT OUT AND THE TRUCK WAS UNABLE TO USE THE OVERDRIVE FUNCTION. REPLACED SEVERAL FUSES AND TRIED AGAIN WITH THE SAME RESULTS. I DISMANTLED THE STEERING COLUMN AND NOTICED THAT THE WIRING HARNESS IS TWO SHORT AND ROUTED AROUND THE STEERING COLUMN CAUSING IT TO BREAK EVERYTIME THE TRUCK IS PUT INTO D1. FORD MOTOR COMPANY NOR ANY AUTO STORE HAVE ANY PARTS TO REPAIR THE PROBLEM. THE TRUCK IS STILL AVAILABLE FOR INSPECTION. I TOOK MY TRUCK TO A FORD DEALER AND THEY DID NOT HAVE A FIX FOR THE PROBLEM. THEY RECOMMEND THAT I NOT USE D2/D1/OVERDRIVE. *TR

AFTER DRIVING ABOUT 2 MILES AND PARKING THE VEHICLE, AN ENGINE COMPARTMENT FIRE STARTED ABOUT 15 MINUTES AFTER LEAVING THE VEHICLE. *TR

TL*THE CONTACT OWNS A 1997 FORD F-150. WHILE DRIVING 65 MPH IN A RAINSTORM, THE WINDSHIELD WIPERS STOPPED WORKING. THE CONTACT PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD. HE WAS ABLE TO DRIVE THE VEHICLE AFTER THE RAIN STOPPED. A MECHANIC STATED THAT THE GEM MODULE WAS DEFECTIVE AND REINSTALLED THE GEM MODULE, AS WELL AS INSTALLED A NEW IGNITION SWITCH. THE WIPERS FAILED AGAIN WHILE DRIVING IN NORMAL CONDITIONS. THE MECHANIC STATED THAT THE GEM MODULE HE INSTALLED FROM FORD WAS DEFECTIVE. AFTER THE REPAIR, THE WARNING LIGHTS ILLUMINATED, INCLUDING THE AIR BAG LIGHT. THE MECHANIC CANNOT DIAGNOSE THE CAUSE OF THE FAILURE AND DETERMINE IF THE AIR BAGS WORK. PRIOR TO THE GEM MODULE FAILURE, SEVERAL COMPONENTS WERE REPLACED ON THE VEHICLE. AT 30,000 MILES, THE ENGINE WAS REBUILT. THE CURRENT AND FAILURE MILEAGES WERE 125,000.

TL*THE CONTACT OWNS A 1997 FORD F-150. AFTER MAKING A RIGHT TURN AT 10 MPH, THE PIN IN THE STEERING COLUMN FELL OUT. THE CONTACT LOST CONTROL OF THE VEHICLE AND MANAGED TO STOP ON THE SIDE OF THE ROAD. THE VEHICLE WAS TOWED TO A PERSONAL MECHANIC. THE MANUFACTURER STATED THAT THEY NEVER HEARD OF THIS FAILURE AND COULD NOT ASSIST. THE CURRENT MILEAGE IS 160,000 AND FAILURE MILEAGE WAS 150,000. THE STEERING SHAFT COUPLER SHEERED OFF. UPDATED 05/29/09*JB

TL*THE CONTACT OWNS A 1997 FORD F-150. THE CONTACT STATED THAT THE VEHICLE WOULD KICK IN AND OUT OF 4-WHEEL DRIVE. WHILE DRIVING LESS THAN 55 MPH, THE STEERING WHEEL BECAME STIFF AND THE 4-WHEEL DRIVE BECAME INOPERABLE. THE 4-WHEEL DRIVE WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. THE DEALER COULD NOT DUPLICATE THE FAILURES. ON A SEPARATE OCCASION, THE FAILURE RECURRED. THE DEALER ADVISED THE CONTACT NOT TO SHUT OFF THE ENGINE. THEY REPLACED UNKNOWN MODULES IN THE TRANSMISSION AT THE COST OF $607. THE DEALER ALSO INSTALLED A NEW DASHBOARD SWITCH AT NO COST DUE TO THE FACT THAT THE VEHICLE HAD BEEN THERE FOUR TIMES WITH THE EXACT SAME FAILURES. THE CURRENT AND FAILURE MILEAGES WERE LESS THAN 53,000. UPDATED 04-24-09 *BF UPDATED 04/27/09.*JB

TL*THE CONTACT OWNS A 1997 FORD F-150. WHILE DRIVING OVER A BUMP AT 30 MPH, THE CONTACT HEARD A LOUD NOISE AND NOTICED THAT THE REAR DRIVER'S SIDE COIL SPRING FAILED AND WAS STRIKING AGAINST THE TIRE. THE MANUFACTURER STATED THAT HIS VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 98V161000 (SUSPENSION: REAR: SPRINGS: LEAF SPRING ASSEMBLY). IF THE CONTACT REPAIRS THE VEHICLE, THE MANUFACTURER WILL OFFER A TWO MONTH WARRANTY FOR THE REAR SPRING. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 100,000 AND CURRENT MILEAGE WAS 126,000. UPDATED 06/12/09 *BF UPDATED 06/16/09